Kiturami KF-35B Manuale utente
SU 120417
•Common KF - 35B
Make sure to keep the user's manual in the vicinity
of the boiler, after reading it.
The user’s manual describes the features of the product and the safety
requirements. Please read and make sure you fully understand the user’s manual
before using the products to ensure an extended lifecycle.
User's Manual
Kiturami
Firewood Boiler
Thank you for purchasing a KITURAMI boiler. Please carefully read and make sure you
fully understand the user’s manual to ensure correct operation and maintenance of the product,
and keep the manual safe. If the boiler operates abnormally or you have any questions about its
functions, etc., please refer to the manual.
Structure and Name
How to Operate
Precautions for Operation
How to Clean
How to Install
Test Operation and Installation of the Indoor Thermometer
Specifications for the Boiler
Troubleshooting
Memo
03
04
07
09
09
14
15
16
18
Hazard or unsafe practices that may result in severe personal injury or death.
Hazard or unsafe practices that may result in severe personal injury or death.
To reduse the risk of fire, explosion, electric shock, or personal injury when using boiler, please
refer to the manual carefully.
▲Precautions for Safety
※The user’s manual uses symbols to indicate that caution should be exercised to prevent accidents caused by
incorrect operation, or damage to the users and their properties. Please carefully read and make sure you fully
understand the symbols and their meanings to ensure correct operation of the product.
※The precautions are classified into three categories:
DANGER
WARNING
CAUTION
3
Structure and name
KF-35B
Flue
Flue
Frame monitoring
window
Firewood feeding
door handle
Blower
cover
Handle
movement
Controller
Automatic air control
Hot water inlet
Heating water outlet
Hot water outlet
Controller
cover
Back of flue
cleaning port
Heating water
collection
Controller cover
<Front>
<Right>
Included accessories: The KF-35B User s Manual, cleaning tools, and corrugated drain pipe.
How to Operate
4
Name of Each Component (CTC-3550N)
Boiler water
temperature
Water temperature
in the boiler.
Exhaust function
lamp
This lamp is turned
on when the boiler
exhaust fan works.
Circulation pump
lamp
The water is being
circulated.
Low water-level
lamp
The water is
insufficient in the
boiler.
Season selection
button
You can set the
heating water
temperature. You
can set the
preferred
temperature.
Power S/N
Boiler operation
switch (ON/OFF)
5
How to Operate
Name of Each Part of the Room Thermostat (CTR-6070)
LED
DISPLAY
LED
VOLUME
S/W+LED
S/W+LED
SWITCH
• Display of current temperature in
numbers.
•
LED is lit if the room controller works.
• Room temperature setting volume
•
Setting and display for the room function
•
Setting and display for the bath function
• his switch is used to turn the power of
the boiler on/off. After turning off and on,
manual return is done.
•
In case of am abnormality in the boiler,
the LED flashes.
•
If the Option function works, display of
the operation.
• Flash of LED in case of a boiler
abnormality (check)
• Operation at set temperature
• Initial mode
• Option function: Heating water
temperature setting function
• Water temperature is maintained at
83°C(adjustable).
• Automatic return to heating function
after 2.5 hours.
• Option function: Hot water temperature
setting function
• Manual return (restart) is possible up to 3
times. (Clear after 5 minutes)
No.
1
2
3
4
5
6
Name Component Function. Remarks
Operation
/check
Room
temperature
setting switch
Function
selection
ROOM
BATH
Power
/Restart
button
Current
temperature
Hot Water
Temp.
Operation
POWER
ROOM
BATH
5
4
3
1
2
How to Operate
6
How to Ignite the Firewood
1) Ignition throgh using tinder
2) Ignition Through Using the Wood
3) Insert wood in a good size enough to close the wood hatch completely.
Ex) The burning time may be differ with the kind of wood and, in general, 20kg of firewood may
be burnt for 4-5 hours.
Stack completely dried wood (thin wood) in the firebox in a zigzag pattern and light the firewood
using paper or cardboard box scraps.
-> Continuous combustion is possible through adding more firewood as soon as wood is lit
<When inserting the firewood>.
Insert wood in a good size enough to close the wood hatch completely
Put the "Tinder" in the central part of the firebox, add the firewood, and light the Beongaetan
using papers, etc. Keep the ashtray hole open until the firewood is ignited to a certain level.
When the firewood is completely lit close the hole.
·ON/OFF Set point of fan and circulation pump
Fan
ON OFF ON OFF
Heating water temp. Setting
Summer (45)
Autumn (55)
Spring (65)
Early winter (75)
Winter (85)
Circulation pump
45
48
56
64
64
50
55
65
75
75
48
50
58
67
74
43
45
46
53
55
7
Precautions
Precautions
The boiler shall be inspected once a year.
Request your distributor to conduct periodic inspections of the boiler
(i.e., once or twice a year).
You can operate the boiler safely only when the boiler has been properly inspected.
Prevent frozen rupture during winter season.
If the product is connected to the pipes, and the pipes are fully filled with water,
connect the power cable to the outlet. If there is insufficient water in the pipes, then
supply water to the pipes in accordance with the water makeup method. Operating
the rupture prevention circuit when the pipes are filled with insufficient water may
cause the pump to run idle or cause overheating or failure of the pump.
Fully insulate the pipes.
Take the appropriate actions to prevent a frozen rupture by, for example, winding
heating coils around the exposed pipes in the cold area.
(It is also desirable to install the pipes adjacent to the heating pipes for insulation.)
Do not wrap the water drain valve with an insulator.
When you do not use the boiler for an extended period, drain the water from the
boiler to prevent a frozen rupture, and disconnect the power cable from the outlet.
The exposed pipes should be wrapped with an insulator 25mm thick or more to
prevent the pipes from freezing (50 mm or more in cold areas)
f you leave your home for a number of hours, open the hot water tap in the kitchen
slightly to allow a small volume of water to flow into the hot water pipe to prevent a
frozen rupture of the tap water pipe.
Use the power outlet exclusive for the boiler, and be cautious for leakage.
The operating power is AC 230 and 50 Hz. Operate the boiler only after checking
the voltage.
Do not touch the power cable or operate the boiler with wet hands to avoid
electric shock. Never clean the boiler with water as a leak, shock or failure of
the boiler may result.
Do not place combustible or inflammable materials in the vicinity of the boiler.
Put a fire extinguisher in the boiler room
Do not stack wooden materials or place inflammable or combustible materials
in the vicinity of the boiler, and keep the area surrounding the boiler clea
Never touch the stovepipe while you operate boiler.
You may get burnt.
Never disassemble, repair or modify without approval of the manufacturer.
Shock or fire may result.
Contact the local distributor when the boiler needs repairing.
DANGER
WARNING
WARNING
WARNING
CAUTION
WARNING
Precautions
8
Install the boiler in a structure where cleaning is easy.
The use of wet wood requires frequent cleaning due to resin; use dry
firewood if possible.
If you use wet wood, you should clean the boiler every 3-4 days.
In a power failure, be careful about overheating.
If electric power is not supplied, the blower and circulation pump do
not work and the risk of overheating and fire is increased.
Do not add an excessive quantity of fuel at anytime.
If an excessive large quantity of fuel is added, the hot water or steam
can burn you, as overheating is likely to occur.
When opening/closing the wood hatch, be careful to not burn your self.
When opening the wood hatch, open the door in a lateral direction in
order to avoid possible heat burns.
After adding firewood, tightly close the inlet.
The sparks may cause a fire in the surroundings area.
As sparks may be dispersed resulting in a fire during the time to treat
the ash, clean the product after the complete removal of embers.
Cautions in using wood fuel
Use the designated fuel only.
Firewood can only be used in this boiler. Use of other fuel (brown coals,
briquettes, or household waste may reduce the lifetime of the product
and should be prohibited.
※
Our product DO NOT gurantee any flaw occurred by using material EXCEPT wooden fuel like oval
briquets, brown coals, etc,.
WARNING
WARNING
CAUTION
WARNING
WARNING
WARNING
9
How to clean
How to clean the firewood combustion chamber
Especially, if firewood is used, the boiler should be cleaned at least once a week in
order to save on fuel costs.
※Note: When cleaning the cleaning port, fire chamber, or flue, disconnect
the exhaust fan and open the door.
How to install
▶Conditions to be checked prior to installation
The product shall be installed by authorized engineer pursuant to the methods stipulated in the users
manual.
Install a boiler suitable for the purpose of use and the CH area.
Install the boiler in a location such that exhaust gas or noise from the boiler does not cause
inconvenience to the users or to residents in the vicinity of the boiler’s location.
Do not install the boiler in a location adjacent to areas frequently accessed by people, such as a
staircase or emergency exit.
Secure sufficient space for the operation, inspection and repair of the boiler (1 m or more at the
front,rear, and left- and right-hand sides of the boiler).
The use of water (for CH) containing a large quantity of lime or salinity causes corrosion of the
product. Always use tap water if possible.
1Cleaning upper part
2Cleaning lower part
push out the ash using an ash cleaning tool
Indice
Altri manuali Kiturami Caldaia
Kiturami
Kiturami eco condensing - 16D Guida utente
Kiturami
Kiturami KF Manuale utente
Kiturami
Kiturami KRH-35B Manuale utente
Kiturami
Kiturami TURBO-21 Manuale
Kiturami
Kiturami Elite Fire Tube Combi Manuale di installazione
Kiturami
Kiturami KRP-20A Manuale utente
Kiturami
Kiturami KRH-35B Guida utente
Kiturami
Kiturami PELLET BOILER Manuale utente
Kiturami
Kiturami WORLD PLUS-13D Manuale
Kiturami
Kiturami K1-22E Manuale utente
