Matrix T5 Manuale utente

Note: The Motor Fly Wheel and the Front Roller Pulley need to be in parallel. If not the Drive Belt will not run

straight and could cause damage to the belt or speed sensor.

Unit shown is a T5 model treadmill. The steps are the same for a T4 or T5x treadmill also.

1. Measure the parallel angle from the 2. The Motor Fly Wheel tolerance 3. If the tolerance is out of spec you

Front Pulley to the Motor Flywheel should be +/-.5mm gap will need to adjust the motor using

a 15mm socket and a long extension

on a ratchet.

4. Measure the parallel angle from the 2. The Motor Fly Wheel to Idler gap 3. If the tolerance is out of spec you

Motor Flywheel to the Idler should be 12mm +/-.5mm gap will need to adjust the Idler using a

5mm Allen Wrench on the Idler bolts

5 / T4 Drive Belt Alignment SOP Instructions

Drive Belt Ali

nment

OP Instructions

Tools Needed

1. Ruler or Jig

2. 3/8 Drive socket

3. 3/8 Drive Long Extension

4. 15mm Socket

5. 5mm Allen Wrench

6. Pry Bar

Installation Time:

Approximately 40 minutes

Installation Steps

1000311 Rev 3

1. To Adjust the belt use a prybar to 2. To adjust the front roller you will need to loosen the front roller bolts. The

pull up on the idler to release the Left side (pulley side) has a 5mm allen bolt and the Right side has a

tension. Now position the belt 8mm Allen bolt and a 15mm nut. Loosen these bolts and you can

correctly on the front roller pulley shift the Front roller side to side. Once in place tighten down.

and motor flywheel pulley.

3. You may need to loosen the rear 4. Insert the 8mm Allen bolt into the rear end cap and turn counter-

roller to loosen the belt. clockwise to loosen. You need to loosen the left and right sides.

Adjusting the Drive Belt & Front Roller

Altri manuali per T5

Questo manuale è adatto per i seguenti modelli

Altri manuali Matrix Tapis roulant

Manuali Tapis roulant popolari di altre marche

Treadly

Treadly TREADLY 2 Manuale utente

HEALTH ONE

HEALTH ONE Walk Ro Manuale utente

NordicTrack

NordicTrack NTL12941 Manuale utente

NordicTrack

NordicTrack T7.5 S Manuale utente

Gold's Gym

Gold's Gym ADVANTAGE GGTL12920 Manuale utente

Merax

Merax MS282992 Manuale utente

FYTTER

FYTTER RU-2SX Manuale utente

Precor

Precor 903 Manuale utente

FitLogic

FitLogic freewill d225 Manuale utente

HOP-SPORT

HOP-SPORT ESTIMA HS-3200LB Manuale utente

Horizon Fitness

Horizon Fitness Adventure 5 Plus Manuale utente

Stamia

Stamia InMotion II Manuale utente

Smooth Fitness

Smooth Fitness EVO 3i Manuale utente

NordicTrack

NordicTrack NETL81810.0 Manuale utente

Schwinn

Schwinn 830/Journey 8.0 Manuale utente

Keys Fitness

Keys Fitness HealthTrainer HT-740T Manuale utente

Spirit

Spirit XT8 Manuale utente

NordicTrack

NordicTrack T 14.0 Treadmill Manuale utente