Optoma EP773 Manuale di istruzioni

Model Name : EP773

SERVICE MANUAL

Date Revise Version Description

2006/12/15 V0.1 Initial Issue

95.86R01GC0A; 95.86R01G00A; 95.86R01GC01; 95.86R01GC0B;

95.86R01GC0C; 95.86R01GC0E; 95.86R01GC0H; 95.86R01GC0J;

95.86R01GC0K; 95.86R01GC0L; 95.86R01GC0T

Prepared by SI :

________________________________________

Prepared by TSE :

________________________________________

Check by :

________________________________________

Approved by :

________________________________________

This manual is applied to EP773 projection system. The manual gives you a

brief description of basic technical information to help in service and maintain

the product.

Your customers will appreciate the quick response time when you immediate-

ly identify problems that occur with our products. We expect your customers

will appreciate the service that you offer them.

This manual is for technicians and people who have an electronic

background. Please send the product back to the distributor for repairing

and do not attempt to do anything that is complex or is not mentioned in the

troubleshooting.

Notice:

The information found in this manual is subject to change without prior

notice. Any subsequent changes made to the data herein will be incorporated

in future edition.

EP773 Service Manual

Manual Version 0.1

EP773

Preface

Conﬁdential

Table of Content

EP773

Chapter 1 Introduction 1-1

Highlight 1-1

Compatible Mode 1-3

Chapter 2 Disassembly Procedure 2-1

Equipment Needed & Product Overview 2-1

Disassemble Lamp Module 2-2

Disassemble Top Cover Module 2-3

Disassemble Top Shielding Module 2-4

Disassemble Keypad Board and Keypad Button 2-5

Disassemble IR Receiver 2-6

Disassemble IO Cover 2-7

Disassemble Light Cut Mylar 2-8

Disassemble Airduct Module 2-9

Disassemble Isolator Mylar 2-10

Disassemble Main Board 2-11

Disassemble DMD Fan 2-12

Disassemble System Fan 2-13

Disassemble Side Shielding Module 2-14

Disassemble Lamp Driver Module 2-15

Disassemble LVPS Module 2-16

Disassemble Engine Module 2-17

Disassemble Power Module Holder 2-18

Disassemble Thremal Switch 2-19

Disassemble Heatsink and 2 Springs 2-20

Disassemble DMD Board and DMD Chip 2-21

Disassemble Color Wheel and Photo Sensor Board 2-22

Disassemble Zoom Ring 2-23

Disassemble Focus Ring 2-24

Disassemble Blower 2-25

Disassemble Interrupt Switch 2-26

Disassemble Bottom Base 2-27

Disassemble Front Lower Panel 2-28

Disassemble Front Shielding Module 2-29

Conﬁdential

Chapter 3 Troubleshooting 3-1

LED Lighting Message 3-1

Main Procedure 3-2

System Block Diagram 3-5

Chapter 4 Function Test & Alignment Procedure 4-1

Test Equipment Needed 4-1

Service Mode 4-1

Reset(OSD) 4-2

Test Condition 4-2

Inspection Procedure 4-3

Chapter 5 Firmware Upgrade 5-1

Equipment Needed 5-1

Installation Procedure 5-2

USB Driver Upgrade Procedure 5-4

Firmware Upgrade Procedure 5-6

Chapter 6 EDID Upgrade 6-1

EDID Introduction 6-1

Equipment Needed 6-1

Setup Procedure 6-2

EDID Key In Procedure 6-2

Appendix A 7-1

Appendix B 7-26

Serial Number System Deﬁnition 7-26

PCBA Code Deﬁnition 7-27

Reader’s Response 7-28

Conﬁdential iii EP773

1-1 EP773Conﬁdential

No Item Description

1 Dimensions (L x W x H) - 348 x 258 x 110 mm

2 Weight - Approx. 7.2 Ibs

3 Tilt Angle - 7 degree with elevator mechanism

4 Power Supply - Universal AC 100—240V; 50 / 60 Hz with PFC

input

5 Lamp Housing

- Lamp could be changed by customer, but should

follow the user manual instruction.

- Replaceable Lamp should be provided by

Coretronic or its authorized agencies

6 Keystone correction - +/ -15 degree

7 Color

- Top Cover: Pantone Cool Gray 6C

- Bottom Base: Pantone 446C

- Side/Back covers: Pantone 446C

- Lens rim/Zoom ring/Focus ring: Pantone 446C

- Keypad: Pantone Cool Gray 6C

8 Input signal spec

- PC Signal (analog)

- Hsync Frequency 15k ~ 80 kHz (PC & Video)

- Vsync Frequency 50 ~ 85 Hz (PC & Video)

- Video Signal RGB (PC)

- Analog RGB 0.7Vp-p, 75 ohm

- Analog RGB 1Vp-p, 75 ohm, Sync. Signal

- Separate TTL H,V Sync.

- Composite TTL Sync.

- Video

- Composite video 1Vp-p,75 ohm

- S-video

- Luminance 0.714Vp-p,75 ohm

- Chrominance 0.286Vp-p,75 ohm

Chapter 1

Introduction

1-1 Highlight

1-2 EP773

Conﬁdential

No Item Description

9 Cooling System

- Advanced air ﬂow

- Three fans with low system acoustic noise level

- Temperature control circuits with adaptive voltage

control fan speed

- Maximum touch temperature follows UL60950-1

regulation

10 Brightness

- 3500 ANSI Lumens (Marketing)

- 3000 ANSI Lumens (Typical)

- 2550 ANSI Lumens (Minimum)

11 Contrast

- 2200:1 Marketing (Full White and Black)

- 1500:1 Typical (Full White and Black)

- 1000:1 Minimum (Full White and Black)

12 Uniformity

- 85% Marketing (Japan standard)

- 75% Typical (Japan standard)

- 60% Minimum (Japan Standard)

13 Throw Ratio -2.0~2.4:1

14 Lamp Door Protection - Lamp power supply shut off automatically when

door open

15 Projection lens

- f = 28.04 mm ~ 33.59 mm @2.4m

- F/2.4 ~ 2.65 @2.4m

- 1.2X Manual Zoom Lens

16 Lamp life

- 2000 hours min, 50% survival rate

(BRIGHT MODE e)

- 3000 hours min, 50% survival rate (STD MODE)

1-3 EP773Conﬁdential

No Item Description

17 System Controller - TI DDP2000

18 Video Compatibility

- Standards :

NTSC: M (3.58MHz), 4.43 MHz

PAL: B, D, G, H, I, M, N

SECAM: B, D, G, K, K1, L

HDTV: 480i/p, 576i/p, 720p, 1080i

19 Intelligent Zoom - By using “DDP2000” Chip to provide excellent

quality zooming

20 SXGA / Compression - By using “DDP2000” Chips to compress SXGA

image into XGA display

21 Power Consumption

- Full power mode: 325W + 10% at 110Vac.

- Dim mode: 280W + 10% at 110Vac.

- Standby mode: <12W

22 Color Wheel - R90G80B74W86Y30

23 Lamp - E20.6 260W OSRAM

24 Temperature - Operating: 5 -- 35°C

- Storage: -20 -- 60°C

1-4 EP773

Conﬁdential

1-2 Compatible Mode

Mode Resolution V-Sync (Hz) Horiz.Freq.(KHz)

VGA 640x350 70 31.5

640x350 85 37.9

640x400 85 37.9

640x480 60 31.5

640x480 72 37.9

640x480 75 37.5

640x480 85 43.3

720x400 70 31.5

720x400 85 37.9

SVGA 800x600 56 35.2

800x600 60 37.9

800x600 72 48.1

800x600 75 46.9

800x600 85 53.7

XGA 1024x768 60 48.4

1024x768 70 56.5

1024x768 75 60.0

1024x768 85 68.7

SXGA 1280x1024 60 63.98

1280x1024 75 79.98

SXGA+ 1400x1050 60 63.98

Analog

1-5 EP773Conﬁdential

Mode Resolution V-Sync (Hz) Horiz.Freq.(KHz)

MAC LC 13’’ 640x480 66.66 34.98

MAC II 13’’ 640x480 66.66 35

MAC 16” 832x624 74.55 49.725

MAC 19” 1024x768 75 60.24

MAC 1152x870 75.06 68.68

MAC G4 640x480 60 31.35

I MAC DV 1024x768 75 60

1152x870 75 68.49

1280x960 75 75

1-6 EP773

Conﬁdential

Mode Resolution V-Sync (Hz) Horiz.Freq.(KHz)

VGA 640x350 70 31.5

640x350 85 37.9

640x400 85 37.9

640x480 60 31.5

640x480 72 37.9

640x480 75 37.5

640x480 85 43.3

720x400 70 31.5

720x400 85 37.9

SVGA 800x600 56 35.2

800x600 60 37.9

800x600 72 48.1

800x600 75 46.9

800x600 85 53.7

XGA 1024x768 60 48.4

1024x768 70 56.5

1024x768 75 60.0

1024x768 85 68.7

SXGA 1280x1024 60 63.98

SXGA+ 1400x1050 60 63.98

Digital

Altri manuali per EP773

Indice

Altri manuali Optoma Proiettore

Manuali Proiettore popolari di altre marche

iEmmet

iEmmet MP-312 Manuale utente

Epson

Epson VS400 Manuale utente

Sony

Sony VPL-HS10 Marketing Specifications & Features Manuale utente

Sony

Sony VPL-HW65ES Manuale di servizio

Toshiba

Toshiba TLP-791U Manuale utente

Philips

Philips LC1341 Guida di riferimento

Panasonic

Panasonic PTL735NTU - LCD PROJECTOR-NETWORK IB Manuale utente

NEC

NEC NP600S EDU Manuale utente

BenQ

BenQ SH753P Manuale utente

Eiki

Eiki EK-623U series Manuale utente

Epson

Epson PowerLite Pro Cinema 6020UB Manuale utente

Epson

Epson PowerLite Home Cinema 705HD Manuale utente

Christie

Christie LHD700 Manuale utente

Navitar

Navitar FX Manuale utente

InFocus

InFocus LitePro 560 Manuale utente

Sony

Sony SRX-R815P Manuale utente

Vivitar

Vivitar DP1500 X Manuale utente

Acer

Acer C20 Series Manuale utente