Panasonic ES4033-A3 Manuale utente
1 SCHEMATIC DIAGRAM 2
2 WIRING CONNECTION DIAGRAM 2
3 DISASSEMBLY INSTRUCTIONS 3
4 CAUTION IN ASSEMBLY 6
©2004 Matsushita Electric Works, Ltd. All rights
reserved. Unauthorized copying and distribution is a
violation of law.
ES4033-A3
ES4035-A3
5 TROUBLESHOOTING GUIDE 9
6 EXPLODED VIEW 10
7 REPLACEMENT PARTS LIST 11
AC/Rechargeable Shaver
SPECIFICATIONS
Power source
A
C 220V, 50-60Hz (Automatic voltage conversion)
Motor voltage 1.2V DC
Charging time 1 Hour for ES4035, 8 Hours for ES4033
Shaves per charge 7 times (3 minutes shave)
Measurement (H)14.6 x (W)5.7 x (D)4.9 cm
Weight 155g
Supplied accessories Soft case
Cleaning brush
CONTENTS
Page Page
ORDER NO. SD0406A47C3
1 SCHEMATIC DIAGRAM
2 WIRING CONNECTION DIAGRAM
2
ES4033-A3 / ES4035-A3
1. Remove the cap, the outer foil with foil frame and the inner
blade.
2. Slide the trimmer handle up to open the trimmer and
unhook the trimmer handle by inserting something like a
plastic spatula into a slit.
NOTE: Make sure not to scratch or damage on the
housing.
3. Remove trimmer and trimmer handle.
3 DISASSEMBLY INSTRUCTIONS
Follow the procedure below to disassemble the main unit.
3
ES4033-A3 / ES4035-A3
4. To remove the trimmer driving bar, press it outward.
5. Loosen a screw and remove the bottom cover.
6. Peel off the side panels on both sides.
7. Loosen two screws and the retaining plate. Remove the
waterproof rubber.
8. Remove the two screw covers using something like a
toothpick and six screws.
4
ES4033-A3 / ES4035-A3
9. Take out the housing B.
10. Remove the motor assembly first. And take out the module
assembly from housing A.
11. Remove the battery o-ring and washer from battery
terminal. Take out the rechargeable battery from the
chassis.
5
ES4033-A3 / ES4035-A3
NOTE: When reassembling, replace the new waterproof
rubber.
Make sure whether there is NO foreign substance sticking
around a part covered with water seal.
4.1. Driving heads
Install the driving head A in motor and assemble the driving
head B.
4.2. Rechargeable battery
Insert the rechargeable battery into chassis. Attach the battery
o-ring and washer to the battery.
4.3. Motor and Module assembly
Put the motor and module assembly from the battery terminal
side into housing A, and insert the driving heads side into
housing A.
NOTE: Make sure that the red lead wire is not over the
chassis rib.
Press fit the red lead wire neatly under the rib of motor
holder and the blue lead wire in between batteries certainly
in order to protect pinching.
4 CAUTION IN ASSEMBLY
6
ES4033-A3 / ES4035-A3
4.4. Housing
Set the both sides of foil frame release buttons with springs.
Put the housing B on the housing A.
Tighten the screws with care of pinching screw o-rings.
4.5. Waterproof rubber
The waterproof rubber must be fitted the right way around.
Install as shown in figure by inserting firmly to the proper
position.
4.6. Driving bar
Set the trimmer driving bar.
7
ES4033-A3 / ES4035-A3
4.7. Side panel
Set the side panel on the body and press fit until clicking the
hook of panel at three locations. Fit the hook on top first, then
front side and rear side.
NOTE: Make sure that the left and right side panels are
firmly fitted on both rear and front side.
4.8. Trimmer
1. Make sure if the bosses of handle arm insert into the holes
of trimmer.
2. Align the bosses of housing with the holes of trimmer, and
hook the trimmer handle.
3. Confirm its operation or smooth movement of trimmer.
8
ES4033-A3 / ES4035-A3
5 TROUBLESHOOTING GUIDE
(Refer to)
<TROUBLE> <CHECK.> <REMEDY>
Motor does not rotate. <CHECK POWER CORD UNIT.> NO Replace power cord unit.
Does not charge. →
→→
→Connect the rated voltage to the normal main unit of empty charge capacity →
→→
→
Functions for a mo- by the power cord unit. Check if the charge status lamp of main unit is lit.
ment and stops. Confirm if the motor rotates more than one minutes by AC power source
Does not operate by when turning ON the switch.
AC power source. Confirm if the output voltage is about DC2.7V with no load operation when
connecting the rated voltage.
↓
↓↓
↓OK
<CHECK RECHARGEABLE BATTERY.> NO Replace both recharge-
Okay if the voltage of rechargeable battery is more than approximately →
→→
→able battery.
1.2V DC between (+) and (-) terminals.
↓
↓↓
↓OK
<CHECK MODULE.> NO Check the
Wire the main unit returned from a customer refer with the following figure, →
→→
→soldering points.
and connect the rated voltage to it by the power cord unit. ↓
↓↓
↓OK
Take out the battery. Connect the chassis and (-) terminal of battery with Replace module.
the lead wire. Check charging current with the wire between chassis and
(+) terminal of battery.
Check charging current, if it is approx. 1100mA.
↓
↓↓
↓OK
<CHECK MOTOR.> NO Replace motor.
Okay if motor rotates when DC1.2V is applied to (+) and (-) terminals. →
→→
→
Noise is too loud. Check if there any deformation with the outer foil. NO Replace the outer foil or
Amplitude is too →
→→
→oiling a drop for the foil.
small. ↓
↓↓
↓OK
<CHECK DRIVING BAR.> NO Replace or repair the
Check if there is any deformation with trimmer driving bar. →
→→
→trimmer driving bar.
↓
↓↓
↓OK
<CHECK MOTOR.> NO Tighten the screws.
Confirm to tighten the screws firmly. →
→→
→
9
ES4033-A3 / ES4035-A3
6 EXPLODED VIEW
10
ES4033-A3 / ES4035-A3
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali Panasonic Rasoio elettrico
Panasonic
Panasonic ES-RT47 Manuale utente
Panasonic
Panasonic ES-8224 Manuale utente
Panasonic
Panasonic ES7003S Operating Manuale utente
Panasonic
Panasonic ER-GB42 Manuale utente
Panasonic
Panasonic ES8113 Manuale utente
Panasonic
Panasonic ES-RF41 Manuale utente
Panasonic
Panasonic ES6003 Manuale utente
Panasonic
Panasonic ER-GB60 Manuale utente
Panasonic
Panasonic ES-LV81 Manuale utente
Panasonic
Panasonic ES-LV6Q Manuale utente
Panasonic
Panasonic ER-GB80 Manuale utente
Panasonic
Panasonic ER-GK75 Manuale utente
Panasonic
Panasonic ES8103S Manuale utente
Panasonic
Panasonic ES-RP40 Manuale utente
Panasonic
Panasonic ER-GB30 Manuale utente
Panasonic
Panasonic ER-GN70 Manuale utente
Panasonic
Panasonic ES-208 Manuale utente
Panasonic
Panasonic ES4036 Manuale utente
Panasonic
Panasonic ES-SA40 Manuale utente
Panasonic
Panasonic ES-LA83 Manuale utente
