Peak Scientific Precision Zero Air Series Manuale utente

Precision Zero Air Series (All Models)

Installation Guide

Page 2

Change History

Rev Comment Name Date

3 Cleaning Information Update LC 28/02/2018

How to use this Manual

This installation guide is intended to be used as a step by step, quick start guide, to

facilitate installation and conﬁguration.

Please visit www.peakscientiﬁc.com/downloads to

download the full User Manual for your gas generator.

Thank you for selecting Peak Scientiﬁc to meet your Gas Generation needs, and should

you require any further assistance or support please do not hesitate to contact Peak

Scientiﬁc or Peak Partner from which you purchased your Generator.

Page 3

Safety Notices

Peak Scientiﬁc Instruments cannot anticipate every possible circumstance which may

represent a potential hazard. The warnings detailed within this document detail the

most known potential hazards, but by deﬁnition cannot be all inclusive. If the user

employs an operating procedure, item of equipment or a method of working which

is not speciﬁcally recommended by Peak Scientiﬁc, the user must ensure that the

equipment will not be damaged or become hazardous to persons or property.

Symbols

This document uses the following symbols to highlight speciﬁc areas important to the

safe and proper use of the Generator

A WARNING notice denotes a hazard. It calls attention to an operating procedure,

process or similar, which if not correctly performed or adhered to, could cause

personal injury or in the worst case death. Do not proceed beyond a WARNING

notice until the indicated conditions are fully understood or met.

A CAUTION notice denotes a hazard. It calls attention to an operating procedure,

process or similar, which if not correctly performed or adhered to, could cause

damage to the Generator or the Application. Do not proceed beyond a CAUTION

notice until the indicated conditions are fully understood or met.

Caution, risk of electric shock. Ensure power to the Generator has been removed

before proceeding.

Safety Notice to Users

These instructions must be read thoroughly and understood before

installation and operation of your Peak Precision Zero Air Series

Generator. Use of the Generator in a manner not speciﬁed by Peak

Scientiﬁc MAY impair the SAFETY provided by the equipment.

When handling, operating or carrying out any maintenance, personnel

must employ safe engineering practices and observe all relevant local

health and safety requirements and regulations. The attention of UK

users is drawn to the Health and Safety at Work Act 1974, and the

Institute of Electrical Engineers regulations.

If the equipment is used in a manner not speciﬁed by the manufacturer,

the protection provided by the equipment may be impaired.

WARNING

CAUTION

Page 3

Page 4

1/4” x 1/4” Compression Fitting 02-4421

1/4” x 1/8” Compression Fitting 02-1000

x3m

1/4” Teﬂon Tubing 00-1266

UK Mains Cable C13 04-1028

US Mains Cable C13 6-15 04-1029

EU Mains Cable C13 04-1038

US Mains Cable C13 5-15 04-1039

Fittings Kit

Page 5

Unpack the generator from the shipping crate and position on a ﬂat surface, in

desired area.

WARNING the weight of the unit constitutes a two man lift. Safe lifting practices are

advised.

Select the ¼” x ¼” and ¼” x ⅛” Compression Fittings and attach to the AIR IN and

ZERO AIR ports respectively.

02-4421

02-1000

WARNING

Page 6

Connect the supplied ¼” Teﬂon Tubing to the AIR IN port. Connect appropriate ⅛”

tubing, greater than 1m in length, to the generators ZERO AIR port. Please note: Only

Copper or Stainless Steel tubing should be connected to the ZERO AIR port.

Copper /

Stainless Steel

tubing only

Select the appropriate mains cable from the ﬁttings kit and plug the IEC 60320/C13

cable into the mains input at the rear of the generator.

Please note both 110V and 230V US cables have been supplied, ensure correct

mains cable is used to match the rating on the generators serial plate.

00-1266

CAUTION

04-1028/04-1029/04-1038/04-1039

Page 7

110VAC 50/60Hz OR 230VAC 50/60Hz

Plug the mains cable into the corresponding 110VAC 50/60Hz OR 230VAC 50/60Hz

single phase power supply.

CAUTION ensure the correct cable has been selected for your electrical supply

Press the POWER switch located at the rear of the generator.

CAUTION

UK EU

110V

230V

Page 8

The LEDs on the front of the generator should now illuminate YELLOW as the unit

starts up.

After approximately 60 minutes the LEDs will illuminate GREEN or BLUE (70-****

Part Numbers Only) to indicate that the generator is now ready to use.

YELLOW for 60 Minutes

GREEN / BLUE

Page 9

CONGRATULATIONS

Your Peak Scientiﬁc gas generator is now fully installed. operational and ready to

supply gas on demand to your instrument.

Page 10

* Electrical requirements are 110 or 230VAC nominal +/- 10% depending on chosen

model. However, running continuoulsy at voltages outwith this is not recommended.

Extended periods at extremes can have a detrimental effect on the operation and life

of the Generator.

Chlorine-based bleaches/cleaning solutions should not be used on the generator, nor

should they be contained within the vicinity of the generator or compressed air supply

as these can facilitate internal and external corrosion of the generator.

Please familiarise yourself with the full User Manual available at www.peakscientiﬁc.

com/downloads This includes all other technical speciﬁcations, operating

instructions, service requirements, contact details and trouble shooting.

If you are using the Precision Air Compressor as your air supply, please refer to the

Precision Air Compressor Installation Guide, available at www.peakscientiﬁc.com/

downloads

General Notes

Altri manuali per Precision Zero Air Series

Indice

Altri manuali Peak Scientific Generatore portatile

Peak Scientific

Peak Scientific FUSION 1010 Manuale utente

Peak Scientific

Peak Scientific ZA015 Manuale

Peak Scientific

Peak Scientific Precision Hydrogen SL Manuale utente

Peak Scientific

Peak Scientific Precision Series Manuale utente

Peak Scientific

Peak Scientific Genius AB-3G Manuale utente

Peak Scientific

Peak Scientific Precision Zero Air Manuale

Peak Scientific

Peak Scientific MS Bench SCI 1 Manuale utente

Peak Scientific

Peak Scientific Infinity XE 60 Series Manuale utente

Peak Scientific

Peak Scientific Genius XE QSD Manuale utente

Peak Scientific

Peak Scientific N 10DR Series Manuale utente

Peak Scientific

Peak Scientific NG2000 Manuale utente

Peak Scientific

Peak Scientific Solaris XE Manuale utente

Peak Scientific

Peak Scientific Infinity 9000 Manuale utente

Peak Scientific

Peak Scientific Genius NM-3G Manuale utente

Peak Scientific

Peak Scientific Precision Zero Air Manuale utente

Peak Scientific

Peak Scientific Halo Manuale utente

Peak Scientific

Peak Scientific Precision Hydrogen SL Manuale utente

Peak Scientific

Peak Scientific TOC 1500 Manuale utente

Peak Scientific

Peak Scientific Genius 3030 Manuale utente

Peak Scientific

Peak Scientific NM20ZA Manuale utente

Peak Scientific

Peak Scientific Infinity 1032 Manuale utente

Peak Scientific

Peak Scientific AMD 200 Manuale utente

Peak Scientific

Peak Scientific Infinity 1045 Manuale utente

Peak Scientific

Peak Scientific Infinity XE 50 0 Series Manuale utente

Manuali Generatore portatile popolari di altre marche

Kohler

Kohler 20EORZ Manuale di istruzioni

Powerhorse

Powerhorse 83171 Manuale utente

HURST

HURST ML-630-SI Manuale utente

ETQ

ETQ TG4000 Manuale utente

Briggs & Stratton

Briggs & Stratton 40265 Guida all'installazione

ConMed

ConMed 7550 Manuale utente

Owon

Owon Waveform Generator Manuale utente

evertz

evertz 7700 Series Manuale utente

Power Stroke

Power Stroke PS906025 Manuale utente

Firefly

Firefly Cygnus CYG2400/460/24 Manuale utente

Draper

Draper PG950S Aggiornamento firmware

PowerBoss

PowerBoss PowerBoss Manuale utente

SDMO

SDMO SH 4000 Manuale utente

EINHELL

EINHELL STE 5500 Manuale utente

Wanco

Wanco WI3000P Manuale utente

Full Boar

Full Boar FBT-3300 Manuale utente

Dwyer Instruments

Dwyer Instruments ASG Manuale utente

Westinghouse

Westinghouse WH1000i Series Manuale utente