Procom MN200TBA-B Guida rapida

BLUE FLAME

VENT-FREE

GAS SPACE HEATER

OWNER’S OPERATION AND

INSTALLATION MANUAL

MODELS

MN200TBA-B, ML200TBA-B

MN300TBA-B, ML300TBA-B

Questions, problems, missing parts? Before returning to your retailer, call

our customer service department at 1-866-573-0674, 7:30 am - 4:30 pm CST,

Monday through Friday or email ser[email protected]

WARNING: If the information in this manual is not

followed exactly, a re or explosion may result causing

property damage, personal injury or loss of life.

— Do not store or use gasoline or other ammable va-

pors and liquids in the vicinity of this or any other

appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

•

Immediately call your gas supplier from a neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the re

department.

—

Installation and service must be performed by a quali-

ed installer, service agency or the gas supplier.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

F09-022

PFS

CSA/ANS

Z21.11.2 2019

Unvented

Room Heaters

www.usaprocom.com 200158-02A2

This is an unvented gas-red heater. It uses air (oxygen)

from the room in which it is installed. Provisions for ad-

equate combustion and ventilation air must be provided.

Refer to Air For Combustion and Ventilation section on

page 6 of this manual.

WARNING: WARNING: FIRE, EXPLOSION AND AS-

PHYXIATION HAZARD

IMPROPERADJUSTMENT, ALTERATION, SERVICE, MAINTENANCE,

OR INSTALLATION OF THIS HEATER OR ITS CONTROLS CAN CAUSE

DEATH OR SERIOUS INJURY.

READAND FOLLOW INSTRUCTIONSAND PRECAUTIONS IN USER'S

INFORMATION MANUAL PROVIDED WITH THIS HEATER.

This appliance may be installed in an aftermarket,* per-

manently located, manufactured (mobile) home, where

not prohibited by local codes.

This appliance is only for use with the type of gas indi-

cated on the rating plate. This appliance is not convert-

ible for use with other gases.

* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer.

SAVE THIS BOOK

TABLE OF CONTENTS

Safety ........................................................ 3

 ............................................ 4

................................. 5

 ........................ 5

....................................... 5

............................................... 6

.................................................. 6



..................... 6

.......... 6

 ................................................. 8

................................................. 15

 .................................... 17

............................ 18

 ....................................... 19

.................................. 22

 ............................................. 22

 ........................................... 22

..................................... 22

 ........................................................ 23

 .................................................. 24

www.usaprocom.com 3200158-02A

SAFETY

IIMPORTANT: Read this owner’s

manual carefully and completely

before trying to assemble, op-

erate, or service this heater.

Improper use of this heater can

cause serious injury or death

from burns, fire, explosion,

electrical shock and carbon

monoxide poisoning.

Only a qualied installer, service

agent, or local gas supplier may

install and service this product.

WARNING: Keep the appli-

ance area clear and free from

combustible materials, gasoline,

and other ammable vapors and

liquids.

This heater is equipped for

either natural or propane gas.

Field conversion is not permit-

ted.

This appliance is only for use

with the type of gas indicated on

the rating plate. This appliance

is not convertible for use with

other gases.

DANGER: Carbon monoxide

poisoning may lead to death!

CARBON MONOXIDE POISONING: 









  









NATURAL AND PROPANE GAS: 

     



       





WARNING: Do not use any

accessories not approved for

use with this heater.

WARNING: Carefully super-

vise young children when they

are in the room with the heater.

WARNING: The re screen or

guard designed for this unvent-

ed appliance must be installed

prior to operation.

WARNING: Due to high tem-

peratures, the appliance should

be located out of tra󰀩c and away

from furniture and draperies.

WARNING: Heater becomes

very hot when running. Children

and adults should be alerted

to the hazards of high surface

temperatures and should stay

away to avoid burns and cloth-

ing ignition. Heater will remain

hot for a time after shuto󰀨. Allow

surfaces to cool before touching.

WARNING: Do not place

clothing or other flammable

material on or near the appli-

ance. Never place any objects

in the heater.

WARNING: Heater becomes

very hot when running. Keep

children and adults away from

hot surfaces to avoid burns or

clothing ignition.

www.usaprocom.com 200158-02A4

 





        



 



    󰀨



  

Combustion and Ventilation

󰀨

Troubleshooting

 





 󰀨



󰀨

 







SAFETY

 

󰀨







     



     

       





 󰀨





    



    





MODEL MN200TBA-B MN300TBA-B ML200TBA-B ML300TBA-B

    

 

 

 









    

    

SPECIFICATIONS



Heater Dimensions

(HxWxD)

12" × 19 14" × 8"

128" × 8

Note: Dimensions listed are outer most points on the heater (includes control knobs and

grill).

Carton Dimensions (HxWxD)

12" × 21 34"

122

www.usaprocom.com 5200158-02A

QUALIFIED INSTALLING AGENCY

      













 



 











PRODUCT FEATURES

SAFETY PILOT



󰀨

󰀨



PIEZO IGNITION SYSTEM







THERMOSTATIC CONTROL

(Thermostat Models Only)

       

   

      



PRODUCT IDENTIFICATION

Figure 1 - Vent-Free Gas Heater















www.usaprocom.com 200158-02A6

LOCAL CODES

       

     

     The National Fuel

Gas Code, ANSI Z223.1/NFPA 54















State of Massachusetts:

       

      



     



       



      

    

     





UNPACKING

 

 



 





       

     







       







      







 





 

       



 



AIR FOR COMBUSTION AND VENTILATION

WARNING: This heater shall

not be installed in a conned space

or unusually tight construction

unless provisions are provided

for adequate combustion and

ventilation air. Read the following

instructionsto insureproperfresh

air for this and other fuel-burning

appliances in your home.

WATER VAPOR: A BY-PRODUCT OF

UNVENTED ROOM HEATERS

󰀩



   

      

      



     





󰀩







www.usaprocom.com 7200158-02A

     









WARNING: This heater shall

not be installed in a room or

space unless the required vol-

ume of indoor combustion air

is provided by the method de-

scribed in the National Fuel Gas

Code, ANSI Z223.1/NFPA 54, the

International Fuel Gas Code, or

applicable local codes.

WARNING: If the area in which

the heater may be operated does

not meet the required volume for

indoor combustion air, combus-

tion and ventilation air shall be

provided by one of the methods

described in the National Fuel

Gas Code,ANSI Z223.1/NFPA54,

the International Fuel Gas Code,

or applicable local codes.

VENTILATION AIR

Ventilation Air From Inside Building



     













  National Fuel Gas Code, ANSI

Z223.1/NFPA 54, Air for Combustion and

Ventilation     



AIR FOR COMBUSTION AND VENTILATION

Outlet

Air

Ventilated

Attic

Outlet

Air

Inlet

Air

Inlet Air Ventilated

Crawl Space

Crawl

Space

To Attic

Figure 2 - Ventilation Air from Inside

Building

Figure 3 - Ventilation Air from Outdoors

Remove

Door into

Adjoining

Room,

Option 3

Ventilation Grills

Into Adjoining Room,

Option 2

12"

Ventilation

Grills into

Adjoining

Room,

Option 1

Ventilation Air From Outdoors

      











  National Fuel

Gas Code, ANSI Z223.1/NFPA 54, Air for

Combustion and Ventilation



IMPORTANT:    

          







    





www.usaprocom.com 200158-02A8

INSTALLATION

NOTICE: This heater is intended

for use as supplemental heat.

Use this heater along with your

primary heating system. Do not

install this heater as your pri-

mary heat source. If you have a

central heating system, you may

run system’s circulating blower

while using heater. This will help

circulate the heat throughout the

house. In the event of a power

outage, you can use this heater

as your primary heat source.

CAUTION: When installing

heater in a home garage

• heater pilot and burner must

be at least 18" above oor

• locate heater where moving

vehicle will not hit it

WARNING: A qualied ser-

vice person must install heater.

Follow all local codes.

WARNING: Never install the

heater

• in a bathroom or a bedroom

• in a recreational vehicle

• where curtains, furniture,

clothing, or other ammable

objects are less than 36" from

the front, top, or sides of the

heater

• in high tra󰀩c areas

• in windy or drafty areas

Figure 4 - Mounting Clearances as

Viewed From Front of Heater

CAUTION: This heater cre-

ates warm air currents. These

currents move heat to wall sur-

faces next to heater. Installing

heater next to vinyl or cloth wall

coverings or operating heater

where impurities (such as to-

bacco smoke, aromatic candles,

cleaning uids, oil or kerosene

lamps, etc.) in the air exist, may

cause walls to discolor.

IMPORTANT:







See Air for Combustion and Ventilation



CHECK GAS TYPE







CLEARANCES TO

COMBUSTIBLES

WARNING: Maintain the

minimum clearances shown

in Figure 4. If you can, provide

greater clearances from oor,

ceiling, and joining wall.

CEILING

36"

Minimum

From

Sides of

Heater

Left

Side

Right

Side

2" Minimum to Top Surface of Carpeting,

Tile or Other Combustible Material

FLOOR

www.usaprocom.com 9200158-02A

INSTALLATION

Figure 6 - Mounting Bracket Location

Removing Front Panel of Heater

 



 



Figure 7 - Removing Front Panel Of

Heater



LOCATING HEATER







Accessories

󰀩

 



 



See Accessories



INSTALLING THERMOSTAT

SENSING BULB (OPTIONAL)

 



       





 







Figure 5 - Moving Thermostat Sensing

Bulb







FASTENING HEATER TO WALL

Mounting Bracket



    





www.usaprocom.com 200158-02A

Figure 8 - Mounting Bracket Clearances

Figure 9 - Folding

Anchor

Figure 10 - Popping

Open Anchor Wings

For Thin Walls

INSTALLATION

WARNING: Maintain mini-

mum clearances shown in Figure

4, page 8. If you can, provide

greater clearances from oor

and joining wall.

 

Note: Mark only last hole on each end

of mounting bracket. Insert mounting

screws through these holes only.

 



Attaching Mounting Bracket To Wall

Note: Wall anchors, mounting screws, and

spacers are in hardware package. The hard-

ware package is provided with heater.

Attaching to Wall Stud Method



 



      





   



 



Attaching to Wall Anchor Method

     





      





 

 



 

       



IMPORTANT:





17 3/8"

18 1/2"

Min.

6 1/2"

Min.

Adjoining Wall

Only Insert Mounting

Screws Through Last

Hole On Each End

Floor

10 5/8"

Min. 17 3/8"

18 1/2"

Min.

Only Insert Mounting

Screws Through Last

Hole On Each End

Floor

Adjoining Wall









Methods For Attaching Mounting

Bracket To Wall









1. Attaching to wall stud:







2. Attaching to wall anchor:













Marking Screw Locations

      





Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Procom Riscaldatore a gas

Procom

Procom Lost River PCILVFD18RT Guida rapida

Procom

Procom WZN18HLA Manuale utente

Procom

Procom MD200TBA Guida rapida

Procom

Procom ML150HPA Guida rapida

Procom

Procom HearthSense BF30T-BB Guida rapida

Procom

Procom MD2TPA Manuale utente

Procom

Procom MN200HBA Manuale utente

Procom

Procom FeatureComforts ML150TPE Manuale utente

Procom

Procom MD300HGA Manuale utente

Procom

Procom ML300HGA Guida rapida

Procom

Procom MG1TIR Guida rapida

Procom

Procom ML100HBAHR Guida rapida

Procom

Procom MN200EBC Guida rapida

Procom

Procom PCD18T Manuale utente

Procom

Procom MG10HBF Guida rapida

Procom

Procom ML150HPA Guida rapida

Procom

Procom MN300HGA Guida rapida

Procom

Procom NVDWA2 Manuale utente

Procom

Procom ML170EPC Guida rapida

Procom

Procom MN060HPA Guida rapida

Procom

Procom MN060HBA Guida rapida

Procom

Procom ML100HBAHR Guida rapida

Procom

Procom ML060HPA Guida rapida

Procom

Procom BLUE FLAME MNSD100TBA Guida rapida

Manuali Riscaldatore a gas popolari di altre marche

Superior

Superior BGE18NV Manuale utente

Dru

Dru Room-sealed atmospheric gas-fired heating... Manuale utente

klover

klover TKR 35 Manuale utente

Rothenberger Industrial

Rothenberger Industrial 035984 Manuale utente

New Buck Corporation

New Buck Corporation 34 Manuale utente

Hargrove

Hargrove Timberland Glow Guida rapida

Kinder

Kinder Cameo BF Manuale utente

Qlima

Qlima GH 438 B-2 Manuale

Desa

Desa 125-R Manuale utente

Gasmate

Gasmate AH100 Series Manuale utente

Medallion

Medallion MBP20TLB Guida rapida

Clarke

Clarke DEVIL 910SS Manuale utente

Superior

Superior BGE18NR Manuale utente

Brant Radiant Heaters

Brant Radiant Heaters QTD Series Istruzioni per l'installazione

L.B. White

L.B. White Therma Grow HW220 Manuale

Sealey

Sealey LP35.V5 Manuale utente

Italkero

Italkero Falo Evo Manuale utente

Desa

Desa 30LP Manuale utente