Sundance Spas Hawthorne Manuale utente

HawthorneTM • HartfordTM

6530-681, Rev. B

OWNER´S MANUAL

Attention New Spa Owner!

Congratulations on the purchase of your new Sundance® 680 series spa! The

following is a list of automated functions and maintenance recommendations

for your new spa. Automated functions have been listed below in an attempt to



24-hours of ownership! Maintenance recommendations are listed in an attempt

to stress their importance in protecting your new spa.

Automated Operations









of the cycle. Note: this function only occurs during the rst ltration/heating

cycle each day.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following parameters as



pH 7.4-7.6

Free Chlorine 3.0-4.0 ppm

Free Bromine 2.0-4.0 ppm

Total Alkalinity 100-120 ppm

Calcium Hardness 150-250 ppm

Always maintain your spa lter as outlined below to ensure healthy spa water.

Refer to pages 29-30 for additional information.

Required Filter Maintenance



provides unsurpassed water quality! To ensure maximum water quality at all





Required Water Maintenance

You should replace the spa’s water every 3 months. The frequency depends

on a number of variables including frequency of use, number of users, and

attention paid to water quality maintenance. You will know it is time for



the normal feel or sparkle to the water, even though the key water balance

measurements are all within the proper parameters. See pages 29-30 for

additional information.

Table of Contents

1.0 Important Spa Owner Information ............................................. 1

2.0 FCC Notice ................................................................................... 1

3.0 Important Safety Instructions .................................................... 2

3.1 Important CSA Safety Instructions (Canada only)......................... 4

3.2 Hyperthermia................................................................................. 5

3.3 Cautions ........................................................................................ 6

3.4 General Electrical Safety Instructions ........................................... 6

4.0 Choosing A Location .................................................................. 7

4.1 Outdoor Location........................................................................... 7

4.2 Indoor Location.............................................................................. 8

5.0 Power Requirements................................................................... 9

6.0 Electrical Wiring Instructions................................................... 10

7.0 Spa Fill Up Procedure ............................................................... 11

8.0 Control Functions ..................................................................... 17

 ............................................................................... 17

8.2 General Spa Features And Controls ........................................... 18

9.0 Operating Instructions.............................................................. 19

9.1 Setting Water Temperature ......................................................... 19

  ........................................................................... 19

9.3 Standard Light Operation ............................................................ 19

9.4 Optional Multi-Colored LED Light System Operation .................. 20

9.5 Adjusting Individual Jet Flow ....................................................... 21

9.6 Selecting Desired Massage Action.............................................. 21

9.7 Air Controls.................................................................................. 21

10.0 Automatic Filtration Cycles...................................................... 21

 

Without  ................................................ 22

 

With  ..................................................... 22

  ......................... 22

10.4 Lock Modes - All Models (L1 - L2)............................................... 22

  ........................................ 22

  ....... 23

  ............ 24

11.0 Spa Maintenance ....................................................................... 25

11.1 Cleaning The Filter Cartridges .................................................... 25

11.2 Draining and Refilling .................................................................. 26

  .................................................................................. 27

11.4 Cleaning The Spa Interior ........................................................... 27

11.5 Maintaining the Cover ................................................................. 27

11.6 Maintaining The Synthetic Cabinet.............................................. 27

11.7 Winterizing................................................................................... 28

11.8 Restarting Your Spa in Cold Weather.......................................... 28

12.0 Water Quality Maintenance....................................................... 29

12.1 pH Control ................................................................................... 29

12.2 Sanitizing..................................................................................... 29

12.3 Optional CD Ozone Water Maintenance System ........................ 30

13.0 Error Conditions / Error Messages.......................................... 30

  ................. 30

  ...................................................................... 30

 ..................................................................... 30

  ..................................................................... 31

  ..................................................................... 31

  ................ 31

 .............................................................................. 31

 

  .............................................................................. 31

 ...................................................................... 32

 ...................................................................... 32

14.0 Troubleshooting Procedures ................................................... 32

 .............. 32

  .................................... 32

  ............................................................................ 33

14.4 Water Is Too Hot.......................................................................... 33

  ....................................................................................... 33

15.0 Circuit Diagram For Models Without Circulation

Pump Option.............................................................................. 34

16.0 Circuit Diagram For Models With Circulation

Pump Option.............................................................................. 35

17.0 Optional SunSoundTM Stereo Receiver Functions ................ 36



1.0 Important Spa Owner Information

Your Sundance® 680 series spa is constructed to the highest standards

and is capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for

efficient operation, an uncovered spa surface and wall fittings directly

exposed to sunlight and high temperatures for an extended period is

subject to permanent damage or discoloration. Damage caused by

exposing the spa to this abuse is not covered under warranty. We rec-

ommend that you always keep the spa full of water when it is exposed

to direct sunlight and that you keep the Sundance premium insulating

cover in place at all times when the spa is not in use. Read and careful-

ly follow the requirements for your spa’s support base found in section



Sundance constantly strives to offer the finest spas available,

therefore modifications and enhancements may be made which

affect the specifications, illustrations and/or instructions contained

herein.

2.0 FCC Notice

This equipment has been tested and found to comply with the limits for



limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used

in accordance with the instructions, may cause harmful interference to

radio communications. However, there is no guarantee that interference

will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be deter-

mined by turning the equipment off and on, the user is encouraged to try



1. Rearrange or relocate the receiving antenna.

2. Increase the separation between the equipment and receiver

3. Connect the equipment into an outlet on a circuit different from the

circuit connected.

 

Changes or modifications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.



3.0 Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

When installing and using this electrical equipment, basic safety precau-



1. WARNING: To reduce the risk of injury, do not permit children to use

this product unless they are closely supervised at all times.

2. WARNING: A grounding wire connector is provided on this unit to

2) solid copper conduc-

tor between this unit and any metal equipment, metal enclosures

of electrical equipment, metal water pipe, or conduit within 5 feet

(1.5m) of the unit.

3. DANGER: Risk of Accidental Drowning. Extreme caution must be

exercised to prevent unauthorized access by children. To avoid

accidents, ensure that children cannot use this spa unless they are

supervised at all times.

4. DANGER: Risk of Injury. The suction fittings in this spa are sized to

match the specific water flow created by the pump. Should the need

arise to replace the suction fittings or the pump, be sure that the flow





than the flow rate marked on the original suction fitting.

5. DANGER: Risk of Electric Shock. Install at least 5 feet (1.5m) from

all metal surfaces. As an alternative, a spa may be installed within

5 feet (1.5m) of metal surfaces if each metal surface is permanently

2) solid cop-

per conductor attached to the wire connector on the grounding lug,

inside the equipment compartment on the equipment box.

6. DANGER: Risk of Electric Shock. Do not permit any electrical appli-

ance, such as a light, telephone, radio, television, etc. within 5 feet

(1.5m) of a spa, unless such appliances are built-in by the manufac-

turer.

7. ELECTRICAL SUPPLY: The electrical supply for this product must

include a suitably rated switch or circuit breaker to open all un-

grounded supply conductors to comply with section 422-20 of the





be readily accessible and visible to the spa occupant but installed at

least 5 feet (1.5m) from the spa water.

8. WARNING: 

9. The water in a spa should never exceed 104°F (40°C). Water

temperatures between 100°F (38°C) and 104°F (40°C) are consid-

ered safe for a healthy adult. Lower water temperatures are recom-

mended for young children and when spa use exceeds 10 minutes.

10. Since excessive water temperatures have a high potential for caus-

ing fetal damage during the early months of pregnancy, pregnant or

possibly pregnant women should limit spa water temperatures to

100°F (38°C). If pregnant, please consult your physician before us-

ing a spa.

11. Before entering the spa, the user should measure the water tem-

perature with an accurate thermometer since the tolerance of water



12. The use of alcohol, drugs, or medication before or during spa use

may lead to unconsciousness with the possibility of drowning.

 

low or high blood pressure, circulatory system problems, diabetes,



-

ties in association with using or operating your spa, discontinue use

and consult your physician.

 

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

15. Always shower before and after using your spa. To reduce the pos-

sibility of contracting a waterborne illness, always maintain water

chemistry within the parameters listed on the inside cover of this

manual. If you or other bathers experience such a condition, discon-

tinue use and seek medical attention.



3.1 Important CSA Safety Instructions (Canada only)

When using this electrical equipment, basic safety precautions should



1. READ AND FOLLOW ALL INSTRUCTIONS.

2. A green colored terminal or a terminal marked G, Gr, Ground,

Grounding or the symbol* is located inside the supply terminal box

or compartment. To reduce the risk of electric shock, this

terminal must be connected to the grounding means provided in the

electric supply service panel with a continuous copper wire

equivalent in size to the circuit conductors that supply this

 

 

 

compartment. To reduce the risk of electric shock, connect the local

common bonding grid in the area of the spa to these terminals with

 

(10mm2).

4. All field-installed metal components such as rails, ladders, drains

or other similar hardware within 10 feet (3m) of the spa shall be

bonded to the equipment grounding buss with copper conductors

 2).

5. SAVE THESE INSTRUCTIONS

WARNING: Children should not use spas without adult supervision.

WARNING: Do not use spas unless all suction guards are installed to

prevent body and hair entrapment.

WARNING:

WARNING: To avoid injury, exercise care when entering or exiting the

spa.

WARNING: Do not use drugs or alcohol before or during the use of a

spa to avoid unconsciousness and possible drowning.



WARNING:

physician before using a spa.

WARNING: Water temperature in excess of 38°C (104°F) may be

injurious to your health.

WARNING: Before entering the spa, measure the water temperature

with an accurate thermometer.

WARNING: Do not use a spa immediately following strenuous exercise.

WARNING:

health.

WARNING: Do not permit electric appliances (such as light, telephone,

radio, television, etc.) within 5 feet (1.5m) of this spa unless factory

installed.

CAUTION: Maintain water chemistry in accordance with manufacturer’s

instructions.

WARNING: The use of alcohol or drugs can greatly increase the risk of

fatal hyperthermia in spas.

3.2 Hyperthermia





Hyperthermia occurs when the internal temperature of the body reaches

a level several degrees above the normal body temperature of 98.6°F

(37°C). The symptoms of hyperthermia include drowsiness, lethargy, and

an increase in the internal temperature of the body. The effects of hyper-



 

 

 

 

 

 



3.3 Cautions

 

pressure, and any condition requiring medical treatment, pregnant

women, the elderly, or infants should consult with a physician before

using a spa.

 

the water temperature in a spa should not exceed 104°F (40°C).

Immersion in water in excess of 104°F (40°C) can be hazardous to

your health.

3. Observe a reasonable time limit when using the spa. Long expo-

sures at higher temperatures can cause high body temperature.

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drowning.

4. Do not use the spa under the influence of alcohol, narcotics, or other



consequences.

5. Always test the spa water temperature before entering the spa. En-

ter and exit the spa slowly. Wet surfaces can be very slippery.

 

operate any electrical appliances from inside the spa or when you

are wet unless such appliances are built-in by the manufacturer.

 

safe water and prevent possible damage to spa components.

 

use. This will help to discourage unsupervised children from enter-

ing the spa and keep the spa cover secure in high-wind conditions.

There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

3.4 General Electrical Safety Instructions

-

ment system. It contains the most advanced safety and self-protective

-



dealer or local building department should you have any questions

regarding your installation.



with a current collector system. A pressure wire connector is provided

on the surface of the control box, located outside the equipment door

(Figure-B, page 11) to permit connection of a bonding wire between

this point and any ground metal equipment, metal water pipe or conduit

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Sundance Spas Vasca idromassaggio

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Spas 680 Series Manuale utente

Sundance Spas

Sundance Spas ALTAMAR 880 Manuale d'uso e manutenzione

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Denali 680 Series Manuale utente

Sundance Spas

Sundance Spas Portofino Series Istruzioni per l'installazione

Sundance Spas

Sundance Spas Hamilton Manuale utente

Sundance Spas

Sundance Spas maxxus 880 Series Manuale utente

Sundance Spas

Sundance Spas Edison Manuale utente

Sundance Spas

Sundance Spas 850 Series Istruzioni operative

Sundance Spas

Sundance Spas 780 series Manuale utente

Sundance Spas

Sundance Spas CAMEO Manuale utente

Sundance Spas

Sundance Spas Architectural Series Manuale utente

Sundance Spas

Sundance Spas CAMDEN 780 Manuale utente

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas 400 series Istruzioni per l'installazione

Sundance Spas

Sundance Spas CONSTANCE 6530-512X Manuale utente

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Kingston 980 Series Manuale utente

Sundance Spas

Sundance Spas 850 Series Manuale utente

Sundance Spas

Sundance Spas Camden Manuale utente

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Altamar 880 series Manuale utente

Sundance Spas

Sundance Spas Export 680 Series Manuale utente

Manuali Vasca idromassaggio popolari di altre marche

Bestway

Bestway Lay-Z-Spa 54189 Manuale utente

Jacuzzi

Jacuzzi ARGA ARG101C0110 Manuale elenco delle parti

Morphy Richards

Morphy Richards Essentials PC4006 Manuale utente

Softub

Softub PRESTIGE Manuale utente

JNJ SPAS

JNJ SPAS SPA-318 Manuale di installazione

KIRAMI

KIRAMI Comfort Family Manuale utente

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Manuale utente

HoMedics

HoMedics FB-655HJ-GB Manuale utente

Everyday Hot Tubs

Everyday Hot Tubs 530 Manuale utente

anko

anko SS-601A Manuale utente

Jacuzzi

Jacuzzi Duetta 6042 Manuale utente

Pooli

Pooli OS030979B Manuale utente

Jacuzzi

Jacuzzi alimia Manuale utente

ab Solares Smart Spa Manuale utente

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Manuale utente

Outsunny

Outsunny 848-047V70 Manuale utente

Aquatic

Aquatic INFINITY 1 Manuale utente

Master Spas

Master Spas MP Force Manuale utente