Triumph ST3 Manuale utente
Triumph ST3 Instructions:
Before you start, prepare a flat area and cover with a soft cloth or towel to protect the
screen from scratches.
Take your time with the installation and assembly to avoid any damage to parts and bike.
Please note that you are working with metal parts which may have sharp edges.
First, apply masking tape either side of the cowl as shown, to allow you to mark the desired
hole locations.
1
Next, you need to use the base brackets to mark the four hole positions.
Attach them in the approximate positions shown with masking tape and manoeuvre them
until they are 240mm apart (as accurately as you can).
Once you are happy with their positions, mark through the tape to leave a marking on the
cowl tape.
2
Carefully and clearly mark the centre positions, ready for drilling.
Before removing the cowl to drill the holes, mark where the outside edge (on both sides)
meets the cowl - you will need this location to apply two foam pads.
3
Remove the cowl and carefully drill the four hole positions - it is best to pre-drill the holes
with a couple of smaller bits before finishing with the correct 9.5mm drill.
Next, apply the two foam pads so they will rest on the bevel edge when refitted.
4
An additional support bracket will need to be fitted to improve the rigidity of the cowl.
Align approximately, as shown, in the centre section, mark and drill a 6mm hole then attach
as shown - be sure to fit a nylon washer to both sides of the cowl to protect the paint finish.
Tighten the nut, ensuring the bracket is squarely aligned - do not overtighten.
Before loosening the lamp clamp, mark the position of the lights so they can replaced in the
same position later.
Remove the front bolt and insert the small piece of thin rubber towards the back section of
the clamp - this will be required to maintain the clamping force after installing the extra
bracket.
5
Refit the cowl, taking care to locate the bracket in line with the front clamp bolt and reinsert
the bolt.
Tighten front bolt then the rear, taking care to realign the lights in their original position
before fully tightening.
6
Refit the three cowl/bevel fasteners then install the four rubber threaded inserts.
Attach the base brackets using the M5 fasteners provided - making sure a finishing washer is
fitted under the head and a nylong washer is attached on the underside, as shown.
7
Loosely fit both brackets and recheck their spacing (should be approximately 240-245mm
apart).
When you are happy with their positions, tighten the screws but take care not to
overtighten.
8
You now need to fit the screen-side brackets taking care to use the correct locations for the
plastic washers provided.
The screen can now be attached.
9
Preinstall the 4 screen fasteners, ensuring a finishing washer is installed under the screw
heads and a rubber washer is fitted on the inside.
Inserts the screen fasteners into the bracket tabs and secure with the washers/nuts - take
care not to overtighten; just enough to apply light pressure onto the rubber washers.
CAUTION:
Please make sure you only tighten the Screen fasteners just before the point where the
rubber washers are starting to be compressed - this is a precaution to prevent the screen
from cracking.
Double check the security of all the fasteners.
You re now ready to test your new screen kit.
Final checks need to be made to make sure the guards do not contact the screen brackets -
put the steering on full lock and if there is any contact, loosen the bar clamp bolts slightly
(bottom of the mirror stalk) and rotate as necessary to give clearance. Repeat for the other
side.
Take care to familiarise yourself with the bike's new characteristics and if any adjustments
are required, stop the bike, reposition, and check the security of the fasteners again before
riding.
GPS / Accessory Bar
10
Altri manuali Triumph Accessori per motociclette
Triumph
Triumph A9708355 Manuale utente
Triumph
Triumph Tiger XR Series Manuale utente
Triumph
Triumph 184.1 Manuale di servizio
Triumph
Triumph A9501275 Manuale utente
Triumph
Triumph A9758100 Manuale utente
Triumph
Triumph A9510323 Manuale utente
Triumph
Triumph A9758013 Manuale utente
Triumph
Triumph Accesories Manuale
Triumph
Triumph ACCESORIES 2006 Manuale di istruzioni
Triumph
Triumph 197.1 Manuale di servizio
Triumph
Triumph A9510289 Manuale utente
Triumph
Triumph 46-2015F Manuale utente
Triumph
Triumph A9618116 Manuale utente
Triumph
Triumph Clothing Range 2006 Manuale
Triumph
Triumph A9758306 Manuale utente
Triumph
Triumph A9708044 Manuale utente
Triumph
Triumph My Triumph Connectivity Guida utente
Triumph
Triumph ACCESORIES 2007 Manuale di istruzioni
Triumph
Triumph A9808081 Manuale utente
Triumph
Triumph A9508184 Manuale utente
