TTI BackUp16 Manuale di servizio

Manufacturer of The Safest Tanks in Motion

www.tti.com.au

BackUp16™ / StandBy10™

HANDBOOK

OPERATOR’S

Portable Fire Fighters

TTi’s BackUp16™/StandBy10 HandBook

2Call 1800 816 277www.tti.com.au 2

Table of Contents

Introduction 3

Your Safety 3

Risk Assesment 4

Operating Instructions 5

Maintenance 6

Parts List 7

Warranty 10

Warranty Registration Card 11

TTi’s BackUp16™/StandBy10 HandBook

3Call 1800 816 277www.tti.com.au 3

Introduction

Please carefully read your operators handbook before mounting & using your

Backup16 or Standby10. Keep your handbook in a safe place.

Thank you for your purchase of a BackUp 16 or StandBy10 which is complete and

ready to use.

These highly efficient and portable fire fighters are your first defence for ember

suppression, managing spot fires and burning off. They feature a reliable, double

action hand pump with an adjustable nozzle. Twin one-way valves prevent syphoning

or leakage when not in use.

The robust, ergonomic tanks are designed to withstand rough handling associated

with fire situations.

Your Safety

1. To ensure your own safety and that of your employees if applicable you must

comply with

2. all relevant environmental, work place health and safety legislation and codes

of practice. In particular, be aware of Rural Fire Service guidelines for safety

when fighting fires or backburning.

3. Select and wear appropriate Personal protection Equipment in accordance with

the label of the product you intend using and your own safe work practices.

4. You must be in good mental health to operate this sprayer and not be under the

influence of alcohol or any drugs that could impair your vision, physical strength,

dexterity, judgment, or other mental capacity

5. All operators must be trained in safe use of this unit

TTi’s BackUp16™/StandBy10 HandBook

4Call 1800 816 277www.tti.com.au 4

Risk Assesment

Product Information Risk Assessment Sheet

TTi - BackUp16™ and Standby10™

TASK HAZARDS RISK CONTROL MEASURES

Partially fill the

tank with water,

start the motor &

test the spray unit

Manual handling;

slips, trips

or falls; petrol;

fumes; fingers

jammed

Med

• Concentrate on task;

• follow safe manual handling techniques:

• don’t lift on your own if > 20kg, bend

knees & keep back straight

• keep fingers clear

• keep unit at least 8m away from overhead

powerlines

• fire extinguisher nearby

• follow warning stickers on tanks

• wear PPE for petrol & fumes-mask & gloves

Check weather

conditions

& select the

appropriate

PPE to suit the

chemicals to be

used

Manual handling;

slips, trips or falls Low

• Put on PPE as per the chemical

requirements in the Material Safety Data

Sheet-coveralls, gloves, safety footwear,

glasses & respirator;

• Follow safe manual handling techniques:-

don’t lift on your own if >20kg, bend

knees & keep back straight.

Mix chemicals

(if applicable)

Fill spray tank/fire

fighting units

As above; spray

drift, chemical

spillage, emission

of vapors or

flammability;

weather; untrained

visitors

Med

• As above;

• User trained in the state’s chemical mixing

& administration course eg Chem. Cert;

• Follow the relevant Environment Protection

Authority requirements; fire extinguisher

present;

• Keep visitors away from the job unless

wearing full PPE.

Use spray or fire

fighter units.

As above; loss

of load; heat

& cold; noise;

exceed load limit

of vehicle; hose

entanglement;

exhaust fumes;

terrain & slopes;

run over by unit

High

• As above

• Wear clothes to suit heat & cold;

• Wear hearing protection if noise > 85 dBa;

• Follow the manufacturer’s safe operation

instruction for the vehicle and the spray

unit

• Don’t overload - water weighs 1kg for

every 1 litre

• Secure load to vehicle;

• Keep hose tidy;

• Put unit brakes on.

Clean up,

maintenance &

storage

As above High

• As above;

• Continue to wear PPE for clean up;

• Store unit in a dry, well ventilated area.

Burn Risk

Hot exhaust/muffler Med

• Do not reach over hot exhaust

• Do not service engine while hot

• Wear appropriate PPE

TTi’s BackUp16™/StandBy10 HandBook

5Call 1800 816 277www.tti.com.au 5

Operating Instructions

Before Use

Check all hoses, connections and hose clamps to ensure that the unit has been

delivered to you without transportation loss or damage.

Before attempting any spraying with your new unit, operate it with water only to

familiarize yourself with its features and capabilities and to ensure that your sprayer

has arrived in a safe working condition.

Please contact your dealer immediately should anything appear to have been

damaged.

Operation - BackUp16

Fill tank from appropriate water source. Place the unit on a surface at the same

height as your back. Slide one arm through a strap and stand upright while swinging

the opposite arm through the remaining strap.

Tighten straps securely

To operate. Remove lance from storage position. Grasp the centre handle firmly

and pull the front of the lance outward using the angled handle.

Aim the water jet at the base of the fire and continue pumping by moving handle

in & out. Due to the double action pump mechanism water is pumped on both in

& out stroke to deliver a consistent water jet.

Adjust nozzle by turning tip to achieve the desired spray pattern.

TTi’s BackUp16™/StandBy10 HandBook

6Call 1800 816 277www.tti.com.au 6

Operation - Standby10™

1. Your Standby10 is supplied with two spring steel mount brackets for easy mounting

on any convenient location on your tractor or trailed equipment.

2. To mount unit, remove the clips from the tank & fasten securely to any suitable flat

surface approx. 280 mm apart. Take care not to drill or screw thru any electrical

cables, pneumatic or hydraulic lines which may be located on the underside of

the fixing area.

3. After filling tank locate in clips by pushing down firmly.

4. To operate. Remove unit from storage clips with a firm upward pull. Grasp the

centre handle firmly and pull the front of the lance outward using the angled

handle.

5. Aim the water jet at the base of the fire and continue pumping by moving

handle in & out. Due to the double action pump mechanism water is pumped

on both in & out stroke to deliver a consistent water jet.

6. Adjust nozzle by turning tip to achieve the desired spray pattern. After use ensure

tank is refilled before returning to storage position.

Please note that the unit is designed for fire fighting use and not for chemical

spraying.

Please consult the manufacturer for further information.

Maintenance

Periodically unscrew knurled greasing cover [#812] on the lance, fill with grease &

screw up again.

Periodically check all hoses, fittings and nozzle parts. Replace any worn or broken

parts

When storing the unit ensure that it is clean and dry and store in a well ventilated

place.

TTi’s BackUp16™/StandBy10 HandBook

7Call 1800 816 277www.tti.com.au 7

Parts List

Lance Parts

No Code Description

197 8.39.04.303 Rubber Washer

198 8.39.04.306 Grip

199 2.23.15.911 Round Joint AN-11

200 8.39.04.009 Piston

201 8.39.04.005 Pin

202 2.20.08.010 Stainless eteel ball Φ 10

264 8.39.08.017 Nozzle

271 8.39.08.620 Tube with Sprayer

288 8.39.08.002 Inlet Nipple

289 8.39.08.324 Spring

350 2.03.24.012 Clamp

354 8.39.08.327 100mm Spring

398 2.59.26.740 Screw

446 8.39.04.324 Grip

808 8.39.08.803 Tube with nozzle

811 8.39.08.801 Complete Body

812 8.39.08.805 Greasing Nipple

TTi’s BackUp16™/StandBy10 HandBook

8Call 1800 816 277www.tti.com.au 8

BackUp16 Parts

No Code Description

1YP1016 Fire fighting knapsack - tank only

2YP1000 Lance

3YP105 Filter basket

4YP286 Lid - no breather

5YP286B Lid breather

6YP1002 1/2” rubber hose

7YP1005 Clip clamps

8YP1001 knapsack pick up tube

9STA69 8mm foot filter

10 YP1003 3/8”bspm x 1/2” tail, nylon

11 YP1010 Shoulder pad

12 YP1011 38mm strap, per mtr

13 YP1012 Plastic buckles

14 YPHTRG 16 X 8mm rubber gasket

15 BOX15 Packing box

TTi’s BackUp16™/StandBy10 HandBook

9Call 1800 816 277www.tti.com.au 9

StandBy10 Parts

No Code Description

1YFATM10TANK Tank only - Tractor mount fire fighter

2YFBKT Mounting barckets - per pair

3YP105 Filter basket

4YP286 Lid - no breather

5YP286B Lid breather

6YP1002 1/2” rubber hose, per mtr

7YP1005 clip clamps

8YP1007 Tractor mount pick up tube

9STA69 8mm foot filter

10 YP1003 3/8”bspm x 1/2” tail, nylon

11 YP1000 Lance, complete

12 YP1006 Stainless steel lance strap

13 B14X1.12/R 1/4” x 1-1/2” roofing bolt

14 NN14 1/4” unc nyloc nut

15 YPHTRG 16 X 8MM Rubber gasket

16 BOX16 Packing box

TTi’s BackUp16™/StandBy10 HandBook

10 Call 1800 816 277www.tti.com.au 10

Warranty

This Fire Fighting unit has been guaranteed free from defect in materials, workmanship

or manufacture for 12 months from the date of purchase. Any parts which appear

to us to be defective either in material or workmanship will be replaced or repaired

at no cost to the purchaser, subject to the following conditions:

1. The registration card enclosed in this handbook must be returned to us within 7

days of purchase

2. The guidelines in this handbook have been adhered to in every respect.

3. In unlikely event of sprayer failure, this should be reported to your dealer who will

act on your behalf to resolve the issue to your satisfaction.

4. Any defective parts will be returned by your dealer within 7 days of failure,

together with a report describing the failure and conditions in which the failure

occurred.

5. The following are specifically excluded from the terms of warranty

• Fair wear and tear to pump moving parts and diaphragms

• Fair wear and tear to nozzles and nozzle bodies

• Damage caused by neglect or lack of lubrication

• Damage caused by misuse or abuse

• Damage caused while the sprayer is in transit

Whilst every care has been taken in the preparation of these instructions, no liabilities

can be accepted with regard to errors or omissions. Product specifications are

subject to change in line with our commitment to continuous improvement.

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali TTI Attrezzature antincendio

TTI

TTI PantherPatrol Manuale di servizio

Manuali Attrezzature antincendio popolari di altre marche

Tyco Fire Protection Products

Tyco Fire Protection Products AM31 AQUAMIST Nozzle Manuale utente

Task Force Tips

Task Force Tips Extend-A-Gun RC3 Manuale del proprietario

Autronica

Autronica AutroSafe BSD-321/EX Manuale utente

POK

POK Froggy Manuale utente

Waterous

Waterous AQUIS Series Manuale

CTP

CTP NPO ETERNIS GUARANT-7 Manuale elenco delle parti

MSA

MSA M1 Manuale utente

Grundfos

Grundfos Hydro EN Manuale operativo

Amerex

Amerex 570 Guida all'applicazione

Vimpex

Vimpex BIG HP18-H200-B1 Manuale utente

Global Fire Equipment

Global Fire Equipment GFE-PA-VOX-A Manuale utente

Chubb

Chubb PEFS F3 Manuale utente

Projoy Electric

Projoy Electric PEFS-PL Series Manuale utente

klimaoprema

klimaoprema FDC25 Series Manuale utente

Tyco

Tyco 802SB Manuale utente

Mueller

Mueller Revive M2 Manuale utente

SEI Industries

SEI Industries BAMBI MAX BBXHL4000PF Manuale utente

Waterax

Waterax MARK-3 Manuale utente