Whispbar K505W Manuale utente

K505W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 4 x 4 x 8

x 4 x 2 x 1 x 1

x 4 x 2 x 2

Revision No: 7C 1

Fitting Kit K505W

MAX kgs (lbs)

W/P WHD

Hyundai

ix35 , 5dr SUV 10-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K505W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K505W

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

●Set bars to length (revert to rear of these

instructions).

●Clamps onto flush roof rail. Pins locate on

inside of rail.

Fitting Kit EN

K505W

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Remove both pins from each leg. Use

tapered end of spanner located inside left

hand cover to assist.

Fitting Kit EN

K505W

●Detach foot from leg. Store loose parts in a

safe place.

●Repeat for all legs.

●Select four feet assemblies and match the

left and right assemblies to the left and

right roof rack legs.

●Assemble foot from kit into leg by pressing

it down.

●Ensure foot interlocks with leg.

●Using short capscrew and washer, secure

assembly onto leg (use Hex Screwdriver

supplied with crossbar to assist)

●Do not over tighten.

●Repeat for all legs.

Fitting Kit EN

K505W

●Use two M5 x 12 mm self tapping screws to

secure the assembly onto the leg.

●Do not over tighten.

Fitment

●Locate two holes at each position along the

inside of the roof rails.

●Place crossbars approximately above

these holes on roof rails.

●Ensure back edge of foot sits flush with the

back edge of vehicle roof rail.

●NOTE: FRONT CROSSBAR ONLY

●Ensure the clamp point faces towards the

front of vehicle.

Fitting Kit EN

K505W

●Apply protective strip as shown.

Trim if required.

●It is important to put the clamps in the

correct position on the vehicle.

●Letters refer to the part numbers stamped

on clamps.

●Clamp Part Number:

A = 685D

B = 731A

C = 732A

●Ensure the two pins of the clamp engages

correctly with the holes in the roof rail.

●Place one hand on the leg and apply

downward pressure.

●Slide clamp through opening in leg.

Fitting Kit EN

K505W

●Thread the coach bolt through the clamp

and the leg.

●Ensure the two pins of the clamp engages

correctly with the holes in the roof rail.

●Tighten the plastic knob.

●Ensure the plastic knob is in the position

shown when fully tightened.

●Do not over tighten.

●Repeat for all four positions.

●Ensure the clamp engages correctly on

inside of roof rail.

●Use keys to fit and lock covers

●Check crossbar is securely attached to the

vehicle.

Fitting Kit EN

K505W

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Altri manuali per K505W

Indice

Altri manuali Whispbar Accessori per automobili

Whispbar

Whispbar K429W Manuale utente

Whispbar

Whispbar K120W Manuale utente

Whispbar

Whispbar K557 Manuale operativo e di installazione

Whispbar

Whispbar K587W Manuale utente

Whispbar

Whispbar K762W Manuale utente

Whispbar

Whispbar K399W Manuale utente

Whispbar

Whispbar K557W Manuale utente

Whispbar

Whispbar K674W Manuale utente

Whispbar

Whispbar K692W Guida all'installazione

Whispbar

Whispbar K621W Manuale utente

Whispbar

Whispbar K651W Manuale operativo e di installazione

Whispbar

Whispbar K376W Manuale utente

Whispbar

Whispbar K389W Manuale operativo e di installazione

Whispbar

Whispbar K468W Manuale utente

Whispbar

Whispbar K395W Manuale utente

Whispbar

Whispbar K747W Manuale utente

Whispbar

Whispbar K067W Manuale utente

Whispbar

Whispbar K622W Manuale operativo e di installazione

Whispbar

Whispbar K328 Manuale utente

Whispbar

Whispbar K083W Manuale utente

Whispbar

Whispbar K182W Manuale utente

Whispbar

Whispbar K484W Manuale utente

Whispbar

Whispbar K536W Manuale utente

Whispbar

Whispbar K723W Manuale utente

Manuali Accessori per automobili popolari di altre marche

James Baroud

James Baroud Odyssey Manuale utente

Motorola

Motorola i50sx Manuale utente

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuale utente

Feniex

Feniex T3 Manuale utente

Renault

Renault 77 11 423 180 Manuale utente

Kia

Kia E8300-4D000 Manuale utente

Brink

Brink 756843 Manuale utente

v.link

v.link CI-VL2-PC-HSD Manuale utente

Viking

Viking Stack-Rack Guida rapida alla configurazione

Aries

Aries 203015 Manuale utente

Choetech

Choetech AT0005 Manuale utente

ZZ2

ZZ2 ZZAIR-PRO Manuale utente

Holman

Holman 4A80L Manuale utente

Thule

Thule 2075 Manuale utente

Motorola

Motorola T325 Manuale utente

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guida all'installazione

DV8

DV8 FBJL-02 Manuale utente

Prorack

Prorack K1163 Manuale utente