Whispbar K603W Manuale utente

K603W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 8 x 4 x 1

x 8 x 4 x 4 x 4

x 4 x 1

Revision No: 4C 1

Fitting Kit K603W

MAX kgs (lbs)

W/P WHD

Nissan

Navara D40 Double Cab, 4dr Truck 05-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute 05-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Dec 05-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Nov 05-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K603W

Items you will require:

●Tape measure

Pen

Cordless drill

Depth stop

Vacuum cleaner

Rust inhibitor

Small paint brush

Neutral cure silicon sealant

Rivet gun

Attention:

●Attaches with permanent mount blocks

riveted to roof. Bar can be removed.

Professional installation advised.

Fitting Kit EN

K603W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type D crossbar

fitted. They also apply to type A, B and C.

●Use keys to remove covers.

Fitting Kit EN

K603W

●Remove Hex Key from right hand cover.

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

Fitting Kit EN

K603W

●Adjust crossbar in or out to suit vehicle.

●Please check the rear of this manual for

information relating specifically to your

vehicle.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all legs.

Fitting Kit EN

K603W

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

●Make sure the pad fits into the holes

underneath the foot.

●This setup is applicable for two crossbars

only.

●Recommended crossbar placement is as

shown.

Fitting Kit EN

K603W

●This setup is applicable for one crossbar

only.

●Recommended single crossbar placement

is above door pillar.

●Apply masking tape to vehicle roof in all

four positions.

●Position the permanent mount block so the

inner edge of the block is on the outer edge

of the ditch channel.

Fitting Kit EN

K603W

●With the drill, lightly mark both permanent

mount hole positions while holding the

mount firmly on roof.

●CAUTION: Maximum depth 7mm.

Use 7mm drillstop over supplied 4.9mm

drill bit.

Drill two outside holes at marked positions.

●Remove masking tape.

Fitting Kit EN

K603W

●Treat holes to prevent corrosion.

●Apply neutral cure silicon sealant in and

around drilled holes.

●Install rivets through permanent mount

blocks.

Altri manuali per K603W

Indice

Altri manuali Whispbar Accessori per automobili

Whispbar

Whispbar K511W Manuale utente

Whispbar

Whispbar K307W Manuale utente

Whispbar

Whispbar K456W Manuale utente

Whispbar

Whispbar S51W Manuale utente

Whispbar

Whispbar K655W Manuale utente

Whispbar

Whispbar K601W Manuale utente

Whispbar

Whispbar K555W Manuale utente

Whispbar

Whispbar K322W Manuale operativo e di installazione

Whispbar

Whispbar K490W Manuale utente

Whispbar

Whispbar K172W Manuale utente

Whispbar

Whispbar K507W Manuale utente

Whispbar

Whispbar K868W Manuale utente

Whispbar

Whispbar K553W Manuale operativo e di installazione

Whispbar

Whispbar K571 Manuale utente

Whispbar

Whispbar K866W Manuale operativo e di installazione

Whispbar

Whispbar K436 Manuale utente

Whispbar

Whispbar K172W Manuale utente

Whispbar

Whispbar K980W Manuale utente

Whispbar

Whispbar K063W Manuale utente

Whispbar

Whispbar K797W Manuale utente

Whispbar

Whispbar K1012W Manuale utente

Whispbar

Whispbar K821W Manuale utente

Whispbar

Whispbar K355W Manuale utente

Whispbar

Whispbar K301W Manuale operativo e di installazione

Manuali Accessori per automobili popolari di altre marche

James Baroud

James Baroud Odyssey Manuale utente

Motorola

Motorola i50sx Manuale utente

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuale utente

Feniex

Feniex T3 Manuale utente

Renault

Renault 77 11 423 180 Manuale utente

Kia

Kia E8300-4D000 Manuale utente

Brink

Brink 756843 Manuale utente

v.link

v.link CI-VL2-PC-HSD Manuale utente

Viking

Viking Stack-Rack Guida rapida alla configurazione

Aries

Aries 203015 Manuale utente

Choetech

Choetech AT0005 Manuale utente

ZZ2

ZZ2 ZZAIR-PRO Manuale utente

Holman

Holman 4A80L Manuale utente

Thule

Thule 2075 Manuale utente

Motorola

Motorola T325 Manuale utente

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guida all'installazione

DV8

DV8 FBJL-02 Manuale utente

Prorack

Prorack K1163 Manuale utente