Zodiac PRO 500 Manuale utente

Owner's Manual

Volume 2

Page 2 of 17

VOLUME 2

DESCRIPTION - BUOYANCY CHAMBER

PROPULSION SYSTEM

INSTALLATION AND CIRCUITS

CONTENTS

PAGE

I - GENERAL DESCRIPTIONS

I-1-Technical characteristics ----------------------------------------------------------

2 - 3

I-2-Inventory -------------------------------------------------------------------------------

I-3-Location of items---------------------------------------------------------------------

I-4-Handling -------------------------------------------------------------------------------

II - BUOYANCY CHAMBER

II-1-Setting up the buoyancy chamber –Main steps------------------------

II-2-Inflation system--------------------------------------------------------------

13 - 14

II-3-Pressure -----------------------------------------------------------------------

15 -16

III - PROPULSION SYSTEM

Page 3 / 17

DESCRIPTION - Technical characteristics

I-1-TECHNICAL CHARACTERISTICS

Dimensions

(m)

4.70

(ft)

15‘ 5“

(m)

3.38

(ft)

11‘ 1“

(m)

2.05

(ft)

6‘ 9“

(m)

1.05

(ft)

3‘ 5“

(m)

0.50

(ft)

1‘8“

Design category

(Directive 94/25/EC)

Capacity

(ISO)

Maximum

Kg (1)

1060

lb.(1)

2337

Kg (2)

230

lb.(2)

507

Compartment

Engine configuration

Minimum power

recommended

HP (3)

KW (3)

Maximum power

recommended

Maximum power

allowed

HP (3)

kW (3)

Maximum

Maximum engine

weight

170

Lbs

375

Overall dimensions

a (4)

4.70m

15‘ 5“

b (4)

2.05

6‘ 9“

c (4)

1.10

3‘ 7“

Page 4 of 17

DESCRIPTION - Technical characteristics

NOTE

Dimension tolerance: +/- 4%

NOTE

(1) The maximum payload has been calculated according to ISO 6185

standards. Operating at or near maximum payload is only advised in

calm water and at reduced speeds.

(2)Weight shown not including accessories

(3) The recommended power corresponds to optimum operation of the

boat's capabilities for an average load (9 people.)

(4)Hull dimensions without buoyancy chamber.

Use the maximum authorized power with extreme caution (see "Sailing

advice" chapter of Volume 1 of the manual.)

WARNING

DO NOT EXCEED THE MAXIMUM LOAD INDICATED ON THE

MANUFACTURER'S PLATE. THE MAXIMUM LOAD INCLUDES

THE WEIGHT OF THE ENGINE, FUEL, ACCESSORIES,

PASSENGERS AND THEIR EQUIPMENT AND ANY OTHER TYPE

OF LOAD.

Page 5 / 17

DESCRIPTION - Inventory

I-2-INVENTORY

HULL

Polyester hull

Counter-moulded non-slip deck

1 Bow ring

1 Anchor locker (capacity approximately 86 litres)

2 traction chain plates

1 Mooring cleat

1 Hull drain hole

1 high flow rate self-bailers with stern well

BUOYANCY CHAMBER

Removable buoyancy chamber

Rails + lashing

Easy push valves

Anti-chafing band with wide profile

External handles

Short cones

OPTIONAL ACCESSORIES

Anchoring tarpaulin

Roll bar

Console

Seat

Page 6 of 17

DESCRIPTION –Location of items

I-3-LOCATION OF ITEMS

ITEM

REF.

DESIGNATION

Buoyancy chamber

Anchor locker

Chain plate

Towing chain plates

high flow rate self-bailer

Hull drain hole

Page 7 / 17

Page 8 of 17

ITEM

REF.

DESIGNATION

Bow roller

Anchor locker cover

Lashing

Handle

Mooring cleat

Buoyancy chamber

AFT Chain plate

High flow rate self-bailer

Hull drain hole

Water shield

Easy push valve

Tank filler access

Page 9 / 17

DESCRIPTION - Handling

I-4-HANDLING

I-4-1-Transportation

The trailer installation recommendations are specified in VOLUME I of the owner's manual.

I-4-2-Storage

WARNING

THE BOAT MUST REST ON THE BOW LINE (SEE SKETCH

BELOW).

PRO 9 MAN (dimensions in mm)

Page 10 of 17

DESCRIPTION - Handling

1-4-3-Lifting

To lift your boat:

You can use a 4-wire sling obtainable from your Zodiac dealer.

To carry out this operation you have to:

a- Remove the aft chain plates and refit them with the ring reversed (facing forward).

b- Fit the bow of the boat with 2 additional chain plates (contact your ZODIAC

dealer). The diagram below shows the areas where the fore chain plates are located

(distances in millimetres).

All these fittings must be made watertight using Sikaflex.

Stiffener area

200 x 200 mm

Altri manuali per PRO 500

Indice

Altri manuali Zodiac Barca

Zodiac

Zodiac MILPRO HEAVY DUTY Series Manuale utente

Zodiac

Zodiac Medline 9 2022 Manuale utente

Zodiac

Zodiac MEDLINE 9 Manuale utente

Zodiac

Zodiac NZO-760 Manuale utente

Zodiac

Zodiac YACHTLINE 490 Manuale utente

Zodiac

Zodiac CLASSIC MARK 1 Manuale utente

Zodiac

Zodiac ZOOM 230 Roll Up Manuale utente

Zodiac

Zodiac CADET 200 Roll Up Manuale utente

Zodiac

Zodiac MILPRO ERB Series Manuale utente

Zodiac

Zodiac eJET 450 Manuale utente

Zodiac

Zodiac MilPro ERB 310 Manuale utente

Zodiac

Zodiac CADET 200 Roll Up Manuale utente

Zodiac

Zodiac PRO 12MAN Guida

Zodiac

Zodiac Pro 420 Manuale utente

Zodiac

Zodiac NZO 600 Manuale utente

Zodiac

Zodiac YACHTLINE 360 Manuale utente

Zodiac

Zodiac MilPro SRMN 500 Manuale utente

Zodiac

Zodiac FUTURA MARK 2C Manuale utente

Zodiac

Zodiac PRO 550 Manuale utente

Zodiac

Zodiac CADET ROLL UP 200 Manuale utente

Zodiac

Zodiac CADET AERO Manuale utente

Zodiac

Zodiac PRO 850 Manuale utente

Zodiac

Zodiac NZO 600 Manuale utente

Zodiac

Zodiac eOPEN 3.4 Manuale utente

Manuali Barca popolari di altre marche

Raymarine

Raymarine ST70 Instrument Manuale utente

Pro-Line Boats

Pro-Line Boats Pro Line 19 Sport Manuale utente

Jeanneau

Jeanneau CAP CAMARAT 8.5 CC Manuale utente

Tiara Yachts

Tiara Yachts C49 2024 Manuale utente

Monterey Boats

Monterey Boats Sport Yacht 330 Manuale utente

J 105 Manuale utente

PURSUIT

PURSUIT OS 335 Manuale utente

Boston Whaler

Boston Whaler CONQUEST 345 Manuale utente

Jeanneau

Jeanneau SUN ODYSSEY 41 DS Manuale utente

Meridian

Meridian 490 Pilothouse Manuale utente

Advanced Elements

Advanced Elements AdvancedFrame Expedition AE1009 Manuale utente

Robo Marine Indonesia

Robo Marine Indonesia GEOMAR Manuale utente

Swallow Boats

Swallow Boats BayRaider Manuale utente

Intex

Intex Excursion 5 Set Manuale utente

X SHORE

X SHORE EELEX 8000 Manuale utente

ISLAND PACKET

ISLAND PACKET 370 Manuale utente

Sea Ray

Sea Ray 175 Sport Manuale utente

Regal

Regal 2300 Manuale utente