Alliance Laundry Systems 512685R2 Manuale utente

Installation/Operation

www.comlaundry.com

D009C

Stacked

Clothes Dryer

Nonmetered and Metered

Electric and Gas Models

Part No. 512685R2

July 2007

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

Para bajar una copia de estas instrucciones

en español, visite www.comlaundry.com.

IMPORTANT: Purchaser must consult the local gas supplier for suggested instructions to be followed if the

dryer user smells gas. The gas utility instructions plus the SAFETY and WARNING note directly above

must be posted in a prominent location near the dryer for customer use.

The following information applies to the state of Massachusetts, USA.

•This appliance can only be installed by a Massachusetts licensed plumber or gas fitter.

•This appliance must be installed with a 36 inch (91 cm) long flexible gas connector.

•A “T-Handle” type gas shut-off valve must be installed in the gas supply line to this appliance.

•This appliance must not be installed in a bedroom or bathroom.

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance.

• WHAT TO DO IF YOU SMELL GAS:

– Do not try to light any appliance.

– Do not touch any electrical switch; do not use any phone in your building.

– Clear the room, building or area of all occupants.

– Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s

instructions.

– If you cannot reach your gas supplier, call the fire department.

• Installation and service must be performed by a qualified installer, service agency or the gas

supplier. W052

FOR YOUR SAFETY, the information in this manual must be followed to minimize

the risk of fire or explosion or to prevent property damage, personal injury or

death. W033

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of

this or any other appliance. W053

means without the expressed written consent of the publisher.

512685

Table of

Contents

Safety Information.............................................................................. 4

Explanation of Safety Messages........................................................... 4

Important Safety Instructions ............................................................... 4

Installation........................................................................................... 6

Nonmetered Models......................................................................... 6

Metered Models ............................................................................... 7

Before You Start ................................................................................... 8

Tools ................................................................................................ 8

Additional Security............................................................................... 8

Installing the Dryer ............................................................................... 9

Step 1: Position and Level the Dryer ............................................... 9

Step 2: Connect Dryer Unit Exhaust System................................... 10

Exhaust Direction............................................................................. 12

Exhaust System................................................................................ 12

Multi-Dryer Installation Exhaust Requirements.............................. 13

Step 3: (Gas Dryer Only) Connect Gas Supply Pipe ....................... 15

Step 4: (Electric Dryer Only) Connect Electrical Plug.................... 16

Step 5: Reverse Door, if Desired ..................................................... 22

Step 6: Wipe Out Inside of Dryer .................................................... 23

Step 7: Plug In the Dryer ................................................................. 23

Step 8: Recheck Steps 1-7................................................................ 24

Step 9: Check Heat Source .............................................................. 24

Vending................................................................................................ 26

Coin Slide Guards................................................................................. 26

Coin Slide Control ................................................................................ 26

Power-Up Mode............................................................................... 26

Ready Mode ..................................................................................... 26

Start Mode........................................................................................ 26

Run Mode......................................................................................... 26

Door Open Mode ............................................................................. 26

End of Cycle Mode .......................................................................... 26

Topoffs............................................................................................. 27

Temperature Selector Switch........................................................... 27

Error Display Mode ......................................................................... 27

Setting Dry Time Dipswitches.............................................................. 27

Dipswitch Settings ................................................................................ 28

Test Setting ...................................................................................... 30

Slide Extension ..................................................................................... 31

Operation............................................................................................. 33

Operation Instructions for Nonmetered and Coin Slide Dryers ........... 33

Step 1: Clean Lint Filter................................................................... 33

Step 2: Load Laundry....................................................................... 33

Step 3: Close Loading Door............................................................. 33

Step 4: Determine Proper Dryer ...................................................... 34

Step 5: Set Fabric Selector............................................................... 34

Step 6: Start Dryer ........................................................................... 34

512685 3

Operation Instructions for Electronic Display Control Dryers............. 35

Step 1: Clean Lint Filter................................................................... 35

Step 2: Load Laundry....................................................................... 35

Step 3: Close Loading Door............................................................. 35

Step 4: Determine Proper Dryer ...................................................... 35

Step 5: Set Fabric Selector............................................................... 36

Step 6: Insert Coin(s) or Card .......................................................... 36

Step 7: Start Dryer ........................................................................... 37

Indicator Lights................................................................................ 37

Operation Instructions for MDC Dryers............................................... 38

Step 1: Clean Lint Filter................................................................... 38

Step 2: Load Laundry....................................................................... 38

Step 3: Close Loading Door............................................................. 38

Step 4: Determine Proper Dryer ...................................................... 38

Step 5: Set Fabric Selector............................................................... 38

Step 6: Insert Coin(s) or Card .......................................................... 39

Step 7: Start Dryer ........................................................................... 39

Indicator Lights................................................................................ 39

Operation Instructions for NetMaster Dryers ....................................... 40

Step 1: Clean Lint Filter................................................................... 40

Step 2: Load Laundry....................................................................... 40

Step 3: Close Loading Door............................................................. 40

Step 4: Determine Proper Dryer ...................................................... 40

Step 5: Set Fabric Selector............................................................... 41

Step 6: Insert Coin(s) or Card .......................................................... 41

Step 7: Start Dryer ........................................................................... 41

Indicator Lights................................................................................ 42

Maintenance ........................................................................................ 43

Lubrication............................................................................................ 43

Care of Your Dryer............................................................................... 43

Dryer Interior ................................................................................... 43

Cabinet ............................................................................................. 43

Control Panel ................................................................................... 43

Exhaust System................................................................................ 43

Lint Filter .............................................................................................. 44

Motor Overload Protector..................................................................... 44

For Energy Conservation...................................................................... 44

Troubleshooting .................................................................................. 45

Contact Information........................................................................... 46

Installer Checklist............................................................... Back Cover

4512685

Safety Information

Explanation of Safety Messages

Throughout this manual and on machine decals, you

will find precautionary statements (“DANGER,”

“WARNING,” and “CAUTION”) followed by specific

instructions. These precautions are intended for the

personal safety of the operator, user, servicer, and

those maintaining the machine.

Additional precautionary statements (“IMPORTANT”

and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used

to inform the reader of specific procedures where

minor machine damage will occur if the procedure

is not followed.

NOTE: The word “NOTE” is used to communicate

installation, operation, maintenance or servicing

information that is important but not hazard

related.

Important Safety Instructions

Save These Instructions

1. Read all instructions before using the dryer.

2. Refer to the GROUNDING INSTRUCTIONS in

the INSTALLATION manual for the proper

grounding of the dryer.

3. Do not dry articles that have been previously

cleaned in, washed in, soaked in, or spotted with

gasoline, dry-cleaning solvents, other flammable

or explosive substances as they give off vapors

that could ignite or explode.

4. Do not allow children to play on or in the dryer.

Close supervision of children is necessary when

the dryer is used near children. This is a safety

rule for all appliances.

5. Before the dryer is removed from service or

discarded, remove the door to the drying

compartment.

6. Do not reach into the dryer if the cylinder is

revolving.

7. Do not install or store the dryer where it will be

exposed to water and/or weather.

8. Do not tamper with the controls.

9. Do not repair or replace any part of the dryer, or

attempt any servicing unless specifically

recommended in the user-maintenance

instructions or in published user-repair

instructions that you understand and have the

skills to carry out.

10. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

11. To reduce the risk of fire, DO NOT DRY plastics

or articles containing foam rubber or similarly

textured rubberlike materials.

12. ALWAYS clean the lint filter after every load. A

layer of lint in the filter reduces drying efficiency

and prolongs drying time.

Indicates an imminently hazardous

situation that, if not avoided, will cause

severe personal injury or death.

DANGER

Indicates a hazardous situation that, if not

avoided, could cause severe personal

injury or death.

WARNING

Indicates a hazardous situation that, if not

avoided, may cause minor or moderate

personal injury or property damage.

CAUTION

To reduce the risk of fire, electric shock,

or injury to persons when using your

dryer, follow these basic precautions: W034

WARNING

Safety Information

512685

13. Keep area around the exhaust opening and

adjacent surrounding area free from the

accumulation of lint, dust and dirt.

14. The interior of the dryer and the exhaust duct

should be cleaned periodically by qualified

service personnel.

15. If not installed, operated and maintained in

accordance with the manufacturer’s instructions

or if there is damage to or mishandling of this

product’s components, use of this product could

expose you to substances in the fuel or from fuel

combustion which can cause death or serious

illness and which are known to the State of

California to cause cancer, birth defects or other

reproductive harm.

16. Dryer will not operate with the loading door

open. DO NOT bypass the door safety switch by

permitting the dryer to operate with the door

open. The dryer will stop tumbling when the door

is opened. Do not use the dryer if it does not stop

tumbling when the door is opened or starts

tumbling without pressing the START

mechanism. Remove the dryer from use and call

the service person.

17. Do not put articles soiled with vegetable or

cooking oil in the dryer, as these oils may not be

removed during washing. Due to the remaining

oil, the fabric may catch on fire by itself.

18. To reduce the risk of fire, DO NOT put clothes

which have traces of any flammable substances

such as machine oil, flammable chemicals,

thinner, etc., or anything containing wax or

chemicals such as in mops and cleaning cloths, or

anything dry-cleaned at home with a dry-

cleaning solvent in the dryer.

19. Use the dryer only for its intended purpose,

drying clothes.

20. Always disconnect the electrical power to the

dryer before attempting service. Disconnect the

power cord by grasping the plug, not the cord.

21. If supply cord is damaged, it must be replaced by

a special cord or assembly available from the

manufacturer or its service agent.

22. Install this dryer according to the

INSTALLATION INSTRUCTIONS. All

connections for electrical power, grounding and

gas supply must comply with local codes and be

made by licensed personnel when required. Do

not do it yourself unless you know how!

23. Remove laundry immediately after the dryer

stops.

24. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of reach of children at all times

(preferably in a locked cabinet).

25. Do not tumble fiberglass curtains and draperies

unless the label says it can be done. If they are

dried, wipe out the cylinder with a damp cloth to

remove particles of fiberglass.

26. ALWAYS follow the fabric care instructions

supplied by the garment manufacturer.

27. Never operate the dryer with any guards and/or

panels removed.

28. DO NOT operate the dryer with missing or

broken parts.

29. DO NOT bypass any safety devices.

30. DO NOT operate dryers if the units have been

separated.

31. Failure to install, maintain, and/or operate this

machine according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

IMPORTANT: Solvent vapors from dry-cleaning

machines create acids when drawn through the

heater of the drying unit. These acids are corrosive

to the dryer as well as to the laundry load being

dried. Be sure make-up air is free of solvent vapors.

IMPORTANT: Have your dryer installed properly.

Don’t do it yourself unless you know how!

NOTE: The WARNING and IMPORTANT

SAFETY INSTRUCTIONS appearing in this

manual are not meant to cover all possible

conditions and situations that may occur. Common

sense, caution and care must be exercised when

installing, maintaining, or operating the dryer.

Always contact your dealer, distributor, service agent

or the manufacturer about any problems or conditions

you do not understand.

6512685

Installation

Nonmetered Models

DRY2104N

*With leveling legs turned into base.

DRY2104N

7 in.

(17.8 cm)

*76.5 in. (194.3 cm)

*44.8 in. (113.8 cm)

23.5 in.

(59.7 cm)

8 in.

(20.3 cm)

4 in.

(10.2 cm)

26.9 in.

(68.3 cm)

15.5 in. (39.4 cm)

28 in.

(71.1 cm)

4.5 in.

(11.4 cm)

*15.44 in.

(39.2 cm)

*39.38 in. (100 cm)

ELECTRIC MODELS

DRY2105N

*With leveling legs turned into base.

13/8 in. N.P.T. Gas Connection

DRY2105N

7 in.

(17.8 cm)

*76.5 in. (194.3 cm)

*44.8 in. (113.8 cm)

23.5 in.

(59.7 cm)

4 in.

(10.2 cm)

26.9 in.

(68.3 cm)

28 in.

(71.1 cm)

GAS MODELS

2.8 in.

(7.1 cm)

8 in.

(20.3 cm)

4.5 in.

(11.4 cm)

2.3 in.

(6 cm) *15.44 in.

(39.2 cm)

*43.5 in. (110.5 cm)

*39.38 in. (100 cm)

15.5 in.

(39.4 cm)

Installation

512685

Metered Models

NOTE: Side, rear and bottom exhaust openings are

4 inch (10.2 cm) ducting. Gas models cannot be

vented out left side of cabinet because of burner

housing.

IMPORTANT: The dryer should have sufficient

clearance around it for needed ventilation and for

the ease of installation and servicing. For maximum

drying performance, we recommend that more

clearance be allowed around the dryer than the

clearances that are listed throughout this manual.

DRY2102N

*With leveling legs turned into base. NOTE: Not all models have windows.

DRY2103N

*With leveling legs turned into base. NOTE: Not all models have windows.

13/8 in. N.P.T. Gas Connection

DRY2102N

7 in.

(17.8 cm)

*76.5 in. (194.3 cm)

*44.8 in. (113.8 cm)

23.5 in.

(59.7 cm)

8 in.

(20.3 cm)

4 in.

(10.2 cm)

26.9 in.

(68.3 cm)

15.5 in. (39.4 cm)

28 in.

(71.1 cm)

4.5 in.

(11.4 cm)

*15.44 in.

(39.2 cm)

ELECTRIC MODELS

Coin Slide Models

*39.38 in. (100 cm)

Electronic Control Models

*36.94 in. (93.8 cm)

DRY2103N

7 in.

(17.8 cm)

*76.5 in. (194.3 cm)

*44.8 in. (113.8 cm)

23.5 in.

(59.7 cm)

4 in.

(10.2 cm)

26.9 in.

(68.3 cm)

28 in.

(71.1 cm)

GAS MODELS

*43.5 in. (110.5 cm)

*15.44 in.

(39.2 cm)

8 in.

(20.3 cm)

4.5 in.

(11.4 cm)

2.3 in.

(6 cm)

2.8 in.

(7.1 cm)

Coin Slide Models

*39.38 in. (100 cm)

Electronic Control Models

*36.94 in. (93.8 cm)

15.5 in.

(39.4 cm)

Installation

512685

Before You Start

Tools

For most installations, the basic tools you will need

are:

Figure 1

NOTE: An 8 in. (20.32 cm) coin drawer is required

for coin operated MDC and NetMaster models.

Additional Security

Torx security screws are available (as optional

equipment at extra cost) for securing both lower access

panels to each dryer base. Order Part No. 62853.

A Torx bit, Part No. 282P4, is available (as optional

equipment at extra cost) for installing the Torx security

screws.

A Torx bit holder, Part No. 24161, is available (as

optional equipment at extra cost) to be used with the

Torx bit.

D818I

1Wrench

2Screwdrivers

3Level

4Te f l o n Ta p e

5Duct Tape

1 2

Any disassembly requiring the use of

tools must be performed by a suitably

qualified service person. W299

WARNING

Indice

Altri manuali Alliance Laundry Systems Asciugatrice

Alliance Laundry Systems

Alliance Laundry Systems 70269701R4 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SWD439C Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems CTSA9AWN Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 120 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumbler 70278501R5EN Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems CA170L Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guida

Alliance Laundry Systems

Alliance Laundry Systems LES37AW Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems Dryer Tumblers Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 504522R3 Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CA025L Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems Drying Cabinet Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY724C_SVG Guida

Alliance Laundry Systems

Alliance Laundry Systems DRY683C Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DC0220SFG Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY735C SVG Series Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY722C-SVG Guida

Alliance Laundry Systems

Alliance Laundry Systems 512906 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SDE807 Guida

Alliance Laundry Systems

Alliance Laundry Systems HSE117*C802 Istruzioni per il montaggio

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers none Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY735C-SVG Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 907003062 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 70223701R2 Manuale utente

Manuali Asciugatrice popolari di altre marche

Bosch

Bosch WTA79200GB Manuale utente

Amana

Amana W10233410A Manuale utente

Miele

Miele TWH 780 WP Manuale utente

Asko

Asko T760 Manuale utente

Bosch

Bosch Logixx 10 WTB76556GB Scheda tecnica

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manuale di istruzioni

Electrolux

Electrolux EW2H328R2 Manuale utente

Beko

Beko DS8433RX1M Manuale utente

Dawlance

Dawlance Spinner DS 6000 C Manuale utente

Electrolux

Electrolux TP5080TW Manuale utente

AEG

AEG TR838P4OB Manuale utente

Indesit

Indesit IDV 75 Manuale utente

Infiniton

Infiniton SD-DG85C Manuale utente

BOMANN

BOMANN WT 5019 Manuale utente

Asko

Asko T793C Manuale utente

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manuale utente

Frigidaire

Frigidaire CAQE7077KW0 Manuale del proprietario

Bosch

Bosch WTX8HKM9SN Manuale utente