Aplex APC-3X97A Manuale utente
APC-3X97Auser manual
1
APC-3X97A Panel PC
User Manual
Release Date Revision
Apr 2012 V1.0
® 2012 Aplex Technology, Inc. All Rights Reserved. Published in Taiwan
Aplex Technology, Inc.
15F-1, No.186, Jian Yi Road, Zhonghe District, New Taipei City 235, Taiwan
APC-3X97Auser manual
2
Warning!___________________________________
Safety & Warranty
1. Read these safety instructions carefully.
2. Keep this user's manual for later reference.
3. Disconnect this equipment from any outlet before cleaning. Do not use liquid or spray
detergents for cleaning. Use a damp cloth.
4. For pluggable equipment, the power outlet must be installed near the equipment and must be
easily accessible.
5. Keep this equipment away from humidity.
6. Put this equipment on a reliable surface during installation. Dropping it or letting it fall could
cause damage.
7. The openings on the enclosure are for air convection. Protect the equipment from overheating.
DO NOT COVER THE OPENINGS.
8. Make sure the voltage of the power source is correct before connecting the equipment to the
power outlet.
9. All cautions and warnings on the equipment should be noted.
10. If the equipment is not used for a long time, disconnect it from the power source to avoid
damage by transient over-voltage.
11. Never pour any liquid into an opening. This could cause fire or electrical shock.
12. NEVER OPEN THE EQUIPMENT. FOR SAFETY REASONS, ONLY QUALIFIED SERVICE
PERSONNEL SHOULD OPEN THE EQUIPMENT.
13. If any of the following situations arises, get the equipment checked by service personnel:
�The power cord or plug is damaged.
�Liquid has penetrated into the equipment.
�The equipment has been exposed to moisture.
�The equipment does not work well, or you cannot get it to work according to the users manual.
�The equipment has been dropped and damaged.
�The equipment has obvious signs of breakage.
14. DO NOT LEAVE THIS EQUIPMENT IN AN ENVIRONMENT WHERE THE STORAGE
TEMPERATURE IS BELOW -20°C OR ABOVE 70°C. IT MAY DAMAGE THE EQUIPMENT.
APC-3X97Auser manual
3
This equipment generates uses and can radiate radio frequency energy and if not installed and
used in accordance with the instructions manual, it may cause interference to radio
communications.
It has been tested and found to comply with the limits for a Class A computing device pursuant to
FCC Rules, which are designed to provide reasonable protection against such interference when
operated in a commercial environment. Operation of this equipment in a residential area is likely
to cause interference in which case the user at his own expense will be required to take whatever
measures may be required to correct the interference.
Disclaimer
This information in this document is subject to change without notice. In no event shall Aplex Technology
Inc. be liable for damages of any kind, whether incidental or consequential, arising from either the use or
misuse of information in this document or in any related materials.
Electric Shock Hazard –Do not operate the machine with its back cover removed. There are
dangerous high voltages inside.
APC-3X97Auser manual
4
Table of Contents______________________
Warning!…………………………………………………………………………….……..….2
Disclaimer………………………………………………………………….…………………2
Chapter 1 Getting Started
1.1 Features…......…………….……………………………………..…..…...…6
1.2 Specifications………………………………………….………………...…..6
1.3 Brief Description ……………………………...……………………………8
1.4 Chassis Dimensions..…………………………………………………..…..9
Chapter 2 Mainboard
2.1 Mainboard Specifications….……………………….………………...........12
2.2 Onboard Jumpers and Port Pinouts……….……………….…….…….......18
Chapter 3 AMI BIOS Setup
3.1 Operations after POST Screen................................................27
3.2 Standard CMOS Features..............................................28
3.3 Advanced BIOS Features.....................................................31
3.4 Advanced Chipset Features Setup............................... 34
3.5 Integrated Peripherals................................................................... 37
3.6 Power Managements Setup................................................. 42
3.7 PnP/PCI Configurations Setup...................................................... 45
3.8 PC Health Status…................................................................ 47
3.9 Load Fail-Safe/Optimized Defaults.............................................. 48
3.10 Set Administrator/User Password....................................... 50
3.11 Save & Exit Setup……………............................................. 50
3.12 Exit Without Saving…………………………………….……………………. 51
Chapter 4
4.1 SuperIO Model.................................................................................................52
APC-3X97Auser manual
5
4.2 W83627UHG Access index port...................................................52
4.3 Configure GPIO register sequence................................................................52
4.4 Read/write GPIO sequence………………………………………………….......52
4.5 Software programming example....................................................................52
Chapter 5
5 Watchdog Source Code...................................................................................59
Chapter 6 Installation of Drivers
6.1 Intel Chipset Drivers .....……………….……………………………….63
6.2 Intel Graphics Media Accelerator Driver……..……………………….66
6.3 RealTek Gigabit LAN Driver………………………………………….70
6.4 Realtek HD Driver Installations…………………………………… 73
Chapter 7 Touch Driver Installation
7.1 Windows 2000/XP Driver Installation for Controller Board.……….….76
7.2 Configuring PenMount Windows 2000/XP Driver……………………..76
Figures
Figure 1.1: Front View ………………….……………………………..…………8
Figure 1.2: Rear View…………...…………………………………………………8
Figure 1.3: Dimensions of the APC-3597A ...........…………………………………9
Figure 1.4: Dimensions of the APC-3797A ………………………… ………..…10
Figure 1.5: Dimensions of the APC-3997A.........................................................11
Figure 2.1: Mainboard Overview….………………..….……………………..……..12
Figure 2.2: Mainboard Dimensions…………………………………………………13
Figure 2.3: Connector and Jumper Locations……………………………………15
Figure 7.1: Bird’s Eye View of Control Board....................................................76
APC-3X97Auser manual
6
Chapter 1_____________________________
1.1 Features
Fanless Design
Intel Atom N270 1.6GHz Processor, FSB 533MHz
One 200 Pin SO-DIMM socket, up to 2GB DDR2 533MHz SDRAM
11~32V DC wide range power input
Total NEMA4/IP65 compliant
Sealed 5-Wire Resistive Touch Screen, Optional for GFG Resistive Touch Screen
1.2 Specifications
System
System
Processor
Intel Atom Processor N270 1.6GHz built-in, FSB533MHz
System Memory
1 x 200-pin SO-DIMM socket, support 533MHz up to 2GB SDRAM
System Chipset
Intel 945GSE + Intel ICH7M
External I/O Port
Standard I/O:
2 x USB 2.0 connectors
1 x RJ-45 LAN connector
1 x DB-9 RS-232 (COM 1) connector
1 x DB-9 RS-232/422/485 connector (COM 2), Default RS-232
1 x DC Power input
Full Function I/O:
1 x VGA DB-15 port
1 x Audio Line-out port
Solid Storage Disk
1 x CF Slot (internal)
1 x 2.5” HDD bay for SATA HDD
OS Support
Windows XP Professional, XP Embedded
LCD
Display Type
TFT-LCD
Max. Resolution
15”1024x768 (APC-3597A)
17”/19”1280x1024 (APC-3797A/3997A)
Max. Color
262K
Luminance (cd/m2)
350 (cd/m2)(APC-3597A)
300 (cd/m2)(APC-3797A/3997A)
ViewAngle
H:120°/ V:100°(APC-3597A)
H:160°/ V:170°(APC-3797A)
APC-3X97Auser manual
7
H:160°/ V:160°(APC-3997A)
Backlight Lifetime
50,000hrs
Touch Screen
Type
Resistive Type
Light Transmission
80%
Power Supply
Power Input
DC 11~32V
Mechanical
Construction
Stainless Steel
IP Rating
Total IP65
Mounting
VESA 75x75 (APC-3597A/3797A)
VESA 100x100 (APC-3997A)
Dimension
399 (W) x324(H) x 53 (D) mm (APC-3597A)
432 (W) x358(H) x 57 (D) mm (APC-3797A)
470 (W) x389(H) x 60 (D) mm (APC-3997A)
Environmental
Operating Temperature
0~50 ﾟC
Storage Temperature
-20~60 ﾟC
Storage Humidity
10~90% @40℃non-condensing
Certificate
Meet CE/FCC Class A
APC-3X97Auser manual
8
1.3 Brief Description of the APC-3X97A
The chassis of theAPC-3X97A is made of stainless steel with an ultra slim profile. It is built in the Intel
Atom N270 1.6GHz, FSB 533MHz, it is fanless. The model comes with a 15”~19”inch TFT LCD
display, total NEMA 4/IP65 compliant, space for one 2.5-inch HDD, resistive touch screen, a DC
11~32V wide range power input. This industrial panel PC also features 2 COM ports, 2 USB ports and
1 x Gigabit LAN port. It is ideal for use as a PC-based controller for Automotive, Logistic Process,
Materials Handling, and Kiosk applications.
Figure 1.1: Front View of APC-3997A
Figure 1.2: Rear View of APC-3997A
APC-3X97Auser manual
9
1.4 Chassis Dimensions
Figure 1.3: Dimensions of the APC-3597A
APC-3X97Auser manual
10
Figure 1.4 Dimensions of the APC-3797A
Indice
Altri manuali Aplex Pannello touch
Aplex
Aplex AEx-P526 Manuale utente
Aplex
Aplex AEx-815P Manuale utente
Aplex
Aplex APC-3514B Manuale utente
Aplex
Aplex APC-3918P Manuale utente
Aplex
Aplex VITAM-9 A Series Manuale utente
Aplex
Aplex APC-3284A Manuale utente
Aplex
Aplex ViTAM-610 Series Manuale utente
Aplex
Aplex APC-3584B Manuale utente
Aplex
Aplex APC-3X19A Manuale utente
Aplex
Aplex ARCHMI-8XX Series Manuale utente
Aplex
Aplex APC-3519 Manuale utente
Aplex
Aplex VITAM-9 A Series Manuale utente
Aplex
Aplex APC-3X17B Manuale utente
Aplex
Aplex ViTAM-8 Series Manuale utente
Aplex
Aplex ARCHMI-9 Series Manuale utente
Aplex
Aplex ARCHMI-932P Manuale utente
Aplex
Aplex APC-3XX9A Manuale utente
Aplex
Aplex APC-3580 Manuale utente
Aplex
Aplex ViTAM-924A Manuale utente
Aplex
Aplex ViTAM-610PH Manuale utente
