Cornelius NITROPRO MINI Manuale utente

NitroproMini(Model:CNBMini)

©2019,CorneliusInc.AllRightsReserved PublicationNumber:548000141

KITINSTUCTIONS

PREVENTATIVEMAINTENANCEKIT629097835‐548000141

Thiskitprovidesinstructionsforreplacementof

theaircompressorairfilterandtheconcentrate

pumpinternaltubing.

1.0AirCompressorAirFilter

Theaircompressor(Fig.1)islocatedintheleft

rearoftheenclosure.

1)Shutoffthepowertothedispenserandunplug

thepowercordfromthewallreceptacle.

2)Removethetop,back,andleftaccesspanels

fromthedispenser.

3)Withpoweroff,pullthereliefvalvering(Fig.2)

todepressurizetheairstoragechamber.

4)Notetheorientationoftheairfilter(Fig.1).

5)Disconnecttheairfilterfromtheairlineby

pressingonthedarkgrayringonthehoseside

ofeachconnectorwhilewithdrawingthehose.

6)Installthenewairfilterbyfirmlypressingthe

airhoseintoeachfilter‐connectorend.

7)Applypowerandconfirmnoairleakageatair‐

filterconnections.

8)Reinstalltheenclosureaccesspanels.

2.0ConcentratePumpTubing

1)Insidethecabinet,disconnectthewaterandair

linesatthebackofthechamber.

2)Pulleachtaptorelievelinepressure.

3)ShutoffpowertotheNitroprounit.

4)Inthecabinet,unplugthewiringconnector

fromthemixing‐dispensingassemblyand

removetheassembly.Placeitonthecounter‐

top(Fig.3).

5)Noteormarkthelocationsofthepumphoses

forreassembly.

6)Disconnectthetwohosesfromthepumpby

removingthehoseclampusingsidecuttersor

therecommendedOetikerHIP2800Escrimp‐

ing/cuttingtool(Fig.4).Cuttheclampopen.

Figure1‐AirCompressorAirFilter

Figure2‐AirCompressorPressureReliefValve

Figure3‐Mixing‐DispensingAssemblyRemoved

NitroproMini(Model:CNBMini)

PublicationNumber:548000141 ©2019,CorneliusInc.AllRightsReserved

KITINSTUCTIONS

PREVENTATIVEMAINTENANCEKIT629097835‐548000141

2.0ConcentratePumpTubing(Cont.)

Becarefultoavoiddamagingthetubing

whenremovingthehoseclamp.

7)Removethefourscrewssecuringthepump

brackettotheassemblybaseplate(accessfrom

underneath).

8)Openthepumpcoverbyremovingthethree

thumbscrewsontop(Fig.5).

9)Liftoutthepumprotorandbearing.Slideout

thetwopump‐hosenipplesfromthepump

housing.

10)Cleanthepump‐hosechamberasrequired.

11)Installthenewpumphose.Wheninstallingit

orienttherotorasshownintheupperphotos

ofFig.5sothatonlyonepointonthehose

mustbecompressed.

12)Reinstallthepumpcover.

13)Installthepumponthebaseplateandrecon‐

nectthehosesusingnewhoseclampsand

theOetiker(orequivalent)crimpingtool.

14)Reinstallthemixing‐dispensingassemblyinto

thecabinet,makingsuretoreconnectthe

plumbingandelectricalconnectors.

15)Confirmpumpoperationbydispensingboth

producttypesuntilairispurgedfromthe

lines.Checkforleaks.

CAUTION!

Figure4‐HoseClampRemoval(OeitikerTool)

Figure5‐ConcentratePumpandReplacementHose

PumpClosed PumpOpen

PumpHose

Altri manuali per NITROPRO MINI

Questo manuale è adatto per i seguenti modelli

Altri manuali Cornelius Distributore

Cornelius

Cornelius SPIRE 4.2 Guida di sicurezza

Cornelius

Cornelius VIPER 3 FLAVOR Manuale utente

Cornelius

Cornelius ED 300 BC Manuale utente

Cornelius

Cornelius Quest Elite 2000 Manuale utente

Cornelius

Cornelius ICE-COOLED CHEST-A-FIELD DISPENSER Manuale utente

Cornelius

Cornelius IDC PRO 255 Manuale utente

Cornelius

Cornelius FCB OVERCOUNTER POST-MIX DISPENSER Manuale utente

Cornelius

Cornelius essense Manuale utente

Cornelius

Cornelius 318569000 Manuale utente

Cornelius

Cornelius NITROPRO MINI Manuale utente

Cornelius

Cornelius IDC 255 PROGATE DRIVE THRU UNIT Manuale utente

Cornelius

Cornelius Millenium II Manuale utente

Cornelius

Cornelius PearlMini Manuale utente

Cornelius

Cornelius Cascata180 Manuale

Cornelius

Cornelius Flavor OverLoad CG5017-1007 Manuale utente

Cornelius

Cornelius Millenium II 4000 Manuale utente

Cornelius

Cornelius FCB 3 H.P. POST-MIX DISPENSER Supplemento

Cornelius

Cornelius 2230 C4-100 Manuale utente

Cornelius

Cornelius JetSpray JS7 Manuale utente

Cornelius

Cornelius Brewed Iced Tea Supplemento

Cornelius

Cornelius ED2XX-B Series Manuale utente

Cornelius

Cornelius IDC Pro Guida

Cornelius

Cornelius QUEST ELITE 4290 Manuale utente

Cornelius

Cornelius 8027 Manuale utente

Manuali Distributore popolari di altre marche

Silver King

Silver King Majestic SK12MAJ Guida rapida

Franke

Franke F3Dn Twin Manuale utente

STIEBEL ELTRON

STIEBEL ELTRON UltraHot Plus Manuale utente

DAN DRYER

DAN DRYER 282 Manuale utente

Essity

Essity Tork 473208 Manuale utente

CBS

CBS SD300BU-88 Guida all'installazione

Sealey

Sealey MK77 Manuale utente

Fluid Management

Fluid Management Accutinter 1600 Manuale utente

Franke

Franke DVS SD99-010 Manuale utente

Graco

Graco Dispensit 1053-10C Guida alla risoluzione dei problemi

ITALTINTO

ITALTINTO i50 Manuale utente

Coca-Cola

Coca-Cola FREESTYLE 9000 Manuale utente

Graco

Graco ProMix 2KE Manuale di istruzioni

TECHCON SYSTEMS

TECHCON SYSTEMS TS1251 Manuale utente

Wayne

Wayne GLOBAL VISTA CNG Manuale utente

clarsen

clarsen H133 Manuale utente

PicoBrew

PicoBrew Zymatic Manuale utente

BOWMAN

BOWMAN BP-007 Manuale utente