Datamax I-Class Manuale utente
I
Maintenance Manual
Copyright Information:
CG Triumvirate is a trademark of Agfa Corporation.
CG Times based upon Times New Roman under license from the Monotype Corporation.
Firmware (Software) Agreement:
The enclosed Firmware (Software) resident in the Printer is owned by Licensor or its suppliers and is licensed for use
only on a single printer in the user’s Trade or Business. The User agrees not to, and not to authorize or permit
any other person or party to duplicate, or copy the Firmware or the information contained in the non-
volatile or programmable memory. The firmware (Software) is protected by applicable copyright laws and Licensor
retains all rights not expressly granted. In no event will Licensor or its suppliers be liable for any damages or loss,
including direct, incidental, economic, special, or consequential damages, arising out of the use or inability to use the
Firmware (Software).
WARNING
Lithium Battery: There is a danger of explosion or fire if the battery is incorrectly replaced.
Replace only with the same or equivalent type recommended by the manufacturer. Discard used
batteries according to the manufacturer’s instructions.
Information in this document is subject to change without notice and does not represent a commitment on the part of
Datamax-O’Neil. No part of this manual may be reproduced or transmitted in any form or by any means, for any
purpose other than the purchaser's personal use, without the expressed written permission of Datamax-O’Neil.
All rights reserved.
Part Number 88-2321-01 Rev. J
COPYRIGHT © 2010, DATAMAX-O’NEIL
i
Contents
1 Overview
2 Adjustments and Maintenance
3 Troubleshooting
4 Removal and Replacement
ii
i
1
Overview
1.0 Introduction........................................................................................ 1
1.1 About the Printer ................................................................................. 2
ii
Overview
1-1
1.0 Introduction
This manual, which primarily includes technical information relating to the electrical and mechanical
components, is intended for use by qualified service personnel in the maintenance and repair of I-
Class printers. For related information, refer to the following documents, available at
http://www.datamax-oneil.com/
• For operating information, reference the Operator’s Manual (part number 88-2241-01).
• For software information, reference the Class Series 2 Programmer’s Manual (part number 88-
2341-01).
Important Information:
The exclamation point inside an equilateral triangle is intended to alert the technician
to the presence of important operating, maintenance or servicing information. Always,
as with all electrical equipment, follow basic safety precautions to avoid personal injury
or printer damage.
Overview
1-2
1.1 About the Printer
The following drawing highlights the user-assessable components of the printer.
Access Cover
Printhead
Media Sensor
Ribbon Supply Hub
Ribbon Take-Up Hub
Front Panel
Printhead Assembly
Fill Block
Media Hub
Internal Rewinder
Printhead Latch
Leveling Cam
Media Idler
Ribbon Idler
Media Guide
Platen
i
2Adjustments and Maintenance
2.0 Introduction........................................................................................ 1
2.1 Media Sensor Calibration ...................................................................... 1
2.1.1 Quick Calibration ........................................................................ 1
2.1.2 Standard Calibration ................................................................... 2
2.1.3 Advanced Entry Calibration .......................................................... 4
2.2 Printhead Adjustments ......................................................................... 8
2.2.1 Leveling Cam Adjustment ............................................................8
2.2.2 Pressure Adjustment ................................................................... 9
2.2.3 Burn Line Adjustment................................................................ 10
2.2.4 Voltage Adjustment................................................................... 11
2.3 Ribbon Path Alignment ....................................................................... 12
2.4 Maintenance ..................................................................................... 15
2.4.1 Cleaning the Printhead .............................................................. 16
2.4.1.1 Cotton Swab Procedure................................................ 16
2.4.1.2 Cleaning Card Procedure .............................................. 17
2.4.1.3 Cleaning Film Procedure............................................... 18
2.4.2 Cleaning the Platen................................................................... 18
2.4.3 Cleaning the Media Path, Media Sensor, and Interior...................... 19
2.4.4 Cleaning the Ribbon Path........................................................... 20
2.4.5 Cleaning the Exterior Surfaces.................................................... 21
ii
2.5 Application Version Updates ................................................................ 21
2.5.1 Updating from READY................................................................ 22
2.5.2 Updating from Download Mode ................................................... 23
2.5.3 Resolving Update Issues ............................................................ 24
2.6 Boot Loader Program Updates ............................................................. 25
2.7 Resetting the Printer .......................................................................... 26
2.7.1 Soft Reset................................................................................ 26
2.7.2 Level One Reset ....................................................................... 26
2.7.3 Level Two Reset ....................................................................... 26
Altri manuali per I-Class
5
Indice
Altri manuali Datamax Etichettatrice
Datamax
Datamax E-Class Mark III Professional+ Manuale utente
Datamax
Datamax M-Class Mark II Manuale utente
Datamax
Datamax H-Class Manuale utente
Datamax
Datamax M-Class Mark II Manuale utente
Datamax
Datamax Prodigy Plus Manuale utente
Datamax
Datamax E-Class Mark III Manuale utente
Datamax
Datamax RL3 Manuale utente
Datamax
Datamax M-Class Mark II Manuale utente
Datamax
Datamax E-class E-3202 Manuale operativo e di manutenzione
Datamax
Datamax H-Class Manuale utente
Datamax
Datamax M-Class Mark II Manuale utente
Datamax
Datamax RL4e Manuale utente
Datamax
Datamax E Class E-4203 Manuale utente
Datamax
Datamax A-Class A-4212 Manuale utente
Datamax
Datamax I-Class Manuale utente
Datamax
Datamax I-Class Mark II Manuale utente
Datamax
Datamax I-Class Mark II Manuale utente
Datamax
Datamax E-4304 Manuale utente
Datamax
Datamax M-Class Mark II Manuale utente
Datamax
Datamax Perfomance Series Manuale utente
