Dometic RM3604 Manuale utente

Dometic

MANUAL

Refrigerators

This section addresses the most common system problems associated with Refrigerators supplied by The Dometic

Corporation. Our intent is to provide you with a guideline of checks to make, should you encounter one of the

following symptoms.

Operation 18C 37,38

Wiring B 25-30

Switch 13C,14C 35

Operation 18C 37,38

AC Volts 17C 36

Heating Element 10C 34

Thermostat 6C 33

Switch 13C,14C 35

Wiring B 25-30

Operation 18C 37,38

DC Volts 15C 36

Igniter 12C 34

Electrode 12C 34

High Voltage Cable 12C 35

Switch 13C,14C 35

Wiring B 25-30

Operation 18C 37,38

LP gas 1A 12

Filter 8C 33

Orifice 3A 14

Burner 2A 12

Shut-off Valve 2A 12

Safety Valve 2C 32

Thermocouple 3C 32

Thermocouple Adapter, 4C 32

(Top Mount Controls Only)

Operation 18C 37,38

Level 1J 89

Ambient Temperature 5J 90

Cooling Unit 6J 90

LP Gas 1A 12

Thermostat 5C 33

Filter 8C 33

Orifice 3A 14

Burner 2A 12

Flue Baffle 3A 12,13

Flue Tube 3A 14

AC Volts 17C 36

Heating Element 17C 37

Thermostat 9C 33

Switch 13C,14C 35

Wiring B 25-30

SYMPTOM CAUSE PAGE

REFER

SECTION

1. No operation.

2. No electric operation.

3. No gas operation — no spark.

4. No gas operation — sparks but no flame.

5. No cooling on any mode.

6. No cooling on gas — cools properly on other

mode(s). (RM2604 & RM2804 ONLY)

7. No cooling on electric — cools properly on other

mode(s). (RM2604 & RM2804 ONLY)

Dometic Manual Refrigerators

Dometic

MANUAL

Refrigerators

SYMPTOM CAUSE PAGE

REFER

SECTION

Operation 18C 37,38

Level 1J 89

Ventilation 2J 89

Ambient Temperature 5J 90

Air Leaks 3J 89

Thermostat 6C 33

Cooling Unit 6J 90

AC Volts 17C 36

Heating Elements 17C 37

Thermostat 6C 33

LP Gas Pressure 1A 12

Thermostat 6C 33

Filter 8C 33

Orifice 3A 14

Burner 2A 12

Flue Baffle 2A,3A 12,13

Flue Tube 3A 14

Thermostat 9C 33

Wiring B 25-30

Bypass Screw 1C 32

Thermostat 5C 33

LP Gas 1A 12

Safety Valve 2C 32

Thermocouple 3C 32

Thermocouple Adapter, 4C 32

(Top Mount Controls Only)

Flame Failure Meter 7C 33

(Top Mount Controls Only)

Flue Baffle 2A,3A 12,13

Flue Cap (Bottom Mount 3A 14

Controls Only)

Orifice 3A 14

Burner 2A 12

Food Storage 7J 90

Air Leaks 3J 89

Interior Liner Seal to Frame 9J 90

High Humidity 8J 90

DC Volts 15C 36

Heating Element 11C 34

Switch 13C,14C 35

Wiring B 25-30

Relay(RM2610/2810/2604/2804) 10C 34

DC Volts 15C 36

Heating Element 11C 34

Relay (RM2610/2810/2604/2804) 10C 34

Electrode 12C 34

LP Gas 1A 12

Bypass Screw 1C 32

Filter 8C 33

Ignitor 12C 34

8. Insufficient cooling on all modes.

9. Insufficient cooling on electric — cools prop-

erly on other mode(s).

10. Insufficient cooling on gas.

Cools properly on other mode(s).

11. Freezes on electric – cools properly on other

mode(s). (RM2604 & RM2804 ONLY)

12. Freezes on gas – cools properly on other

mode(s). (RM2604 & RM2804 ONLY)

13. Won't stay lit on gas.

14. Rapid formation of frost.

15. No DC operation – cools properly on AC and

gas.

16. Insufficient cooling on DC– cools properly on

AC and gas.

RM2510/RM2610/RM2810/RM2604/RM2804/

RM2552/RM2553

17. On gas mode, sparks while flame is lit.

Dometic

MANUAL

Refrigerators

DC Volts 4F 65

Fuse 5F 71

Wiring B 18,19,21

Upper PC Board 5F 67-70

Circuit Board 5F 70,71

Thermostat 5F 65

Upper Circuit Board 5F 67-70

Solenoid 5F 65,66

Wiring B 18,19,21

Circuit Board 5F 70,71

DC Volts 4F 65

Wiring B 18,19,21

Upper Circuit Board 5F 67-70

Circuit Board 5F 70,71

AC Volts 2F 65

Heating Element 3F 65

Upper Circuit Board 5F 67-70

Wiring B 18,19,21

Thermostat 5F 65

Circuit Board 5F 70,71

DC Volts 4F 65

Heating Element 3F 65

Upper Circuit Board 5F 67-70

Wiring B 18,19,21

Relay 5F 66

Thermostat 5F 65

Circuit Board 5F 70,71

LP Gas 1A 12

Manual Gas Valve 2A 12

Igniter 5F 66

High Voltage Cable 5F 66

Electrode 5F 66

Solenoid 5F 65,66

Upper Circuit Board 5F 67-70

Wiring B 18,19,21

Circuit Board 5F 70,71

Ventilation 2J 89

Leveling 1J 89

Ambient Temperature 5J 90

Air Leaks 9J 90

Thermostat 5F 65

Cooling Unit 6J 90

1. No operation – no panel lights.

2. No operation – has panel lights.

3. Operating OK – no panel lights.

4. No AC operation – operates on DC and gas.

5. No DC operation – operates on AC and gas.

6. No gas operation – operates on AC and DC.

7. Insufficient cooling on all modes.

SYMPTOM CAUSE PAGE

REFER

SECTION

AES MODELS: RM3604, RM3804, RM4804 and

RM7030 with Product No. 921890201, 921890301

Dometic

MANUAL

Refrigerators

8. Insufficient cooling on AC.

Cools properly on DC and gas.

9. Insufficient cooling on DC.

Cools properly on AC and gas.

10. Insufficient cooling on gas.

Cools properly on AC and DC.

11. Freezes on all modes.

12. Changes preset mode.

13. Flame failure light within 10 seconds.

14. Flame failure light after 3 minutes.

15. Interior Light ON when door is closed.

16. Rapid formation of frost.

AC Volts 2F 65

Heating Element 3F 65

DC Volts 4F 65

Heating Element 3F 65

Wiring B 18,19,21

LP gas 1A 12

Orifice 3A 14

Flue Baffle 2A,3A 12,13

Flue Tube 3A 14

Flue Cap 3A 14

Burner 2A 12

Thermostat 5F 65

DC Volts 4F 65

Wiring B 18,19,21

Circuit Board 5F 70,71

Igniter 5F 66

High Voltage Cable 5F 66

Electrode 5F 66

Wiring B 18,19,21

LP Gas 1A 12

Manual Gas Valve 2A 12

Solenoid 5F 65,66

Orifice 3A 14

Burner 2A,3A 12

Wiring B 18,19,21

Thermocouple 5F 66

Wiring B 18,19,21

Door Switch 5F 67

Door Position 4J 90

Food Storage 7J 90

Interior Liner Seal to Frame 9J 90

High Humidity 8J 90

Air Leaks 3J 89

SYMPTOM CAUSE

REFER

SECTION PAGE

Dometic

MANUAL

Refrigerators

AMES/AES Refrigerator Models including: S1521, S1531, S1621, S1631, S1821, S1831, RM2607,

RM2611, RM2807, RM2811, RM3607 and RM3807, the ROYALE/ELITE Refrigerator Models including

RM3662, RM3663, RM3862, RM3863, RM4872, RM4873, RM7732, RM7832, RM7130, and RM7030 with

Product No. 921890401.

1. No operation - no panel lights Operation 1D-5D 40-47

DC Volts 11D 48-49

Fuse 13D 53

Wiring B15,16,17,22,23,24

Upper Circuit Board 12D 51

Lower Circuit Board 13D 52,53

2.No operation - has panel lights Operation 1D-5D 40-47

DC Volts 11D 48,49

Thermistor 9D 48

Fuses 13D 53

Upper Circuit Board 12D 51

Wiring B15,16,17,22,23,24

Lower Circuit Board 13D 52,53

3.No AC operation - operates on other Operation 1D-5D 40-47

mode(s) AC Volts 6D 47

Fuse 13D 53

Heating Element 7D 47

Upper Circuit Board 12D 51

Wiring B15,16,17,22,23,24

Lower Circuit Board 13D 52,53

4.No DC operation - operates on other Operation 1D-5D 40-47

mode(s) DC Volts 11D 48,49

Fuse 13D 53

Heating Element 8D 47

Upper Circuit Board 12D 51

Wiring B15,16,17,22,23,24

Lower Circuit Board 13D 52,53

5.No Gas operation - operates on other Operation 1D-5D 40-47

mode(s) LP Gas1A 12

Manual Gas Valve 2A 12

Igniter 12D 50

High Voltage Cable 12D 50

Electrode 12D 50

Solenoid 12D 49

Upper Circuit Board 12D 51

Wiring B15,16,17,22,23,24

Lower Circuit Board 13D 52,53

6.Insufficient cooling on all modes. Ventilation 2J89

Leveling 1J 89

Ambient Temperature 5J90

Air Leaks 3J89

Thermistor 9D 48

Cooling Unit 6J 90

Thermistor Adjuster 10D 48

SYMPTOM CAUSE REFER TO SEC. PAGE

REFRIGERATOR SECTION

Dometic

MANUAL

Refrigerators

SYMPTOM CAUSE REFER TO PAGE

7. Insufficient cooling on AC - cools properly on AC Volts 6D 47

other mode(s). Heating Element 7D 47

Lower Circuit Board 13D 52,53

8. Insufficient cooling on DC - cools properly on DC Volts 11D 48,49

other mode(s). Heating Element 8D 47

Wiring B 15,16,17,22,23,24

Lower Circuit Board 13D 52,53

9. Insufficient cooling on Gas - cools properly on LP Gas 1A 12

other mode(s). Orifice 3A 14

Flue Baffle 2A,3A 12,13

Flue Tube 3A 14

Flue Cap (if equipped) 3A 14

Burner 2A 12

Lower Circuit Board 13D 52,53

10. Freezes. Thermistor 9D 48

Thermistor Adjuster 10D 48

Lower Circuit Board 13D 52,53

Upper Circuit Board 12D 51

11. Changes preset mode. Operation 1D-5D 40-47

DC Volts 11D 48,49

Wiring B 15,16,17,22,23,24

Upper Circuit Board 12D 51

Lower Circuit Board 13D 52,53

12. Check light on. DC Volts 11D 48,49

Wiring B 15,16,17,22,23,24

LP Gas 1A 12

Manual Gas Valve 2A 12

Solenoid 12D 49

Orifice 3A 14

Burner 2A 12

Lower Circuit Board 13D 52,53

Thermocouple 8E 60

13. Interior light on when door is closed. Wiring B 15,16,17,22,23,24

Door Switch 13D 53

Door Position 4J 90

14. Rapid formation of frost. Food Storage 7J 90

Interior Liner to Frame 9J 90

High Humidity 8J 90

Air Leaks 3J 89

15. Water on frame. Interior Liner to Frame 9J 90

High Humidity 8J 90

Air Leaks 3J 89

Climate Control Heater 13D 53

Dometic

MANUAL

Refrigerators

SYMPTOM CAUSE REFER TO PAGE

REFRIGERATOR SECTION

1. No operation - no panel lights Operation 1E 55,56

DC Volts 7E 57,58

Fuse 8E 62

Wiring B 20

Upper Circuit Board 8E 60

Lower Circuit Board 8E 60,61,62

2. No operation - has panel lights Operation 1E 55,56

DC Volts 7E 57,58

Thermistor 8E 58

Fuses 8E 62

Wiring B 20

Lower Circuit Board 8E 60,61,62

3. No AC operation - operates on gas mode Operation 1E 55,56

AC Volts 5E 57

Fuse 8E 62

Heating Element 6E 57

Wiring B 20

Lower Circuit Board 8E 60,61,62

4. No Gas operation - operates on AC mode Operation 1E 55,56

LP Gas 1A 12

Manual Gas Valve 2A 12

Igniter 8E 59

High Voltage Cable 8E 60

Electrode 8E 60

Solenoid 8E 59

Wiring B 20

Lower Circuit Board 8E 60,61,62

5. Insufficient cooling on all modes. Ventilation 2J 89

Leveling 1J 89

Ambient Temperature 5J 90

Air Leaks 3J 89

Thermistor 8E 58

Cooling Unit 6J 90

6. Insufficient cooling on AC - cools properly on AC Volts 5E 57

gas mode. Heating Element 6E 57

Lower Circuit Board 8E 60,61,62

RM2652, RM2852, RM2612 & RM2812 DOMETIC REFRIGERATORS

Dometic

MANUAL

Refrigerators

SYMPTOM CAUSE REFER TO PAGE

7. Insufficient cooling on Gas - cools properly on LP Gas 1A 12

AC mode. Orifice 3A 14

Flue Baffle 2A,3A 12,13

Flue Tube 3A 14

Burner 2A 12

Lower Circuit Board 8E 60,61,62

8. Freezes. Operation 1E 55,56

Thermistor 8E 58

Lower Circuit Board 8E 60,61,62

9. Check light on. DC Volts 7E 57,58

Wiring B 20

LP Gas 1A 12

Manual Gas Valve 2A 12

Solenoid 8E 59

Orifice 3A 14

Burner 2A 12

Thermocouple 8E 60

Lower Circuit Board 8E 60,61,62

10. Interior light on when door is closed. Wiring B 20

Door Switch 8E 62

Door Position 4J 90

11. Rapid formation of frost. Food Storage 7J 90

Interior Liner to Frame 9J 90

High Humidity 8J 90

Air Leaks 3J 89

12. Water on frame. Interior Liner to Frame 9J 90

High Humidity 8J 90

Air Leaks 3J 89

Climate Control Heater 8E 62

ICE MAKER SECTION/WITHOUT

COMPRESSOR

13. Ice Maker fails to start. Operation 2G 73

Arm in Up Position 1G 72

AC Voltage 4G 77

Water Valve 1G 73

Ice Maker Cycle 1G 73

Dometic

MANUAL

Refrigerators

14. Ice Maker won’t make ice. Blades Frozen in Ice 1G72

AC Voltage 4G77

Water Valve 1G73

Ice Maker Cycle 1G73

15. Keeps making ice and won’t shut off. Shut-off arm 1G72

16. Not making enough ice. Operation 2G73

Mold Thermostat 1G72

Cube Size 3G76

Ice Maker Cycle 1G73

17. Too much water is coming out. Water Fill Adjustment 3G76

Water Valve 1G73

18. Ejector blade frozen into ice cubes. Water Fill Adjustment 3G76

Water Valve 1G73

19. Unit is hooked-up no water comes in. Water 3G77

Water Valve 1G73

20. Ice maker is running but won’t make cubes. Water 3G77

Shut-Off Arm 1G72

Mold Thermostat 1G72

Mold Switch 1G73

21. Ice maker will not make ice. Ice Ejector 1G72

Mold Heater 1G72

Timing Motor 1G73

SYMPTOM CAUSE REFER TO SEC. PAGE

ICE MAKER SECTION

22.Ice Maker fails to start.

23.Fan Runs – No compressor.

Operation 1H 78

Arm in UP Position 2H 79

AC Volts 6H 84

Switch On/Off 2H 78

Wiring 6H 84

Starting Device 2H 78

Compressor 2H 78,79

Dometic

MANUAL

Refrigerators

SYMPTOM CAUSE REFER TO SEC. PAGE

Starting Device 2H 78

Refrigerant System 7H 85

Fan Motor 2H 79

Low Voltage 6H 84

High Amperage 6H 84

Compressor 2H 78,79

Breaker 6H 84

Ice Maker Assembly 2H 80

Blade Frozen in Ice 2H 79

Switch 2H 78

AC Voltage 6H 84

Water Valve 2H 80

Level 1J 89

Water fill adjustment 4H 83

Water Valve 2H 80

Air Flow 4H 83

Condenser Fins 2H 80

Shut-Off Arm 2H 79

Shut-Off Switch 2H 78

Operation 1H 78

Thermostat, Mold 2H 79

Cube Size 4H 83

Air Flow 4H 83

Condenser Fins 3H 80

Fan Motor 2H 79

Water Fill Adjustment 4H 83

Water Valve 2H 80

Water Fill Adjustment 4H 83

Water Valve 2H 80

Water Supply 8H 85

Water Valve 2H 80

Water Supply 8H 85

Shutoff Arm 2H 79

Thermostat, Mold 2H 79

Mold Switch 2H 80

24.Compressor runs but kicks ON and OFF.

25.Compressor runs – no fan.

26.Ice maker trips breaker.

27.Ice maker won't make ice.

28.Water in bucket.

29.Ice is too soft and wet.

30.Keeps making ice and won't shut off.

31.Not making enough ice.

32.Too much water is coming out.

33.Ejector blade frozen into ice cubes.

34.Unit is hooked-up – no water comes in.

35.Ice maker is running but won't make any cubes.

Altri manuali per RM3604

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Dometic Frigorifero

Dometic

Dometic REFRIGERATION 10-Series Manuale utente

Dometic

Dometic RUA5208X Manuale utente

Dometic

Dometic A30P1 Manuale utente

Dometic

Dometic RM2554 Manuale

Dometic

Dometic ABSORPTION RMD 8501 Manuale utente

Dometic

Dometic CoolMatic CRX 50 Manuale utente

Dometic

Dometic miniCool EA 3280 Manuale utente

Dometic

Dometic CFF12 Manuale utente

Dometic

Dometic HIPRO A30 Manuale utente

Dometic

Dometic REFRIGERATION 10-Series Manuale utente

Dometic

Dometic CCF-T Manuale utente

Dometic

Dometic CRD0050 Manuale utente

Dometic

Dometic RM 5310 Manuale utente

Dometic

Dometic Type C40/110 Manuale utente

Dometic

Dometic HIPRO CRUISE N30SCL Manuale utente

Dometic

Dometic Servel RGE400 Manuale utente

Dometic

Dometic CoolMatic CD30DC Manuale utente

Dometic

Dometic RGE 3000 Manuale utente

Dometic

Dometic RM 3762 Manuale utente

Dometic

Dometic Tundra TJ18 Manuale

Dometic

Dometic Frigo DC Manuale utente

Dometic

Dometic RM1350 Elite Manuale utente

Dometic

Dometic RM7030 Manuale utente

Dometic

Dometic RUC8408X Manuale utente

Manuali Frigorifero popolari di altre marche

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manuale utente

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manuale utente

Sharp

Sharp SJ-BA31IEXW2-EU Manuale utente

CORBERO

CORBERO CC2300MCW Manuale utente

KitchenAid

KitchenAid 2205264 Manuale utente

Stengel

Stengel KU 1101 A++ Manuale utente

NEFF

NEFF KI181 Series Manuale utente

Hoshizaki

Hoshizaki Reach-In Manuale utente

Amana

Amana ASD2524VES00 Manuale utente

BOMANN

BOMANN KGC 213 Manuale utente

Danby

Danby DAR044A1SLDD Istruzioni per il montaggio

Samsung

Samsung RF323TE Manuale utente

Beko

Beko CSA31022 Manuale utente

IKEA

IKEA FROSTIG C 185 E Manuale utente

Electrolux

Electrolux ER 6821 D Manuale utente

True

True TS-28 Manuale utente

Frigidaire

Frigidaire FSC23R5DW9 Manuale utente

Beko

Beko LSP4579W Manuale utente