GarrettCom Magnum 6K32 Manuale utente

www GarrettCom com

Corporate Headquarters

GarrettCom, Inc.

47823 Westinghouse Drive

Fremont, CA 94539

Phone (510) 438-9071

Fax (510) 438-9072

Website: http://www.GarrettCom.com

email [email protected]om

Magnum 6K32

Managed Switch

Hardware

Installation and User Guide

Magnum 6K32 Managed Switch Installation and User Guide (05/05)

www GarrettCom com

Magnum



6K32

Managed Switch

Hardware

Installation and User Guide

Part #: 84-00138 (Rev. A)

Trademarks

Ethernet is a trademark of Xerox Corporation

NEBS is a trademark of Telcordia Technologies

UL is a registered trademark of Underwriters Laboratories

GarrettCom, Magnum, Personal Switch, S-Ring, Link-Loss-Learn, Converter

Switch and Convenient Switch are trademarks and Personal Hub is a registered

trademark of GarrettCom, Inc.

GarrettCom, Inc. reserves the right to change specifications, performance

characteristics and/or model offerings without notice.

Important: The Magnum 6K32 Managed Switch contains no user

serviceable parts. Attempted service by unauthorized personnel shall

render all warranties null and void. If problems are experienced with

Magnum 6K32 Switch products, consult Section 6, Troubleshooting, of

this User Guide.

publication may be reproduced without prior written permission from

GarrettCom, Inc.

Printed in the United States of America.

Magnum 6K32 Managed Switch Installation and User Guide (05/05)

www GarrettCom com

Contacting GarrettCom, Inc

Please use the mailing address, phone and fax numbers and email address listed

below: GarrettCom, Inc.

213 Hammond Ave.

Fremont, CA 94539

Phone (510) 438-9071

Fax (510) 438-9072

Website: http://www.GarrettCom.com

email [email protected]

Federal Communications Commission

Radio Frequency Interference Statement

This equipment generates, uses and can radiate frequency energy and if

not installed and used properly, that is in strict accordance with the manufacturer's

instructions, may cause interference to radio communication. It has been tested

and found to comply with the limits for a Class A computing device in accordance

with the specifications in Subpart J of Part 15 of FCC rules, which are designed to

provide reasonable protection against such interference when operated in a

commercial environment. Operation of this equipment in a residential area is

likely to cause interference, in which case the user at his own expense will be

required to take whatever measures may be required to correct the interference.

Canadian Emission

This Class A digital apparatus meets all requirements of the Canadian

Interference-Causing Equipment Regulations.

Cet appareil respecte toutes les exigences du R

glement sur le mat

riel du

Canada. Cet appareil est Classe A.

TABLE OF CONTENTS.......................................................................... Page

1.0

SPECIFICATIONS................................................................................1

Magnum 6K32 Managed Switch Installation and User Guide (05/05)

iii

www GarrettCom com

1.1

Technical Specifications.......................................................................1

1.2

Ordering Information ...........................................................................4

2.0

INTRODUCTION..................................................................................6

2.1

Inspecting the Package and Product.....................................................6

2.2

Product Description - Magnum 6K32 Managed Switch ......................7

2.2.1

Magnum 6K32 and 6K32R chassis..............................................8

2.2.2 Eight-port SFF fiber modules 100Mb fiber........................................9

2.2.3

Eight-Port Copper Module, 6K8-RJ45.......................................10

2.2.4

Six-Port “4 + 2” Combo Modules, ............................................10

2.2.5

Four-Port 10 Mb mm Fiber ST Modules.................................11

2.2.6

Gigabit (1000Mbps) port modulesError! Bookmark not defined.

2.2.7

Packet Prioritization, 802.1p QOS .............................................12

2.2.8

Frame Buffering and Flow Control............................................13

2.2.9

Managed Network Software (MNS-6K) for Magnum 6K32 .....14

2.3

Features and Benefits .........................................................................15

2.4

Applications .......................................................................................16

3.0

INSTALLATION................................................................................20

3.1

Locating Magnum 6K32 Switches.....................................................20

3.2

Connecting Ethernet Media................................................................20

3.2.1

Connecting Fiber Optic ST-type, “twist-lock”..........................21

3.2.2

Connecting Fiber Optic SC-type, "Snap-In" ..............................21

3.2.3

Connecting Single-Mode Fiber Optic ........................................22

3.2.4

Connecting Twisted Pair ............................................................22

3.2.5

Connecting Twisted Pair ............................................................22

3.3

Table-Top or Shelf Mounting.............................................................23

3.3.1 Rack-mounting regular Magnum 6K32s.....................................23

3.3.2 Rack-mounting, Reverse version of the Magnum 6K32s .................24

3.4

Powering the Magnum 6K32 Managed Switch..................................25

3.4.1 Alarm Contacts for monitoring internal power..............................25

3.5

6K32 Port Module (6KPM) Installation.............................................26

3.5.1 Preparation for Installing and Removing 6KPMs............................26

3.5.2

Installing 6KPM Cards in the Magnum 6K32............................29

3.5.3

Removing 6KPM Cards .............................................................31

3.6

Connecting the Console Terminal to Magnum 6K32.........................33

3.6.1

RS-232 (DB-9) Console Com port.............................................33

4.0

OPERATION........................................................................................34

4.1

Switching Functionality .....................................................................34

4.2

Status LEDs........................................................................................35

4.3

Up-link Cross-over Switch on RJ-45 port modules ...........................35

4.4

Auto-cross (MDIX),

Auto-negotiation, for RJ-45 ports..............35

4.5

Flow-control, IEEE 802.3x standard..................................................37

4.6

Power Budget Calculations for Magnum 6K32 PM’s........................38

5.0

MAGNUM 6K32 MANAGED SWITCH PORT MODULES..........39

Magnum 6K32 Managed Switch Installation and User Guide (05/05)

www GarrettCom com

5.1

Inspecting the Package and Product...................................................39

5.2

6KPM Module Description................................................................40

5.2.1

6KP6-RJMST “twist lock” Combo Module...............................40

5.2.1a

6KP6-RJ10ST, “twist lock” Combo Module .............................41

5.2.1b

6KP4-F10ST, “twist lock” Module...........................................41

5.2.1c

6KP4-FLSTFX, “twist lock” Module........................................42

5.2.2. 6KP6-RJMSC “snap-in” Fiber connector .......................................42

5.2.3

6KP6-RJSSC “snap-in” connector ............................................43

5.2.4

6KP6-RJSSCL single-mode “snap-in” connector.....................43

5.2.4a

6KP6-RJ10ST FL-ST-type, “twist-lock” connector...................44

5.2.5 6KP8-MTRJ, MTRJ Small-Form-factor.........................................45

5.2.5a 6KP6-MT10ST, Multi-mode ST-Fiber port..................................45

5.2.6

6KP8-45MT, MTRJ Small-Form-Factor....................................46

5.2.7

6KP8-MLC, Small Form Factor.................................................46

5.2.8

6KP8-45LC, Combo factor and RJ-45 Connector .....................47

5.2.9

6KP8-RJ45 (Twisted Pair), 10/100Mb 8-Port...........................47

5.2.10

6KP8-45-2MT, multi-mode FX , MTRJ Small-Form-Factor.....48

5.2.10a

6KP8-45-2LC, LC Small-Form-Factor......................................48

5.2.11

GBIC-SXSC Gigabit fiber(1000Mb), mm SC Connector..........49

5.2.11a

GBIC-LXSC Gigabit fiber (1000Mb), mm SC Connector........50

5.2.12

6KM-BLNK ...............................................................................50

6.0

TROUBLESHOOTING.......................................................................50

6.1

Before Calling for Assistance.............................................................51

6.2

When Calling for Assistance..............................................................51

6.3

Return Material Authorization (RMA) Procedure..............................52

6.4

Shipping and Packaging Information.................................................53

APPENDIX A: WARRANTY INFORMATION .........................................53

APPENDIX B : INTERNAL DC POWER SUPPLY OPTIONS.................53

APPENDIX C: INTERNAL DC DUAL-SOURCE POWER OPTION......57

Revisions

Rev A 05/05 : Minor updates, Auto-Cross(MDIX)

Rev A 02/05 : Minor updates and tweak on LC connector diagram

Rev A 08/04 : This revision is the initial release of the 6K32 manual.

Magnum 6K32 Managed Switch Installation and User Guide (05/05)

www GarrettCom com

The Magnum Line

ETHERNET CONNECTIVITY PRODUCTS

"DESIGNED AND MANUFACTURED IN THE USA"

OVERVIEW

GarrettCom, Inc. offers the premium-quality Magnumline of Ethernet LAN

connectivity products with industry-standard functionality and built-in fiber

configurability. Magnum products are designed for use in demanding Carrier

Class, Industrial Grade and OEM applications where reliability is a primary

consideration.

6K Managed Switches, Gigabit, 100 and 10 Mbps, fiber and copper ports,

mix-and match. Features a family of modules for user configurability.

Magnum MNS software. Versions for 6K Switches and for mP62’s.

4K-Series Switches, 100 and 10 Mbps, copper ports with optional fiber port,

with auto-negotiating full switching performance.

Quad-Series Fiber Switches, 100 and 10Mbps, fiber and copper ports, mixed-

speed and mixed-media types, full switching performance.

“Outdoor” Ethernet Switches, for temperature uncontrolled locations

6 10/100 and 2 100Mb fiber ports, can be connected in strings and rings

Mixed-Media Fiber Hub, 16-port Stackable,10/100 auto-sensing

Dual Speed 8-port and 16-port Stackable, 10/100 auto-sensing

Stackable Hubs, SNMP Optional

10Mb series and 100Mb series, both w/ optional port modules

Personal Switches, 10/100Mb

8 port dual speed, Auto-negotiable with fiber option

Personal Hubs, 100Mb or 10/100Mb

8-port, with two switched ports (1 fiber built in)

Personal Hubs, 10Mb series

8-port + AUI, stackable to 5 high, + optional BNC of fiber port

8 or 9-port and 4 or 5-Port Personal Hubs, w/ man. up-link sw.

Converter Switches and Media Converters, 10Mb and 100Mb series

All media combinations, incl. fiber ST, SC, mm., single mode

The “X-line” of configurable MiXed Media products:

Stackable Concentrators, SNMP optional, 13-Ports

Repeaters, 2-Ports

Repeater Port Modules (RPMs),6 types for Ethernet media

Transceivers, 10Mb series Mini-Transceivers and Coax Models May, 05

Magnum 6K32 Managed Switch Installation and User Guide (02/05)

www GarrettCom com

1.0 SPECIFICATIONS

1.1 Technical Specifications

Performance

Filtering / Forwarding Rate:

Ethernet:14,880 pps

Fast Ethernet: 148,800 pps

Gigabit Ethernet: 1,488,000 pps

Switching Processing Type: Store and Forward with IEEE 802.3x full-

duplex flow -control, non-blocking

Data Rate: 10Mbps,100Mbps and 1000Mbps

Address Table Capacity: 4K node, self-learning with address aging

Packet buffer size : 240KB for 10/100 and 120KB for 1000Mb

Latency: 5 s + packet time (100 to 100Mbps)

15 s + packet time (10 to 10 Mbps, and 10 to 100Mbps)

Network Standards and Compliance

Ethernet V1.0/V2.0 IEEE 802.3: 10BASE-T,

IEEE 802.3u: 100Base-TX, 100BASE-FX

IEEE 802.3z: 1000BASE-X Ethernet(Auto-negotiation)

IEEE 802.3ab: 1000BASE-X Ethernet

IEEE 802.1p: Priority protocol

IEEE 802.1d: Spanning tree protocol

IEEE 802.1w: Rapid Spanning tree protocol

IEEE 802.1q: VLAN Tagging

IEEE 802.3x: Flow Control

IEEE 802.3ad: Link Aggregation (Trunking)

Maximum 10 Mbps Ethernet Segment Lengths

Unshielded twisted pair - 100 m (328 ft)

Shielded twisted pair - 150 m (492 ft)

10BASE-FL multi-mode fiber optic - 2 km (6,562 ft)

10BASE-FL single-mode fiber optic - 10 km (32,810 ft)

Maximum Standard Fast Ethernet Segment Lengths:

10BASE-T (CAT 3, 4, 5 UTP) - 100 m (328 ft)

100BASE-TX (CAT 5 UTP) - 100 m (328 ft)

Shielded twisted pair - 150 m (492 ft)

100BASE-FX, half-duplex, multi-mode - 412 m (1350 ft)

100BASE-FX, full-duplex, multi-mode - 2.0 km (6,562 ft)

100BASE-FX, half-duplex, single-mode - 412 m (1350 ft)

100BASE-FX, full-duplex, single-mode - 20.0 km (66K32 ft)

100BASE-FX, full-duplex, Long Reach - 40.0 km (122K ft)

Maximum Standard Gigabit Ethernet Segment Lengths:

1000BASE-T (CAT5E or higher is recommended) - 100 m

1000BASE-SX, full-duplex, multi-mode(62.5m cable) - 220m

1000BASE-SX, full-duplex, multi-mode(50m cable) - 550m

1000BASE-LX, full-duplex, single-mode(62.5m cable) -5Km

Magnum 6K32 Managed Switch Installation and User Guide (02/05)

www GarrettCom com

Fiber connector types supported:

ST-type (twist-lock)

SC-type (snap-in)

MTRJ-type Small Form Factor (SFF)

LC-type Small Form Factor (SFF)

GBIC modules

LEDs: Per Port

LK: Steady ON when media link is operational

ACT: ON with receiver port activity

FDX/HDX: ON = Full-Duplex Mode

OFF = Half-Duplex Mode

100/10: ON = 100Mbps speed

OFF = 10 Mbps

Operating Environment

Ambient Temperature: 25to 130F (-5to 55C)

Storage Temperature: -40to 185F (-40to 85C)

Ambient Relative Humidity: 5% to 95% (non-condensing)

Altitude: -200 to 13,000 ft. (-60 to 4000m)

Conformal Coating option: Request quote

Packaging

Enclosure: Rugged High strength metal. Suitable for stand-alone

or rack-mounting

Dimensions: 1.70in. H x 17.0in. W x 9.0in. D

4.32cm H x 43.2cm W x 22.9cm D

Cooling method: Fan cooled, @ 3@ 7 cfm ea.

Management Console connector

DB-9 for RS-232 “ null-modem “ cable (sometimes called an X-modem cable)

Power Supply (Internal)

AC Power Connector: IEC-type, male recessed at rear of chassis,

with adjacent manual ON-OFF switch (optional if no Alarms Cont.)

Input Voltage: 100 to 240 VAC (auto-ranging)

Input Frequency: 47 to 63 Hz (auto-ranging)

Power Consumption: 45 watts max (with fiber module)

30 watts for a fully-loaded copper only model

DC Power Supply (Options)

-48VDC Power Input Voltage : -36 to -70 VDC

24VDC Power Input Voltage : 20 to 40VDC

125VDC Power and 100VDC Input Voltage : 88 to 150VDC

Std. Terminal Block : “ -, GND, + ”

Power Consumption: same as for AC models, see above

For (Optional) DC internal power supplies at –48VDC, 24VDC and 125VDC,

including Dual Source options (

for continuity of operation when either of the DC

input sources are interrupted)

, see Appendices B and C.

Magnum 6K32 Managed Switch Installation and User Guide (02/05)

www GarrettCom com

Alarm Contact (Optional)

Alarm Contact option is offered as a special order. The alarms can be configured

through two normally closed Form-C contacts, one for loss of power and one

software alarm through user selectable software traps.

Manual switches for modular slot port module only

The copper daughter board has an internal switch for selecting MDI-MDIX

crossover on port # 1, located next to the port internally.

Note: Other port-specific user settings ( such as FDX or HDX,AUTO OFF,

copper 10/100 speed) can be configured using software commands.

Agency Approvals

UL listed (UL1950), cUL, CE, Emissions meet FCC Part 15 Class A

NEBS L3 and ETSI Compliant for Carrier Central Offices

IEEE P1613 Environmental Standard for Electric Power Substations.

IEC61850 EMC and Operating Conditions Class C for Power Substations

Warranty: Three years, return to factory Made in USA

For a Configuration Guide, see the GarrettCom web site at

http://www.garrettcom.com/techsupport/insertion_guides/6k32cg.pdf

[email protected]

for additional details.

Magnum 6K32 Managed Switch Installation and User Guide (02/05)

www GarrettCom com

1.2 Ordering Information

Magnum Managed Switch

MODEL DESCRIPTION

Magnum 6K32 Magnum 6K32 Managed Switch(32 total ports max.) base unit provides

24 10/100 RJ-45 ports and one optional port module slot, which may be configured with a

selection of 10/100/1000Mb fiber and copper connector types, 8 ports max., Wire speed

filtering and forwarding across all ports, 802.3x flow control, 802.1p priority packet

processing, self-learning 4K-node address table, large 240KB packet buffers for 10/100

and 120KB for 1000Mb. Plug-and-play switching services, front-mounted LEDs, internal

auto-ranging AC power supply, 19" rack-mounting brackets. For licensed managed

networks software, see MNS-6K datasheets.

Magnum 6K32R: “Reverse” model, same as Model 6K32 except the user ports and

the power input connectors are in the rear. Two sets of LEDs (both rear and front) provide

duplicate status data for viewing from either side.

Magnum 6K32-48VDC: Same as 6K32 except the power input is –48VDC

Magnum 6K32R-48VDC: Same as 6K32R except the power input is –48VDC

Magnum 6K32-24VDC: Same as 6K32 except the power input is 24VDC

Magnum 6K32R-24VDC: Same as 6K32R except the power input is 24VDC

Magnum 6K32-125VDC: Same as 6K32 except the power input is 125VDC

Magnum 6K32R-125VDC: Same as 6K32R except the power input is 125VDC

Configuration Options:

Each Magnum 6K32 and 6K32R base unit has one port module slot to be

configured with one of the port modules listed below:

Magnum 6K32 Port Modules

6KP8-RJ45 TP Module, w/eight 10/100Mbps auto-negotiating RJ-45 ports

6KP4-F10ST “2+2” 10Mb Fiber module, w/ four 10Mb 2km FL ST connectors

6KP4-FXSC “2+2” 100Mb Fiber module, w/ four 100Mb 2km FX SC connectors

6KP4-FXST “2+2” ST Fiber module, w/ s, four 100Mb 2km FX ST connectors

6KP4-FLSTFX “2+2” ST Fiber module, w/ two 100Mb and two 10Mb ports, 2km

6KP6-RJMST “4+2” module, w/four RJ-45 ports and two 2km mm FX SC’s

6KP6-RJMSC “4+2” module, w/four RJ-45 ports and two 2km mm FX ST‘s

6KP6-RJSSC “4+2” module, w/four RJ-45 ports and two 20km Sgl.m FX SC’s

6KP6-RJSSCL “4+2” module, w/four RJ-45 ports and two 40km Sgl.m FX SC’s

6KP8-MTRJ SFF Fiber module, w/eight 100Mb mm FX MT-RJ connectors

6KP8-MLC SFF Fiber module, w/eight 100Mbps mm FX LC connectors

6KP8-SLC SFF Fiber module, w/eight 100Mbps sgl-m FX LC connectors

6KP8-45MT “4+4” module, w/four RJ-45 ports and four 2km mm FX MT-RJ’s

6KP8-45LC “4+4” module, w/four RJ-45 ports and four 2km mm LC connectors

6KP6-MT10ST “4+2” module, w/four MTRJ ports and two 10Mb 2km FL ST’s

6KP6-RJ10ST “4+2” module, w/four RJ-45 ports and two 10Mb 2km FL ST ‘s

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali GarrettCom Interruttore

GarrettCom

GarrettCom Magnum DS80 Manuale utente

GarrettCom

GarrettCom Magnum CS14 Series Manuale utente

GarrettCom

GarrettCom Magnum CSG14 Manuale utente

GarrettCom

GarrettCom magnum 6kl Manuale utente

GarrettCom

GarrettCom PS14H-48VDC Manuale utente

GarrettCom

GarrettCom Magnum 6KQE Manuale utente

GarrettCom

GarrettCom Magnum 6K16V Manuale utente

GarrettCom

GarrettCom Magnum 14E Manuale utente

GarrettCom

GarrettCom Magnum 6K32T Istruzioni per l’uso

GarrettCom

GarrettCom Magnum 4K220 Manuale utente

GarrettCom

GarrettCom 500-Series Manuale utente

GarrettCom

GarrettCom Magnum 1016 Manuale utente

GarrettCom

GarrettCom Magnum 10KG Manuale utente

GarrettCom

GarrettCom DS80C Manuale utente

GarrettCom

GarrettCom Magnum 4K24F Manuale utente

GarrettCom

GarrettCom MAGNUM H80B Manuale utente

GarrettCom

GarrettCom Magnum 6K16-Series Manuale utente

GarrettCom

GarrettCom Magnum 6K8 Manuale utente

GarrettCom

GarrettCom Magnum 4K16 Manuale utente

GarrettCom

GarrettCom 4K-Series Manuale utente

GarrettCom

GarrettCom Magnum 6K8-Series Manuale utente

GarrettCom

GarrettCom Magnum 6K25e Manuale utente

GarrettCom

GarrettCom Magnum CSG14 Manuale utente

GarrettCom

GarrettCom Magnum ITS Blade Manuale utente

Manuali Interruttore popolari di altre marche

URC

URC Total Control MFS-8 Manuale utente

Azbil

Azbil HPQ-D11 Manuale utente

Sony

Sony DFS-900M Manuale utente

SICK

SICK i17S Manuale utente

F&F

F&F SZR-277 Manuale utente

Shure

Shure UAMS/BK Manuale utente

Dräger

Dräger X-zone Switch Off Manuale utente

Asco

Asco Joucomatic 349 Series Manuale utente

BT Mini Hub Manuale utente

D-Link

D-Link DES-1226G Manuale utente

Johnson Controls

Johnson Controls FS80-C Manuale utente

Alcatel-Lucent

Alcatel-Lucent 7450 ESS-12 Manuale utente

MicroNet

MicroNet SP1200A Manuale utente

Ruijie

Ruijie RG-PF2920 Series Manuale di installazione e funzionamento

Altinex

Altinex DA1914SX Manuale utente

MiLAN

MiLAN MIL-SM2401M Manuale utente

RJM

RJM MASTERMIND PBC/6X Manuale utente

Atlas

Atlas MMK-KVM8 Manuale utente