Konica Minolta Magicolor 5550 Istruzioni operative e di manutenzione
MATERIAL SAFETY DATA SHEET Page:1/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
1. PRODUCT AND COMPANY IDENTIFICATION
Product Name: TONER (CYAN)
used for: magicolor5570series/5550series
Supplier Identification:
Konica Minolta Business Technologies, INC.
Marunouchi Center Building 1-6-1, Marunouchi, Chiyoda-Ku, Tokyo
100-0005 JAPAN
Telephone: +81-3-6250-2250 Facsimile: +81-3-3218-1379
Contact Point:
Chemical Products Development Center
Chemical Products Business Headquaters
No.2970 ishikawa-machi, hachioji-shi Tokyo 192-8505, Japan
Tel: +81-42-660-9093 Fax: +81-42-660-9094
2. COMPOSITION / INFORMATION ON INGREDIENTS
Substance [ ] Preparation [ X ]
Major Ingredients:
[Generic Name] [CAS No.] [%]
Styrene acrylic resin +++ 75-85
Wax +++ 10-20
Organic pigment 147-14-8 1-10
Amorphous silica 7631-86-9 1-10
Titanium oxide 13463-67-7 <1
+++: Supplier’s confidential information
Hazardous Ingredients:
None present
MATERIAL SAFETY DATA SHEET Page:2/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
3. HAZARDS IDENTIFICATION
Emergency Overview: Cyan powder (mean dia. is 5-10um by volume ).
Almost odorless
Classification: Not classified as dangerous. (1999/45/EC)
Most Important Hazards and Effects of the Products
Ingestion Effect: None currently known.
Inhalation Effect: None currently known. Minimal respiratory tract
irritation may occur as with exposure to large amount
of any non-toxic dust.
Eye Effect: None currently known.
Skin Effect: None currently known.
Chronic Effects: Prolonged inhalation of excessive dusts may cause lung
damage. Use of this product, as intended, does not
result in inhalation of excessive dust.
Environment Hazards: No data are available on the adverse effects of
this product on the environment.
Specific Hazards: Dust explosion(like most finely divided organic
powders)
4. FIRST-AID MEASURES
Ingestion: Wash out mouth with water. Drink one or two glasses of water.
If symptoms occur, get medical attention.
Inhalation: Move victim to fresh air immediately. If symptoms occur,
get medical attention.
Eye Contact: Immediately flush eyes with plenty of water for 15 minutes.
If symptoms occur, get medical attention.
Skin Contact: Wash with water and mild soap.
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media: CO2, water spray, foam and dry chemical
Extinguishing Media to Avoid: Full water jet
Fire and Explosion Hazards: If dispersed in air, like most finely
divided organic powders, may form an explosive mixture.
Protection of Firefighters: Use self-contained breathing apparatus(SCBA).
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: None
Environmental Precautions: None
Methods for Cleaning Up: Wear personal protective equipment
(See Section 8).Vacuum or sweep material and place in a bag and hold
for waste disposal. Use vacuum equipped with High Efficiency Particulate
Air(HEPA) filter. Vacuum should be electrically bonded and grounded
to dispel static electricity. To avoid dust generation, do not sweep
dry.
MATERIAL SAFETY DATA SHEET Page:3/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
7. HANDLING AND STORAGE
Handling
Technical Measures: None
Precautions: Do not breathe dust. Avoid contact with eyes.
Safe Handling Advice: Try not to disperse the particulates.
Storage
Technical Measures: None
Storage Conditions: Keep container closed. Store in a cool and dry place.
Keep out of reach of children.
Incompatible Products: None
Packaging Materials: Bottles or Cartridge designated by KonicaMinolta.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Measures
Ventilation: None required with intended use.
Control Parameters(As total dust)
OSHA-PEL(USA): 15mg/m3 ACGIH-TLV(USA): 10mg/m3
DFG-MAK(GER): 4mg/m3 Worksafe-TWA(Austl.): 10mg/m3
Personal Protective Equipment
Not required under normal conditions. For use other than in normal
operating procedures (such as in the event of large spill), goggles and
respirators may be required.
Hygiene Measures: Wash hands after handling.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State: Solid Color: Cyan
Form: Powder (mean dia. is 5-10um by volume)
Odor: Almost odorless
PH Not applicable
Boiling Point(°C): Not applicable
Melting Point(°C): Around 125C(275F) (Softening Point)
Flash Point(°C): Not applicable
Ignition Temperature(°C): No data available
Explosion Properties: No data available
Vapor Pressure: Not applicable
Specific Gravity: 1.2
Solubility: Insoluble in water.
Partition Coefficient, n-Octanol/Water: Not applicable
MATERIAL SAFETY DATA SHEET Page:4/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
10. STABILITY AND REACTIVITY
Stability: Stable except above 200C(392F).
Hazardous Reactions: Dust explosion, like most finely divided organic
powders.
Conditions to avoid: Electric discharge, throwing into fire.
Materials to Avoid: Oxidizing materials.
Hazardous Decomposition Products: CO, CO2, NOx and smoke.
Hazardous Polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION
Acute Toxicity:
Ingestion(oral), LD50(mg/kg): >2500 (Rat)
Dermal, LD50(mg/kg): No data available
Inhalation, LC50(mg/l): >5.08 (Rat)(This was the highest attainable
concentration.)
Eye irritation: Minimal irritant (Rabbit)
Skin irritation: Non irritant (Rabbit)
Skin sensitizer: Non sensitizer (Guinea pig)
(*= Based on data for other Konica Minolta Products with similar ingredients)
Local Effects: see Chronic Toxicity or Long term Toxicity
Chronic Toxicity or Long Term Toxicity:
Prolonged inhalation of excessive dust may cause lung damage. It is
attributed to “lung overloading”, a generic response to excessive
amounts of any dust retained in the lungs for a prolonged interval.
Use of this product, as intended, does not result in inhalation of
excessive dust.
In a study in rats by chronic inhalation exposure to a typical toner,
a mild to moderate degree of lung fibrosis was observed in 92% of rats
in the high concentration(16mg/m³) exposure group, and a minimal to
mild degree of fibrosis was noted in 22% of the animals in the
middle(4mg/m³) exposure group. But no pulmonary change was reported
in the lowest(1mg/m³) exposure group, the most relevant level to
potential human exposures.
Carcinogenicity
IARC Monographs: Not listed
NTP(USA): Not listed
OSHA Regulated(USA): Not listed
Mutagenicity: Negative (AMES test)
MATERIAL SAFETY DATA SHEET Page:5/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
12. ECOLOGICAL INFORMATION
No data are available on the adverse effects of this material on the
environment.
Ecotoxicity: No data available
Mobility: No data available
Persistenceanddegradability: No data available
Bioaccumulativepotential: No data available
13. DISPOSAL CONSIDERATION
When disposing of the waste or recovered material, consult federal, state
and/or local regulations for the proper disposal method.
14. TRANSPORT INFORMATION
Information on Code and Classifications According to International
Regulations
UN Classification: None
15. REGULATORY INFORMATION
US Information
Information on the label: Not required
TSCA(Toxic Substances Control Act):
All chemical substances in this product comply with all applicable
rules or order under TSCA.
California Proposition 65:
This product contains no chemical substances subject to California
Proposition 65.
EU Information
Information on the label (1999/45/EC and 67/548/EEC): Not required
Article14 (2.1) of Directive 1999/45/EC is not applicable to this
product.
16. OTHER INFORMATION
HMIS Rating: The National Paint and Coating Association(USA):
Health: 1 Flammability: 1 Reactivity: 0
Recommended Uses: Toner for Electrophotographic Equipment
Revision Information: Regular revision on revised date.
MATERIAL SAFETY DATA SHEET Page:6/6
MSDS No.: PRT-2185
Product Name: TONER (CYAN)
Prepared date:20-Jan-2006
Revised Date: 10-Aug-2006
Literature References:
ANSI Z400.1-1993
ISO 11014-1
Commission Directive 91/155/EEC
H.Muhle, B.Bellmann, O.Creutzenberg, C.Dasenbrock, H.Ernst, R.Kilpper,
J.C.MacKenzie, P.Morrow, U.Mohr, S.Takenaka, and R.Mermelstein(1991)
Pulmonary Response to Toner upon Chronic Inhalation Exposure in Rats.
Fundamental and Applied Toxicology 17, pp.280-299.
Restrictions:
The above information is believed to be accurate and represents the best
information currently available to Our Corporation. However, Our
Corporation makes no warranty with respect to such information, and Our
Corporation assumes no liability resulting from its use. Users should
make their own investigation to determine the suitability of the
information for their particular purposes.
Altri manuali per Magicolor 5550
4
Questo manuale è adatto per i seguenti modelli
2
Indice
Altri manuali Konica Minolta Accessori per stampanti
Konica Minolta
Konica Minolta WT-513 Manuale utente
Konica Minolta
Konica Minolta RU-513 Manuale utente
Konica Minolta
Konica Minolta PI-506 Manuale utente
Konica Minolta
Konica Minolta PI-505 Manuale utente
Konica Minolta
Konica Minolta PK-511 Manuale utente
Konica Minolta
Konica Minolta AU-201S Manuale utente
Konica Minolta
Konica Minolta JS-506 Manuale utente
Konica Minolta
Konica Minolta PC-410 Manuale utente
Konica Minolta
Konica Minolta IP-011 Come usare
Konica Minolta
Konica Minolta MAGICOLOR 4600 Series Manuale utente
Konica Minolta
Konica Minolta FS-532 Manuale utente
Konica Minolta
Konica Minolta LU-302 Manuale utente
Konica Minolta
Konica Minolta Image Controller IC-402 Manuale utente
Konica Minolta
Konica Minolta AD-509 Manuale utente
Konica Minolta
Konica Minolta Image Controller IC-205 Manuale utente
Konica Minolta
Konica Minolta Color Care IQ-501 Manuale utente
Konica Minolta
Konica Minolta bizhub 361 Manuale utente
Konica Minolta
Konica Minolta DK-510 Manuale utente
Konica Minolta
Konica Minolta EK-608 Manuale utente
Konica Minolta
Konica Minolta FS-505 Manuale utente
