KYE Systems Corp. Genius SP-i355 Manuale utente

ServiceGuide SP-i355

Version : 1.0 Page 1 of 15

SERVICE GUIDE

KYESYSTEMS CORP.

SP-i355

ServiceGuide SP-i355

Version : 1.0 Page 2 of 15

Version : 1.0

RevisionHistory

Version Date Change

1.0 7/5/2009

ServiceGuide SP-i355

Version : 1.0 Page 3 of 15

Table of Contents

Revision History …………………………………………………………………….2

Table of Contents ……………………………………………………………………3

Getting Started ………………………………………………………………………4

Conventions Used in this Guide ……………………………………….4

Safety Precautions ……………………………………………………..4

Chapter 1. How to Handle Defective Returns……………………………………..5

1.1 Overview …………………………………………………………..5

1.2 Problems …………………………………………………………...6

1.2.1 One or more channels no sound (Line in jack no

function) ………………………………………..…7

1.2.2 Power LED (indicator) no light……...………....…8

1.2.3 Volume , Tone no function……….…….………….8

1.2.4 Earphone no function…………………………….9

Chapter 2. Specifications ………………………………………………………….10

Chapter 3. Block Diagram ……………………………………………………….11

Chapter 4. Exploded View ……………………………………………………….12

Chapter 5. Part List ………………………………………………………………13

Chapter 6. Schematic Diagram …………………………………………………..14

Chapter 7. Important Notes ………………………………………………………15

7.1 Packing Requirement for Sending the PCB Assembly by Post …..15

7.2 Short of Spare Parts while Repairing a Speaker System …………15

ServiceGuide SP-i355

Version : 1.0 Page 4 of 15

Getting Started

Conventions Used in this Guide

Pay Special Attention : Instructions that are important to remember and

may prevent mistakes .

Caution : Information that, if not followed, may result in damage to the

product .

Safety Precautions

The following precautions should be observed in handling the speaker

Described in this guide :

Place the speakers on a flat, level and stable surface.

Do not place the speakers in environments subject to mist, smoke,

vibration, excessive dust, salty or greasy air, or other corrosive gases

and fumes.

Do not drop or jolt the speakers.

Do not allow anything to drop into the subwoofer case through its

ventilator, as it could result in fatal electric shock or fire .

Place the unit far enough from other equipments for good heat

dissipation .

Disconnect the AC power cord from the AC outlet before performing

any maintenance on the speakers .

Do not perform any maintenance with wet hand .

Prevent foreign substances, such as water, other liquids or chemicals ,

From entering the speakers while performing maintenance procedures

on the speakers .

ServiceGuide SP-i355

Version : 1.0 Page 5 of 15

Chapter 1. How to Handle Defective Returns

1.1 Overview

Verifying problems

Proceeding necessary tests

Receiving Defective speakers from

Customers

Analyzing possible malfunction

causes

Deciding & proceeding the

rectification methods

Replace necessary defective parts

Proceeding tests to

Verif

if the s

eaker is

functionin

normall

Ret

urn the speakers with proper

repackaging to customers

Function NG

Function OK

Function NG

ServiceGuide SP-i355

Version : 1.0 Page 6 of 15

1.2 Problems

Item Problem Description

1.2.1 One or more channels no sound (Line in jack no function)

1.2.2 PowerLED(indicator)nolight

1.2.3 Volume,Tonenofunction

1.2.4 Earphone no function

ServiceGuide SP-i355

Version : 1.0 Page 7 of 15

Attention

1.2.1 One or more channels no sound (Line in jack no function)

Problem

Solutions

Please follow the numbered sequence marked within parenthesis given in individual

Flow chat, in that this is the best-recommended sequence to rectify the problems.

One or more channels no sound

Broken or short circuit Defective U1,

U2 , U3 , VR1

Speaker cable

dis-connect , JACK1 or

JACK2 defective or

speaker damaged

Check solder points on

PCB

Check and Replace

defective IC , VR

Re-connect speaker

cable or replace

defective speaker(s)

Analyzer and

Identify the Causes

ServiceGuide SP-i355

Version : 1.0 Page 8 of 15

1.2.2 Power LED (indicator) no light

Problem

Solutions

1.2.3 Volume , Tone no function

Problem

Solutions

Power LED (indicator) no light

Power switch or LED

defective

Defective

D1~D2, D4~D7,

Ac cord of transformer

disconnected or defective

Re-solder or replace

defective component(s)

Analyzer and

Identify the Causes

Volume , Tone no function

Broken or short circuit Defective U1, VR1, SW2, SW3

Check solder points on PCB

Analyzer and

Identify the Causes

Check and Replace defective

components

Check the

ac power

ServiceGuide SP-i355

Version : 1.0 Page 9 of 15

1.2.4 Earphone no function

Problem

Solutions

Broken or short circuit Defective JACK2 , R27 , R28

Check solder points on PCB

Analyzer and

Identify the Causes

Check and Replace defective

components

Earphone no function

ServiceGuide SP-i355

Version : 1.0 Page 10 of 15

Chapter 2. Specifications

NO. Description Unit Specifications

1 Out Power at THD 10% W ≧5

2 Sensitivity V 550 ±50

3 Freq. Response (1KHz -3dB) Hz 30~20K ± 10%

4 Separation dB ≧40

5 S/N ratio dB ≧70

6 Hum & Noise (Vol.: max) mV ≦ 2

Indice

Altri manuali KYE Systems Corp. Altoparlanti

KYE Systems Corp.

KYE Systems Corp. Genius SP-N200 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1100X Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i175 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SW-i2.1 1100 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i200 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i170 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-F120 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i205U Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-S115 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-F350 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF 2.1 800 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-J330 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF2000X Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i202u Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SW-Flat2.1 700 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i220 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-S105 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-S200 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF800 PRO Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-E06S Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF2000A Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-i300 Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF360A Manuale utente

KYE Systems Corp.

KYE Systems Corp. Genius SP-N120 Manuale utente

Manuali Altoparlanti popolari di altre marche

argon audio

argon audio IE20 Manuale utente

Denon

Denon SC-N7 Manuale utente

Gemline

Gemline Ace 3952 Manuale utente

Focal

Focal ON WALL 300 Manuale di istruzioni

HEADRUSH

HEADRUSH Maximus HRSP 5024 Manuale utente

SoundLogic

SoundLogic BCCS-6/6395 Manuale utente

Peavey

Peavey DTH 218 Manuale utente

Avantree

Avantree Pluto Air Manuale utente

Morel

Morel Integra Series INTEGRA OVATION 4 Manuale utente

Oppo

Oppo SONICA Manuale utente

Bose

Bose SoundLink Wireless Music System Manuale utente

Rocksteady

Rocksteady Stadium Manuale utente

Bowers & Wilkins

Bowers & Wilkins 4 Manuale utente

Sonance

Sonance SONOS OUTDOOR Series Manuale utente

Electro-Voice

Electro-Voice EVID FM4.2 Manuale utente

Pioneer

Pioneer XW-HTD630 Manuale utente

Onn

Onn BWA16AA002 Manuale utente

HP GL313AA - USB Speakers PC Multimedia Manuale utente