Lippert Components Jack-It Manuale utente

Jack-It™

Aftermarket Manual

www.lippertcomponents.com (574) 537-8900 Rev: 02.17 - Jack-It™ Aftermarket Manual

Jack-It™

Aftermarket

Manual

Table Of Contents

Introduction � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 1

Safety Requirements � � � � � � � � � � � � � � � � � � � � � � � � � � � � 1

Resources Required � � � � � � � � � � � � � � � � � � � � � � � � � � � � 2

Installation Instructions � � � � � � � � � � � � � � � � � � � � � � � � � 2

Securing Bikes � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 4

Patent protected, trademarked, and produced by Let’s Go Aero, Inc.

Corporate Ofce: 4474 Barnes Road, Colorado Springs, CO 80917 USA.

Made in China.

US Patent Numbers: 8,899,456, D717,716, D717,717, D684,917, D722,289,

patents pending.

Introduction

The Jack-IT™ is a bicycle rack designed to attach to your RV.

Additional information about this product can be obtained from

www.lci1.com/support or by downloading the free myLCI app.

The app is available on iTunes® for iPhone® and iPad® and

also on Google Play™ for Android™ users.

iTunes, iPhone, and iPad are registered trademarks of Apple

Inc. Google Play and Android are trademarks of Google Inc.

Lippert Components, Inc. recommends that the following

inspections, troubleshooting, component replacement and

verications be completed only by certied RV technicians.

Safety Requirements

Failure to follow the instructions provided in this

manual may result in death, serious injury, vehicle

damage or voiding of the component warranty�

Moving parts can pinch, crush or cut� Keep clear and

use caution�

The use of this product while bicycles are loaded may

affect the turning radius on some vehicles� Check the

turning radius before travel�

Jack- It™

Aftermarket Manual

www.lippertcomponents.com (574) 537-8900 Rev: 02.17 - Jack-It™ Aftermarket Manual

Resources Required

9/16” Socket Wrench

3/4” Socket Wrench

Installation Instructions

1� Remove the tongue jack from the coupler. Position the

PowerTower™ (Fig�1G) on the coupler. Place the

tongue jack on the PowerTower (Fig�1G) and secure

both to the coupler using 3 nuts, bolts and washers each

(Fig�1H, 1I and 1J).

Note: If there is no tongue jack, attach the PowerTower

(Fig�1G) to the coupler on the front of the trailer using 3

nuts, bolts and washers each (Fig�1H, 1I and 1J).

2� Attach the stinger (Fig�1F) to the PowerTower

(Fig�1G) using the NoMotion™ pin and washers

(Fig� 1C, 1D and 1A). For safety, insert the cotter pin

(Fig�1B) through the hole at the end of the NoMotion pin

(Fig�1C) after tightening securely.

3� Attach the base (Fig�1E) to stinger (Fig�1F) using the

NoMotion pin and washers (Fig�1C, 1D and 1A). For

safety, insert the cotter pin (Fig�1B) through the hole at the

end of the NoMotion pin (Fig�1C) after tightening securely.

Fig�1

Jack- It™

Aftermarket Manual

www.lippertcomponents.com (574) 537-8900 Rev: 02.17 - Jack-It™ Aftermarket Manual

Note: Several hole positions are provided for

cradles (Fig�2A). Pads (Fig�2D) and

SwayStop™ pins (Fig�2F) slide along the

length of the wings (Fig�2G).

4� Slide one SwayStop pin (Fig�2F) onto each

wing (Fig�2G) from the bottom so that the

SwayStop locates between the snap pin

(Fig�2H) and the pad (Fig�2D).

Note: A 2nd and optional SwayStop pin is

provided to secure both wheels of the bike to

the rack, install at this time if desired.

Note: If not using the 2nd and optional

SwayStop pins then the SwayStop pins

(Fig�2F) should point in opposite directions.

5� Attach wings (Fig�2G) to base (Fig�2E)

using 2 snap pins (Fig�2H).

6� Install 6 rubber straps (Fig�2B): 1 onto

each cradle (Fig�2A) and 1 onto each

SwayStop pin (Fig�2F).

7� Attach 4 cradles (Fig�2A). Attach 2 to each

wing (Fig�2G), securing with cotter pins

(Fig�2C). Attach 1 on each wing facing the

tow vehicle and 1 on each wing facing the

trailer.

Note: Adjustment will be necessary depending

on the size and desired position of the

bicycles.

C D E

Fig�2

Jack- It™

Aftermarket Manual

www.lippertcomponents.com (574) 537-8900 Rev: 02.17 - Jack-It™ Aftermarket Manual

Manual information may be distributed as a complete

document only, unless Lippert Components provides explicit

consent to distribute individual parts.

All manual information is subject to change without notice.

Revised editions will be available for free download at www.

lippertcomponents.com. Manual information is considered

factual until made obsolete by a revised version.

Please recycle all obsolete materials and contact Lippert

Components with concerns or questions.

NotesSecuring Bikes

1� For 2 bicycles, the best technique is to position the bicycles

front to back/back to front with the chain ring to the outside.

2� Hang 1 bicycle on the tow vehicle side of the bicycle rack, so

the top of the wheels are each supported by a cradle.

3� Secure by tensioning each rubber strap over the top of each

tire and engaging a strap hole with the end of the cradle.

4� Use 1 SwayStop pin to secure at least 1 wheel below the

frame where the wheel crosses the wing using the same

technique with the stop pin rubber strap (Fig�3). A second

and optional SwayStop pin is provided to secure both wheels

of the bike to the rack if desired.

5� Repeat for a 2nd bicycle on the trailer side of the bicycle rack.

Fig�3

Always make sure all connections between the bicycle

rack and the trailer coupler are secure/tight/ready for

travel� Always make sure the bicycles are securely

attached to the bicycle rack before driving�

Indice

Altri manuali Lippert Components Accessori per automobili

Lippert Components

Lippert Components Solera Istruzioni per l'installazione

Lippert Components

Lippert Components Kwikee Manuale utente

Lippert Components

Lippert Components Solera Classic Istruzioni operative e di manutenzione

Lippert Components

Lippert Components OneControl Hotspot Manuale utente

Lippert Components

Lippert Components Solera Power Awning Manuale per l'uso e la cura

Lippert Components

Lippert Components SolidStep XF Manuale utente

Lippert Components

Lippert Components SURESHADE POWER BIMINI Manuale utente

Lippert Components

Lippert Components In-Wall Slide-Out Manuale utente

Lippert Components

Lippert Components Air Ride 155925 Istruzioni per l'installazione

Lippert Components

Lippert Components Innolight Sliding Istruzioni per l'installazione

Lippert Components

Lippert Components Solera Classic Istruzioni per l'installazione

Lippert Components

Lippert Components Solera Manuale utente

Lippert Components

Lippert Components X-Trek Manuale utente

Lippert Components

Lippert Components Alumi-Tread series Manuale utente

Lippert Components

Lippert Components Vela Manuale utente

Lippert Components

Lippert Components Solera Power Awning Regal Head Manuale per l'uso e la cura

Lippert Components

Lippert Components Jack-It Manuale utente

Lippert Components

Lippert Components Curt Rota-Flex Pin Box Manuale utente

Lippert Components

Lippert Components Solera Power Awning Manuale per l'uso e la cura

Lippert Components

Lippert Components Solera Slide Topper Manuale utente

Lippert Components

Lippert Components In-Wall Slide-Out Manuale utente

Lippert Components

Lippert Components Edge Manuale utente

Lippert Components

Lippert Components Sliding Swivel Seat Base Manuale utente

Lippert Components

Lippert Components ground control TT Istruzioni per l'installazione

Manuali Accessori per automobili popolari di altre marche

James Baroud

James Baroud Odyssey Manuale utente

Motorola

Motorola i50sx Manuale utente

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuale utente

Feniex

Feniex T3 Manuale utente

Renault

Renault 77 11 423 180 Manuale utente

Kia

Kia E8300-4D000 Manuale utente

Brink

Brink 756843 Manuale utente

Whispbar

Whispbar K085W Manuale utente

v.link

v.link CI-VL2-PC-HSD Manuale utente

Viking

Viking Stack-Rack Guida rapida alla configurazione

Aries

Aries 203015 Manuale utente

Choetech

Choetech AT0005 Manuale utente

ZZ2

ZZ2 ZZAIR-PRO Manuale utente

Holman

Holman 4A80L Manuale utente

Thule

Thule 2075 Manuale utente

Motorola

Motorola T325 Manuale utente

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guida all'installazione

DV8

DV8 FBJL-02 Manuale utente