Maxon GPS 44X1 GPS Manuale utente
www.frimax.mx
MANUAL DE USUARIO
Serie Deslizables
GPS
ÍNDICE
Pág. 2
Pág. 6
Pág. 11
Pág. 7
Pág. 8
Pág. 1
Pág. 5
Información general
Carga del camión
Recomendaciones
Desplazamiento
Pág. 4 Controles de mano
Aseguración de carga
Reparación de elementos de rodamiento
Pág. 10 Trasnsferencia de carga de un vehículo a otro
Capacidad
1
INFORMACIÓN GENERAL
1X55SPG/1X44SPGledoMkoobdnahs`rotarepO
Document no.: M – 01 - 03 Version: 10.03.2008
You have decided to purchase a top Slidelift. The Maxon Slidelift is very easy to use and to
maintain. It is equipped with maintenance and grease-free bearings, and does not require greasing
throughout its entire lifetime. The Maxon Slidelift is only to be used for lifting and lowering of loads,
which have to be placed on the platform in accordance with the loading diagram.
The Slidelift must only be operated, maintained and repaired by persons who have been
technically trained and who have especially been informed about the hazards that may occur
during operation. Otherwise, manufacturer's liability for resulting damages is void.
These operating instructions are valid for following lifts:
Daily verifications :
1. Function and completeness of all operating and security equipment
2. Legibility of all operating and information labels (replace if necessary)
3. Damages and completeness on bolts, bolt retainers, cracked or broken bolts and nuts
4. Damages and tightness of hoses, fittings and valves on hydraulic cylinders. Check all
hoses for leaks and tightness
5. Verify deformation of under ride device and energy absorber
6. Damages and function of platform warning lights
7. The function of the battery main switch (option) is to be checked
Recommended checks every month:
1. Check hydraulic fittings for tightness and tightening torque.
2. Check oil level.
If necessary correct with recommended oil.
3. Check wires and cables for damages.
Replace missing cable fasteners.
Correct if there are cutting and shearing risks.
4. Check hydraulic hoses for damages.
Replace missing fasteners.
Correct if there are cutting and shearing risks.
5. Check that al decals are in place and full readable.
Replace missing or damaged decals.
6. Check rubber seals at bearings.
Replace missing or damaged seals.
7. Check that all bearing pins are secured and without damage.
Model GPS 44X1 GPS 55X1
Capacity 4,400 lbs 5,500 lbs
2
Replace if necessary.
Recommended checks and maintenances every year:
1. Oil change.
Clean oil suction filter and air breather filter.
Fill up with recommended oil.
2. Hydraulic hoses.
Change every four years, or if damages appear.
3. Electric motors.
Check carbon brushes, and clean with compressed air.
4. Check battery voltage.
Measure acid density.
Clean cable connections at the battery.
5. Load test.
Function test with nominal load.
6. Check foot controls
If necessary renew the switch or the rubber.
7. Check mechanical components for cracks or deformation.
Any failure must be repaired immediately and any missing part is to be replaced at once!
The vehicle operator is responsible for repairs in due time of known damages
The operating instructions are to be carried in the vehicle at all times.
Annual verifications
The Slidelift is to be verified by an expert once a year after its first operation. The results of that
verification must be written down in the control book.
Battery capacity
When driving short distances, always choose higher battery capacity.
Reinforced alternators are always recommended
The operator is responsible for battery capacity and its loading condition
Lifting
capacity 4,400 lbs 5,500 lbs
Battery -
SizeGroup 31 to Battery
RECOMENDACIONES
3
RECOMENDACIONES
Switching on the "SlideLift"
A master power switch is located in the pump box, and must be in the "On" position prior to
operating lift. Green light will illuminate.
Description Operation of Controls
Control Box
Using the control box, both hands must be used to operate control box.
Foot Controls
The foot controls are connected sothat they only work when pushed in a specific order.
To lift and tiltup
Step 1 - activate foot control button for lowering
Step 2 – activate foot control button for lifting
To lower and tilt down
Step 1 -activate foot control button for lifting
Step 2 – activate foot control button for lowering
see page 5
4
CONTROLES DE MANO
Hand Controls
General information
Riding on the platform
As only one person at atime is allowed to ride on the platform, the operator must ensure to avoid
any endangering of other persons (especially children) while operating the Slidelift.
Description of the security devices
Hose bursting valves
If a hose, atube or afitting should burst, the lift will lower in a controlled manner, without
exceeding the maximum allowed speed, as long as one of the functions of the hand control box is
activated. If the control is not operated any more, the lift stops immediately.
Pressure relief valve
The lift is secured against the lifting of loads which are heavier than its capacity, by an overload
security valve, set at the factory. An adjustment of this valve is allowed only by an expert, equipped
with a pressure gauge and an appropriate test load.
Electrical fuses
Defective fuses must be replaced by ones of same value, as stated on the wiring diagram.
Roll-off securities
The platform must be fitted with cart stops when using carts. The function of cart stops can be
altered through dirt. The operator must keep them clean at all times.
Warning lights
Warning lights are flashing when switching the lift on. Security equipment should always be in
perfect condition and kept clean.
lifting
lowering
5
DESLIZAMIENTO
ATTENTION BY SLIDING!
Parallel to the slidefram
No contact between
slideframe and platform
Riding on the platform
When loading the platform,
please leave enough space to
ensure that the operator can
ride and operate the platform
safely. The handle (optional)
must be within reach at all
times during vertical platform
travel.
Contact
Slideframe
overloadet
6
ASEGURACIÓN DE CARGA
Securing the loads
Rolling and shifting loads must be secured on the platform.
On request, Maxon Slidelifts can be equipped with cart stops, securing rolling loads with the
maximum efficiency (wheels with maximum diameter 4”)
Security instructions when operating the Slidelift
Caution at loading docks
Caster diameter max. 4“ max.
Securing the loads
Secure the loads against tipping and
slipping!
7
CAPACIDAD
Capacity
In addition to the operating instructions, the Slidelift loading diagram is also shown on its
identification plate. The load's centre of gravity should be in the middle between the lift arms. The
greater the distance of the load from the end of the flatbed, the lower the loading capacity.
The maximum loading capacity specified in the loading diagram must not be exceeded. The
platform may not be used as a bridge plate.
8
CARGA DEL CAMIÓN
Loading from the truck or trailer onto the platform
It is not possible to protect the Slidelift against loads brought from the vehicle tothe platform, that
are heavier than its rated capacity, nor against loads which are brought onto the platform at the
wrong loading distance. An overload can lead to heavy damage (breaking) of the platform.
The operator is responsible for loading the Slidelift according to the loading diagram.
Center
Loadcenterdistance
Do not use Platform as a bridge plate
Use trailer or truck body still as load point
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali Maxon Sistema di sollevamento
Maxon
Maxon BMR-35 Manuale utente
Maxon
Maxon GPT-25 Manuale utente
Maxon
Maxon TE-250C Manuale utente
Maxon
Maxon MXT-25 Manuale utente
Maxon
Maxon GPC 22 X1 10 Series Manuale utente
Maxon
Maxon GPTLR Series Manuale utente
Maxon
Maxon TUK-A-WAY 72-150 LMV Manuale utente
Maxon
Maxon TE-20 Manuale utente
Maxon
Maxon DMD-22 Manuale utente
Maxon
Maxon TE-15 Manuale utente
Maxon
Maxon TUK-A-WAY 80-3LM Manuale utente
Maxon
Maxon GPC 22 X1 Manuale utente
Maxon
Maxon TE-15 Manuale utente
Maxon
Maxon BMR-CS Series Manuale utente
Maxon
Maxon GPC 17 X-1 Manuale utente
Maxon
Maxon RA-45 Manuale del proprietario
Maxon
Maxon DMD series Manuale utente
Maxon
Maxon GPTLR Series Manuale utente
Maxon
Maxon 80 Series Manuale utente
Maxon
Maxon ME2 Series Manuale utente
Manuali Sistema di sollevamento popolari di altre marche
Genie
Genie Z-60/34 Manuale utente
Screen Technics
Screen Technics INTERFIT Vertical Up Lift Manuale utente
Mortuary Lift
Mortuary Lift ULTIMATE 1000 Manuale utente
Custom Equipment
Custom Equipment Hy-Brid 3 Series Manuale di programmazione
Custom Equipment
Custom Equipment Hy-Brid Lifts 2 Series Manuale di programmazione
Hy-Brid Lifts
Hy-Brid Lifts HB-P3.6 Manuale di programmazione
