MIMAKI JV3 Series Manuale utente

1-2. Remove the two indicated screws and

remove the Head Cover Bracket.

1-4a. Loosen the two screws that secure the

Damper Holder Bracket, tilt up and remove.

1-5. Unplug the pair of FPC Cables from the

head you wish to replace and tuck cables

up out of the way. Using long-nose pliers as

shown, remove each of the two Dampers.

Be especially careful not to drip ink onto

FPC Cables or contacts on Head!

1-6.If replacing multiple Heads it is a good

idea to label the position of each Damper.

Newer models may already have a small

ID tag on each ink line. Take care not to

touch or damage the clear membrane on

back of Damper!

1-7. Tape ink lines and Dampers out of the

way. Lift off the plastic Damper Holder that

covers the head. Remove the hex screw

from front and rear of Head Adjusting Plate.

1-8. Wipe any ink from the damper projec-

tions. Grasp damper projection nearest to

you. Using tweezers or needle-nose pliers

to compress the spring, tip head forward

and lift to remove.

1-3. Use a coin to ensure that Head-Lock

Screws are tight then remove screws on

left and right ends of Head Lever Bracket.

Remove entire Head lever taking care not to

damage Head FPC Cables.

1. Removal of Damaged Print Head:

1-1. Ensure both power switches are off.

Move Carriage out over Platen by hand.

Remove indicated screws and remove Head

Cover.

1-4b. Left screw is accessed through this

opening in Head Bracket and Cutter Brack-

et.

Lift straight up

Important:

Water-based transportation liquid

(S-46), supplied in the head at the

time of shipment, reacts to solvent ink

and may cause clogging. Therefore,

it is necessary to wash the new head

before proceding with installation.

2-3. Insert hex screws in holes at front and

rear of Head Adjusting Plate.

2-4. Before installing new Head inspect the

area where Head will sit for any debris such

as dried ink. Clean with Solvent (SPC-0336)

if neccessary.

2-5. Grasping damper projection, place

Head in position. Install, but do not tighten

the front and rear hex screws.

2-2. Fill syringe with 6-8 cc of S-Head

Replacement Solution. Inject approx 3-4 cc

into each Damper Insertion Projection over

a period of about 30 seconds. Head can be

damaged if ﬂuid is injected too fast.

2. Installation of New Head:

2-1. Unpackage new head. Copy down the

new Head ID exactly as it appears on head.

1-9. Head and Adjusting Spring removed.

If head is covered by warranty, ﬂush, drain,

place rubber cap over nozzles and package

ready for return to Mimaki USA.

2-13. Perform a TEST DRAW to conﬁrm

that all nozzles are ﬁring correctly. Perform

additional Ink Fill Ups or Cleanings if nec-

cessary.

2-12. Perform an Ink Fill Up to ﬁll the new

Heads with ink (MAINTENANCE

 FILL

UP INK). As the printer is in Service Mode

you can choose just Pump 1 or Pump 2 if

desired.

2-8. Re-install the Dampers in their original

positions and ensure that they are prop-

erly seated. Re-install the Damper Holder

Bracket, the Head Cover Bracket and the

Height Adjustment Lever.

2.6. Grasp spring near onje end with needle-

nose pliers. Insert spring one end ﬁrst then

compress to complete installation. Lightly

tighten the front and rear hex screws.

2-7a. Thread Head FPC Cables back

through the Damper Holder. Cable HCN2

goes through the left slot and HCN1 through

the right. Blue side of cables face to the left.

2-7b. Connect the FPC cables, taking care

that they are seated correctly. A cable seat-

ed at and angle may short out, damaging

cable and head! Lower Damper Holder into

position.

2-11. Use the arrow keys to enter the new

Head ID. (#ADJUST HEAD ID). Ensure

that the correct Head is selected and all ID

values are entered correctly. Incorrect entry

will result in a error code.

2-10. Restore power to the printer and put

into Service Mode. (FUNCTION and RE-

MOTE keys are held as printer boots).

 



    

    

 

       



 





  





  



 







 







  



  

    

     

    

     





      

   

  

   

  



  

    

   



   

   



                   

                

                  

   

                  

      

              

                    

                 

                

         

        

                   

   

   

 

  



 

 

     









     

    

       

 

  

   



    

    







 

  

      

      

  





 

     

 

 

  

  



    

   

I 







   

 

  

 

    

    





 



 

  

    

   

   

           

                

                      

    

                 

   

                 

                  



           

    

 

 

 

















   

  

 







      

   

 



 

  

   













     













 

   

   

  













 

  

   

                               











           

                

                       

  

               

          

          

    

         

 

    

    



 

 

         

    

 

 

         

        

  

 

   

 

 

    

  



 

   





          

                

                      

    

                 

  

   

                 

 

 

 

 

 

  

   

      

       

Altri manuali per JV3 Series

Indice

Altri manuali MIMAKI Stampante

MIMAKI

MIMAKI tx300p Manuale utente

MIMAKI

MIMAKI JV150-130A Manuale di manutenzione

MIMAKI

MIMAKI JV300-130 A Manuale utente

MIMAKI

MIMAKI TextileJet Tx2-1600 Series Istruzioni operative

MIMAKI

MIMAKI JV33-260BS Manuale utente

MIMAKI

MIMAKI JV3-250 SP Manuale utente

MIMAKI

MIMAKI UJV500 Series Manuale utente

MIMAKI

MIMAKI JV4-180 Manuale utente

MIMAKI

MIMAKI CJV30-60 Manuale utente

MIMAKI

MIMAKI jv34 series Manuale di installazione e funzionamento

MIMAKI

MIMAKI TS3 Manuale di manutenzione

MIMAKI

MIMAKI Kebab MKII Manuale utente

MIMAKI

MIMAKI JV33 Series Manuale utente

MIMAKI

MIMAKI UJV100 Manuale di manutenzione

MIMAKI

MIMAKI SWJ-320 S2 Manuale utente

MIMAKI

MIMAKI JV5-320S Manuale utente

MIMAKI

MIMAKI JV5-130S Manuale utente

MIMAKI

MIMAKI UJF-3042HG Manuale utente

MIMAKI

MIMAKI TS500P-3200 Manuale utente

MIMAKI

MIMAKI UJV-160 Manuale utente

MIMAKI

MIMAKI JV5-160S Manuale utente

MIMAKI

MIMAKI CJV150 series Manuale di manutenzione

MIMAKI

MIMAKI ML Tiger-1800B MKII Manuale utente

MIMAKI

MIMAKI JV300-130 A Manuale utente

Manuali Stampante popolari di altre marche

Lexmark

Lexmark 1400 Series Manuale

Canon

Canon i70 Series Manuale utente

Evolis

Evolis Elypso Manuale utente

Kyocera

Kyocera FS-9530DN Manuale utente

Canon

Canon LASER SHOT LBP-1210 Manuale utente

Samsung

Samsung BIXOLON SRP-350plusF Manuale utente

Canon

Canon PIXMA PRO-1 Series Manuale utente

Canon

Canon PIXMA G3560 Guida all'installazione

Dell

Dell Color Laser Printer 2130cn Manuale utente

Tektronix

Tektronix Phaser 840 Manuale utente

Epson

Epson ET-7750 Istruzioni operative

Canon

Canon CLBR 460ps Manuale utente

Eltron

Eltron P210 Guide Manuale utente

Ricoh

Ricoh MD-P1 Manuale utente

Epson

Epson SC-F7100 series Manuale utente

Epson

Epson Stylus C40UX Manuale utente

Canon

Canon imagePASS-A2 Manuale utente

Canon

Canon S820D Manuale utente