Pentair Raychem PMKG-LE Manuale utente

1 / 2

PMKG-LE

Low-ProfiLe end SeaL Kit inStaLLation inStructionS

THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

DESCRIPTION

The PMKG-LE is a NEMA Type 4X rated end seal kit designed for

use with Raychem BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, and

KHP-CR parallel heating cables. It is designed to be placed on the

pipe under the insulation and cladding.

For additional information contact your Pentair Thermal

Management representative or call (800)545-6258.

TOOLS REQUIRED

• Screwdriver • Wirecutters

• Utilityknife

ADDITIONAL MATERIALS REQUIRED

• Onegrommet:(1)

PMK-GK-10 P/N 222724-000 (Package of ten grommets)

• Glassclothtape

– GT-66 Installation temperature above 40°F (4°C)

 –GS-54 Installationtemperatureabove–40°F(–40°C)

(1) Required for LBTV2 (see step 1)

This component is an electrical device that must be installed

correctly to ensure proper operation and to prevent shock or fire.

Read these important warnings and carefully follow all of the

installation instructions.

• Tominimizethedangeroffirefromsustainedelectricalarcing

if the heating cable is damaged or improperly installed, and to

comply with the requirements of Pentair Thermal Management,

agency certifications, and National Electrical Codes, ground-

fault equipment protection must be used. Arcing may not be

stopped by conventional circuit breakers.

• Componentapprovalsandperformancearebasedontheuseof

Pentair Thermal Management-specified parts only. Do not use

substitute parts or vinyl electrical tape.

• Theblackheatingcablecoreisconductiveandcanshort.It

must be properly insulated and kept dry.

• Damagedbuswirescanoverheatorshort.Donotbreakbuswire

strands when scoring the jacket or core.

• Keepcomponentsandheatingcableendsdrybeforeandduring

installation.

• Buswireswillshortiftheycontacteachother.Keepbuswires

separated.

• Useonlyfire-resistantinsulationmaterials,suchasfiberglass

wrap or flame-retardant foam.

WARNING:

KIT CONTENTS

Item Qty Description

A 1 Pressure plate

B 1 End seal body with stainless steel screws

C 1 Red grommet (not for use with LBTV2)

D 1 End seal label

APPROVALS

-W

Class I, Div. 2, Groups A, B, C, D

Class II, Div. 2, Groups F, G

Class III

KHP-CR heating cables only

Hazardous Locations

Nonhazardous Locations

BTV-CR, BTV-CT, QTVR-CT and LBTV2-CT heating cables only

2 / 2THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

WWW.THERMAL.PENTAIR.COM

NORTH AMERICA

Tel: +1.800.545.6258

Fax: +1.800.527.5703

Tel: +1.650.216.1526

Fax: +1.650.474.7711

thermal.info@pentair.com

EuROPE, MIddLE EAsT, AfRICA

Tel: +32.16.213.511

Fax: +32.16.213.603

thermal.info@pentair.com

AsIA PACIfIC

Tel: +86.21.2412.1688

Fax: +86.21.5426.2917

cn.thermal.info@pentair.com

LATIN AMERICA

Tel: +55.11.2588.1400

Fax: +55.11.2588.1410

thermal.info@pentair.com

Pentair, BTV, QTVR, LBTV2 and KHP are owned by Pentair or its global affiliates. All other trademarks are the property of their respective owners. Pentair

reserves the right to change specifications without prior notice.

BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, KHP-CR

Bus wire

Conductive core

Inner jacket

Braid

Outer

jacket

3/4 in

(20 mm)

• Slidepartsontoheatingcable.

• Removeexposedbraid.

• Secureendsealtopipeusingcorrect

tape(GT-66orGS-54).

• Applyinsulationandcladding.

• Installlabelonoutsideofcladding.

• Leavetheseinstructionswiththeend

user for future reference.

• Lightlyscoreouterjacket.

• Bendheatingcabletobreakjacket

at score, then peel off jacket.

• Pushheatingcable

completely into end

seal body.

• Seatgrommetand

tighten screws.

WARNING: Use of the

wrong grommet can

result in leaks, cracked

components, shock or

dielectric failure, and

will invalidate

approvals and

certifications

• Identifyheatingcabletype.

• Selectcorrectgrommetfromtablebelow.

Heating Cable Type Grommet

BTV, QTVR -CR or -CT RED

LBTV2 -CT K *

KHP -CR RED

*Orderseparately

Identify Heating Cable Type

Altri manuali Pentair Unità di controllo

Pentair

Pentair AURORA CBV-S5 Manuale utente

Pentair

Pentair SUDMO P740 Manuale utente

Pentair

Pentair Fleck 2510 ECONOMINDER Manuale utente

Pentair

Pentair FLECK 9000 SXT Guida utente

Pentair

Pentair Fleck 5800 LXT Manuale utente

Pentair

Pentair BAA A390-D.03 Select Manuale utente

Pentair

Pentair LINCOLN 84976 Manuale del proprietario

Pentair

Pentair JUNG PUMPEN BASICLOGO AD 00 E Manuale utente

Pentair

Pentair 2750 Manuale utente

Pentair

Pentair SIATA V132 SFE-EV VIRIDION Manuale utente

Pentair

Pentair FLECK 3900 NXT Guida utente

Pentair

Pentair AUTOTROL 368 Manuale utente

Pentair

Pentair AUTOTROL 363 Manuale utente

Pentair

Pentair Fleck 5800 LXT Guida utente

Pentair

Pentair SIATA V132 SFE-EV VIRIDION Manuale utente

Pentair

Pentair AUTOTROL MAGNUM 293 Guida utente

Pentair

Pentair AUTOTROL 742 Series Manuale utente

Pentair

Pentair FLECK 4600-SXT Guida utente

Pentair

Pentair SUDMO IntelliTop 2.0 Manuale utente

Pentair

Pentair AUTOTROL 368 Manuale utente

Pentair

Pentair JUNG PUMPEN BASICLOGO EXM Series Manuale utente

Pentair

Pentair Fleck 2510 ECONOMINDER Manuale utente

Pentair

Pentair TRACETEK TTDM-128 Manuale di servizio

Pentair

Pentair AUTOTROL Performa 263 Guida utente

Manuali Unità di controllo popolari di altre marche

Festo

Festo Compact Performance CP-FB6-E Manuale elenco delle parti

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuale utente

JS Automation

JS Automation MPC3034A Manuale utente

JAUDT

JAUDT SW GII 6406 Series Guida rapida

Spektrum

Spektrum Air Module System Manuale utente

BOC Edwards

BOC Edwards Q Series Manuale utente

KHADAS

KHADAS BT Magic Manuale utente

Etherma

Etherma eNEXHO-IL Manuale utente

PMFoundations

PMFoundations Attenuverter Manuale utente

GEA

GEA VARIVENT Manuale utente

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuale utente

Altronix

Altronix LINQ8PD Istruzioni per il montaggio

Eaton

Eaton Powerware Series Manuale utente

WAGO

WAGO 750-407/040-000 Manuale utente

Sony

Sony CCU-590 Manuale utente

Graco

Graco 25D614 Manuale utente

Task Force Tips

Task Force Tips YE-RF-900 Manuale di programmazione

Shini

Shini SPV-U Series Manuale utente