Eaton Powerware Series Manuale utente

Powerware Series

Eaton PowerPass Distribution Module

User's Guide

For use with Eaton 9130 UPS

(2500/3000 VA) Models

Class A EMC Statements

FCC Part 15

NOTE This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to

part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference

when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate

radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful

interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful

interference in which case the user will be required to correct the interference at his own expense.

ICES-003

This Class A Interference Causing Equipment meets all requirements of the Canadian Interference Causing

Equipment Regulations ICES‐003.

Cet appareil numérique de la classe A respecte toutes les exigences du Reglement sur le matériel brouilleur du

Canada.

EN 50091-2

Some configurations are classified under EN 50091-2 as “Class‐A UPS for Unrestricted Sales Distribution.” For

these configurations, the following applies:

WARNING This is a Class A‐UPS Product. In a domestic environment, this product may cause radio interference, in

which case, the user may be required to take additional measures.

Eaton, Powerware, and PowerPass are registered trademarks of Eaton Corporation or its subsidiaries and affiliates.

All other trademarks are property of their respective companies.

reproduced in any way without the express written approval of Eaton Corporation.

Requesting a Declaration of Conformity

Units that are labeled with a CE mark comply with the following harmonized standards and EU directives:

SHarmonized Standards: EN 50091-1-1 and EN 50091-2; IEC 60950 Third Edition

SEU Directives: 73/23/EEC, Council Directive on equipment designed for use within certain voltage limits

93/68/EEC, Amending Directive 73/23/EEC

89/336/EEC, Council Directive relating to electromagnetic compatibility

92/31/EEC, Amending Directive 89/336/EEC relating to EMC

The EC Declaration of Conformity is available upon request for products with a CE mark. For copies of the EC

Declaration of Conformity, contact:

Eaton Power Quality Oy

Koskelontie 13

FIN-02920 Espoo

Finland

Phone: +358-9-452 661

Fax: +358-9-452 665 68

Special Symbols

The following are examples of symbols used on the UPS or accessories to alert you to important

information:

RISK OF ELECTRIC SHOCK - Indicates that a risk of electric shock is present and the

associated warning should be observed.

CAUTION: REFER TO OPERATOR'S MANUAL - Refer to your operator's manual for

additional information, such as important operating and maintenance

instructions.

This symbol indicates that you should not discard the UPS or the UPS batteries

in the trash. This product contains sealed, lead‐acid batteries and must be

disposed of properly. For more information, contact your local recycling/reuse or

hazardous waste center.

This symbol indicates that you should not discard waste electrical or electronic

equipment (WEEE) in the trash. For proper disposal, contact your local

recycling/reuse or hazardous waste center.

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Table of Contents

1 Introduction 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safety Warnings 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2 Installation 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Inspecting the Equipment 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PDM Setup 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Rackmount Setup 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Plug-Receptacle Installation 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Low-Voltage PDM Installation 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

High-Voltage PDM Installation 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Plug-Receptacle PDM Rear Panels 17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Hardwired Installation 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Low-Voltage and High-Voltage PDM Installation 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Hardwired PDM Rear Panels 25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Load Segments 26. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

3 Operation 27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Using Maintenance Bypass 27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

4 Specifications 29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

TABLE OF CONTENTS

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Chapter 1 Introduction

The PowerPass®Distribution Module (PDM) is designed to operate with

a 2500/3000 VA Eaton 9130 uninterruptible power system (UPS) and

allows you to:

SReplace or upgrade the UPS without losing power to your equipment

(see “Using Maintenance Bypass” on page 27).

SProvide surge protection if the UPS is not present.

SProvide extra surge protection when the UPS is present.

Safety Warnings

IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

This manual contains important instructions that you should follow during installation and

maintenance of the UPS and batteries. Please read all instructions before operating the

equipment and save this manual for future reference.

DANGER

This UPS contains LETHAL VOLTAGES. All repairs and service should be performed by

AUTHORIZED SERVICE PERSONNEL ONLY. There are NO USER SERVICEABLE PARTS

inside the UPS.

WARNING

STo reduce the risk of fire or electric shock, install this UPS in a temperature and humidity

controlled, indoor environment, free of conductive contaminants. Ambient temperature

must not exceed 40°C (104°F). Do not operate near water or excessive humidity

(95% maximum).

SFor PDM models with hardwired outputs, overcurrent protection for the output AC

circuit(s) is to be provided by others.

SFor PDM models with hardwired outputs, suitably rated disconnect switches for the

output AC circuit(s) are to be provided by others.

INTRODUCTION

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Sikkerhedsanvisninger

VIGTIGE SIKKERHEDSANVISNINGER

GEM DISSE ANVISNINGER

Denne manual indeholder vigtige instruktioner, som skal følges under installation og

vedligeholdelse af UPS'en og batterierne. Læs venligst alle instruktioner inden betjening af

udstyret og gem denne manual mhp. fremtidige opslag.

FARE

Denne UPS indeholder LIVSFARLIG HØJSPÆNDING. Alle reparationer og vedligeholdelse bør

kun udføres af en AUTORISERET SERVICETEKNIKER. Ingen af UPS'ens indvendige dele kan

repareres af brugeren.

ADVARSEL!

SInstallér denne UPS i et temperatur- og fugtighedskontrolleret indendørsmiljø, frit for

ledende forureningsstoffer for at formindske risikoen for brand og elektrisk stød.

Rumtemperaturen må ikke overstige 40°C. UPS'en bør ikke betjenes nær vand eller høj

fugtighed (maksimalt 95%).

SFor PDM systemer med hårdledningsudgange, skal overstrømsbeskyttelse for

vekslestrømmens udgangskredsløb forsynes af andre.

SFor PDM systemer med hårdledningsudgange, skal egnede, nominelle afbryderkontakter

for vekslestrømmens udgangskredsløb forsynes af andre.

INTRODUCTION

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Belangrijke Veiligheidsinstructies

BELANGRIJKE VEILIGHEIDSINSTRUCTIES

BEWAAR DEZE INSTRUCTIES

Deze handleiding bevat belangrijke instructies die u dient te volgen tijdens de installatie en

het onderhoud van de UPS en de accu's. Lees alle instructies voordat u de apparatuur in

bedrijf neemt en bewaar deze handleiding als naslagwerk.

GEVAAR

Deze UPS bevat LEVENSGEVAARLIJKE ELEKTRISCHE SPANNING. Alle reparaties en

onderhoud dienen UITSLUITEND DOOR ERKEND SERVICEPERSONEEL te worden uitgevoerd.

Er bevinden zich GEEN ONDERDELEN in de UPS die DOOR DE GEBRUIKER kunnen worden

GEREPAREERD.

WAARSCHUWING

STeneinde de kans op brand of elektrische schok te verminderen dient deze UPS in een

gebouw met temperatuur‐ en vochtigheidregeling te worden geïnstalleerd, waar geen

geleidende verontreinigingen aanwezig zijn. De omgevingstemperatuur mag 40°C niet

overschrijden. Niet gebruiken in de buurt van water of bij zeer hoge vochtigheid

(max. 95%).

SVoor PDM systemen met vast‐bedrade uitgangen, moet de overstroombeveiliging voor

wisselstroom uitvoercircuit(s) door anderen worden geleverd.

SVoor PDM systemen met vast‐bedrade uitgangen, moeten de juiste hoofdschakelaars

voor wisselstroom uitvoercircuit(s) door anderen worden geleverd.

INTRODUCTION

Eaton®PowerPass®Distribution Module (2500/3000 VA) User's Guide S164201798 Rev 2

www.eaton.com/powerquality

Tarkeita Turvaohjeita

TÄRKEITÄ TURVAOHJEITA - SUOMI

SÄILYTÄ NÄMÄ OHJEET

Tämä käyttöohje sisältää tärkeitä ohjeita, joita on noudatettava UPS-virtalähteen ja akkujen

asennuksen ja huollon yhteydessä. Lue kaikki ohjeet ennen laitteiston käyttöä ja säilytä ohje

myöhempää tarvetta varten.

VAARA

Tämä UPS sisältää HENGENVAARALLISIA JÄNNITTEITÄ. Kaikki korjaukset ja huollot on

jätettävä VAIN VALTUUTETUN HUOLTOHENKILÖN TOIMEKSI. UPS ei sisällä MITÄÄN

KÄYTTÄJÄN HUOLLETTAVIA OSIA.

VAROITUS

SVähentääksesi tulipalon ja sähköiskun vaaraa asenna tämä UPS sisätiloihin,

joissa lämpötila ja kosteus on säädettävissä ja joissa ei ole virtaa johtavia

epäpuhtauksia. Ympäristön lämpötila ei saa ylittää 40 °C. Älä käytä lähellä vettä ja vältä

kosteita tiloja (95 % maksimi).

SPDM‐järjestelmissä kiintealla asennuksella: kuormana olevien laitteiden ylivirtasuojaus

ja erotuskytkimet tulee toteuttaa kuormapiireissa.

Consignes de sécurité

CONSIGNES DE SÉCURITÉ IMPORTANTES

CONSERVER CES INSTRUCTIONS

Ce manuel comporte des instructions importantes que vous êtes invité à suivre lors de toute

procédure d'installation et de maintenance des batteries et de l'onduleur. Veuillez consulter

entièrement ces instructions avant de faire fonctionner l'équipement et conserver ce manuel

afin de pouvoir vous y reporter ultérieurement.

DANGER!

Cet onduleur contient des TENSIONS MORTELLES. Toute opération d'entretien et de

réparation doit être EXCLUSIVEMENT CONFIÉE A UN PERSONNEL QUALIFIÉ AGRÉÉ.

AUCUNE PIÈCE RÉPARABLE PAR L'UTILISATEUR ne se trouve dans l'onduleur.

Altri manuali per Powerware Series

Indice

Altri manuali Eaton Unità di controllo

Eaton

Eaton XC-CPU101-FC128K-8DI-6DO Manuale

Eaton

Eaton Vickers DF3S4-16 Series Manuale utente

Eaton

Eaton ELC-EX08NNSN Manuale utente

Eaton

Eaton OPTCB RS-485 Manuale utente

Eaton

Eaton Crouse-hinds series Manuale utente

Eaton

Eaton NH00 Manuale utente

Eaton

Eaton NZM XMC Series Manuale utente

Eaton

Eaton PowerXL DX-NET-ETHERCAT-2 Manuale

Eaton

Eaton CEAG CG IV Manuale utente

Eaton

Eaton DXC-EXT-LOCSIM Manuale

Eaton

Eaton Vickers CM2 Series Manuale utente

Eaton

Eaton Char-Lynn 5 Series Manuale utente

Eaton

Eaton Cutler-Hammer IQMSSPM Manuale utente

Eaton

Eaton MMX-COM-PC Manuale

Eaton

Eaton 9395 SSBM Manuale utente

Eaton

Eaton ELC-PC12NNDR Manuale utente

Eaton

Eaton PKE-SWD-32 Manuale

Eaton

Eaton MN024002EN Manuale utente

Eaton

Eaton i-on30R Manuale utente

Eaton

Eaton 33 Manuale utente

Eaton

Eaton MFD-CP8 Series Manuale

Eaton

Eaton ELC-CODNETM Manuale utente

Eaton

Eaton CMA Manuale utente

Eaton

Eaton Vickers CG-03 Series Manuale utente

Manuali Unità di controllo popolari di altre marche

Festo

Festo Compact Performance CP-FB6-E Manuale elenco delle parti

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuale utente

JS Automation

JS Automation MPC3034A Manuale utente

JAUDT

JAUDT SW GII 6406 Series Guida rapida

Spektrum

Spektrum Air Module System Manuale utente

BOC Edwards

BOC Edwards Q Series Manuale utente

KHADAS

KHADAS BT Magic Manuale utente

Etherma

Etherma eNEXHO-IL Manuale utente

PMFoundations

PMFoundations Attenuverter Manuale utente

GEA

GEA VARIVENT Manuale utente

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuale utente

Altronix

Altronix LINQ8PD Istruzioni per il montaggio

WAGO

WAGO 750-407/040-000 Manuale utente

Sony

Sony CCU-590 Manuale utente

Graco

Graco 25D614 Manuale utente

Task Force Tips

Task Force Tips YE-RF-900 Manuale di programmazione

Shini

Shini SPV-U Series Manuale utente

Flyron

Flyron FN-BC04 Manuale utente