Rain Bird CPF Series Manuale utente

Rain+Birdt

CP/CPF Series Valve Installation

and Operation

BODY

INLET

FLOW CONTROL

(select models)

OUTLET

SOLENOID

BLEED

SCREW

Before Installation

 Install master valves, pressure regulators and back-

ow preventers as needed.

 A pressure regulator is required if water pressure

exceeds 150 PSI (recommended over 80 PSI).

 Inline valves require a separate backow preventer

in the main line. Check local building codes.

 Flush the system thoroughly until water runs clear.

 Shut o the main water supply.

Connect Valve to Pipes

A

Apply PTFE thread-seal tape to the male threads

on the adapters, screw into the valve and

hand-tighten (do not use PVC glue or pipe dope

on adapter threads).

B

Apply primer and then PVC cement to the ends

of the pipe and inside the adapters per manu-

facturer’s instructions.

C

Ensure the valve arrows face in the direction of

water ow, and push valve onto inlet and outlet

pipes until secure. Follow PVC cement instruc-

tions for cure time.

1 2

TO LANDSCAPE WATER SOURCE

Connect Valve Wires

 NOTE: Use watertight connectors and direct

burial wire for all connections.

A

Connect one solenoid wire to a common wire

(usually white). All valves can share the same

common wire.

B

Connect the second solenoid wire to a power

wire (usually colored).

Valve Operation

Manual Operation:

A

Manual on: Turn the solenoid counter-clockwise

1/4 turn. Do not unscrew completely. To close,

hand tighten clockwise.

B

Flow control (select models only): Turn clock-

wise to restrict ow. Turn counter-clockwise to

open ow.

C

Flush valve to clear debris: Turn the bleed screw

counter-clockwise ONLY 1 turn. Flush one min-

ute and turn clockwise to close.

First Use:

D

Open the main water supply and ush one min-

ute with bleed screw to clear debris.

E

Test wiring by using the Manual Water feature

on the irrigation controller.

F

Adjust the ow control to reduce over-spray.

(select models).

Operating Ranges

075-CP / 075-CPF 100-CP / 100-CPF

Flow20.2 - 22 GPM 0.2 - 40 GPM

Pressure 15 - 150 PSI 15 - 150 PSI

 NOTE: For ows below 3 GPM (0.75 m3/h), or

any drip application, use a 200 mesh lter up-

stream and a pressure regulating lter down-

stream from the valve. 40 psi for 1”and 30 psi for

3/4” drip lines.

Troubleshooting

Symptom Solution

Valve

Won’t Turn

On when

Solenoid is

Turned

Make sure ow control is open (select

models)

Check that main water supply is on

Make sure piping is connected properly and

not blocked

Valve Won’t

Turn On at

the Timer

Verify timer settings are correct

Check and repair wiring and connections as

needed

Check and replace valve solenoid as need-

Verify timer power output

Valve Won’t

Shut-o

Verify timer settings are correct

Hand tighten solenoid and bleed screw if

needed

Valve Won’t

Turn On at

the Valve

Incorrect timer settings

Check wiring

Check solenoid

Timer not supplying power to the valve

Make sure the Flow Control stem is not

turned all the way closed

Leaks at

sprinkler

heads

Clear debris by opening the bleed screw

and ushing 1 minute

Remove and clean the diaphragm. Replace

if needed.

Leaks around

the valve

Check pipe ttings connection and glue,

repair or replace as needed

Hand tighten solenoid and bleed screw if

needed

If vacuum breaker is leaking (anti-siphon

models) remove cap, gasket, and internal

piston gasket to clean and reassemble

Turn o main water supply, relieve pressure

on the valve by opening the bleed screw

and tighten the jar top bonnet

 NOTE: During winter, shutdown and drain the

system to protect valves from freezing. Failure to

properly drain the lines can result in damage to

the valves, which is not covered under the cus-

tomer satisfaction policy.

Pressure Loss Chart

Pressure Loss - PSI

01020304

050

3/4" CP-075 1" CP-100

Flow Rate - GPM

Looking for dependable watering & irrigation products? Rely on Rain Bird for quality and long-lasting products.

Questo manuale è adatto per i seguenti modelli

Altri manuali Rain Bird Unità di controllo

Rain Bird

Rain Bird STP-400i Manuale utente

Rain Bird

Rain Bird CP-075 Istruzioni di montaggio

Rain Bird

Rain Bird CP Manuale operativo

Rain Bird

Rain Bird IQ-NCC Manuale utente

Rain Bird

Rain Bird Rain Bird Manuale utente

Rain Bird

Rain Bird TBOS-BT1 Manuale utente

Rain Bird

Rain Bird 100-DV Manuale utente

Rain Bird

Rain Bird HV Series Manuale utente

Rain Bird

Rain Bird WP 4 Manuale utente

Rain Bird

Rain Bird HV Series Manuale utente

Rain Bird

Rain Bird DAS-075 / ASVF 3/4 Manuale utente

Rain Bird

Rain Bird JTV Series Manuale utente

Rain Bird

Rain Bird TBOS-BT Manuale utente

Rain Bird

Rain Bird ICI+ Manuale utente

Rain Bird

Rain Bird 075-CPF Manuale del proprietario

Rain Bird

Rain Bird WP Series Manuale utente

Rain Bird

Rain Bird PGA Manuale

Rain Bird

Rain Bird DAS-075 I ASVF Manuale utente

Rain Bird

Rain Bird LNK2 Manuale utente

Rain Bird

Rain Bird TBOS Manuale utente

Rain Bird

Rain Bird TBOS-BT Manuale utente

Rain Bird

Rain Bird 300BPE Istruzioni operative

Rain Bird

Rain Bird STP-400i Guida all'installazione

Rain Bird

Rain Bird EASY RAIN Manuale utente

Manuali Unità di controllo popolari di altre marche

Festo

Festo Compact Performance CP-FB6-E Manuale elenco delle parti

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manuale utente

JS Automation

JS Automation MPC3034A Manuale utente

JAUDT

JAUDT SW GII 6406 Series Guida rapida

Spektrum

Spektrum Air Module System Manuale utente

BOC Edwards

BOC Edwards Q Series Manuale utente

KHADAS

KHADAS BT Magic Manuale utente

Etherma

Etherma eNEXHO-IL Manuale utente

PMFoundations

PMFoundations Attenuverter Manuale utente

GEA

GEA VARIVENT Manuale utente

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manuale utente

Altronix

Altronix LINQ8PD Istruzioni per il montaggio

Eaton

Eaton Powerware Series Manuale utente

WAGO

WAGO 750-407/040-000 Manuale utente

Sony

Sony CCU-590 Manuale utente

Graco

Graco 25D614 Manuale utente

Task Force Tips

Task Force Tips YE-RF-900 Manuale di programmazione

Shini

Shini SPV-U Series Manuale utente