Snorkel TM12E Manuale del proprietario

November 2016

Part Number 10016030

MANUAL

REPAIR PARTS

Serial number 000000 and after

GENERAL INFORMATION

GENERAL INFORMATION 1-1

REPAIR PARTS

TM12E ASSEMBLY 2-1

CHASSIS ASSEMBLY TM12E 2-2

TM12E CHASSIS ASSEMBLY 2-3

TM12E CHASSIS ASSEMBLY LOADCELL 2-4

CHASSIS TM SEM300 TM SEM300-11-XXXXXX AND AFTER 2-5

POTHOLE PLUNGER ASSEMBLY 2-6

WHEEL ASSEMBLY 12.72 2-7

REAR WHEEL ASSEMBLY 2-8

TRAILER HUB ASSEMBLY 2-9

HUB ASSEMBLY 2-10

TORQUE HUB 2-11

MAST ASSEMBLY TM12E 2-12

MAST CONTROL HARNESS ASSEMBLY #2 EIGHT PIN 2-13

MAST ASSEMBLY WITH LOAD CELL 2-14

MAST WIRE CHASE TM16E TM SEM300 2-15

LOADCELL ASSEMBLY ANSI CE 2-16

BEARING MOUNT ASSEMBLY LOADCELL 2-17

BEARING MOUNT ASSEMBLY LOADCELL 2-18

TOEKICK ASSEMBLY LOADCELL MARCH 2018 AND AFTER 2-19

TOEKICK ASSEMBLY LOADCELL DECEMBER 2016 AND BEFORE 2-20

PLATFORM ASSEMBLY WITH LOADCELL NOVEMBER 2018 AND BEFORE 2-21

PLATFORM LOADCELL ASSEMBLY DECEMBER 2018 AND AFTER 2-22

FOOT LATCH ASSEMBLY 2-23

PLATFORM EXTENSION ASSEMBLY TM12E 2-24

PLATFORM EXTENSION ASSEMBLY TM12E 2-25

EXTENSION LOCK ASSEMBLY 2-26

SALOON DOOR ASSEMBLY 2-27

DECAL KIT ANSI TM12E 2-28

DECAL KIT LOADCELL CE TM12E 2-29

DECAL KIT SWEDISH TM12E 2-30

DECAL KIT CE GERMAN 2-31

HYDRAULICS

HYDRAULIC POWER UNIT 3-1

HOSES TM12E 3-2

STEER CYLINDER ROSENBOOM 3-3

LIFT CYLINDER TM12E ROSENBOOM and PB 3-4

HYDRAULIC POWER UNIT WUXI 3-5

ELECTRICAL

STEP ASSEMBLY OCTOBER 2018 AND BEFORE 4-1

STEP ASSEMBLY NOVEMBER 2018 AND AFTER 4-2

CHASSIS HARNESS AC TM12E TM16E 4-3

CHASSIS HARNESS TM12E TM16E WITH OVERLOAD 4-4

TM12E TM16E CHASSIS HARNESS UPDATES MADE TO ADD NON-OVERLOAD TO SCHEMATIC

4-5

DRIVE HUB 24V (HUB, MOTOR, BRAKE) 4-6

110V AC PLUG ASSEMBLY 4-7

LOWER CONTROL PANEL ASSEMBLY WITH OVERLOAD TM12E TM16E 4-8

LOWER CONTROL PANEL ASSEMBLY NON OVERLOAD TM12E TM16E 4-9

HARNESS MAST ASSEMBLY TM12E ANSI 4-10

HARNESS MAST ASSEMBLY TM12E CE 4-11

MAST HARNESS CONTROL #1 8-PIN 4-12

MASTER CONTROL 4-13

MAST HARNESS AC TM12E 4-14

MAST HARNESS ASSEMBLY AC TM12E 4-15

MAST HARNESS AC PIGTAIL TM12E 4-16

MAST HARNESS ASSEMBLY OVERLOAD 4-17

MAST HARNESS CONTROL #2 8-PIN 4-18

PLATFORM CONTROL BOX ASSEMBLY WITH OVERLOAD TM12E TM16E SEPTEMBER 2017

AND BEFORE 4-19

PLATFORM CONTROL BOX TM WITH OVERLOAD ASSEMBLY OCTOBER 2017 through

FEBRUARY 2019 4-20

PLATFORM CONTROL BOX TM WITH OVERLOAD ASSEMBLY MARCH 2019 AND AFTER 4-21

PLATFORM CONTROL BOX CE 4-22

UPPER CONTROL BOX ASSEMBLY 4-23

JOYSTICK CONTROLS OEM 4-24

OPTIONS

TOOL TRAY INSTALLATION 5-1

SINGLE GATE ASSEMBLY 5-2

SCHEMATICS

TM12E TM16E ELECTRICAL SCHEMATIC 10001448A WITH OVERLOAD 6-1

TM12E TM16E ELECTRICAL SCHEMATIC 10001446A WITH OVERLOAD 6-2

TM12E TM16E ELECTRICAL SCHEMATIC 10001446B ADDED BRAKE CONNECTOR NOTE 6-3

TM12E TM16E ELECTRICAL SCHEMATIC 10001101B UPPER CONTROLS HARNESS 6-4

A A

B B

The aerial platform is not electrically insulated. Death or serious injury will result from contact

with, or inadequate clearance from, an energized conductor.

Do not go closer than the Minimum Safe Approach Distance as dened by ANSI standards.

Regard all conductors as energized.

Allow for electrical wire sag and aerial platform sway.

If the platform, mast, or any part of the aerial platform contacts a high-voltage electrical conductor,

the entire machine can become electrically charged.

If that happens, remain on the machine and do not contact any other structure or object. This in-

cludes the ground, adjacent buildings, poles, and any other objects that are not part of the aerial

platform.

Such contact could make your body a conductor to the other object, creating an electrical shock

hazard resulting in death or serious injury.

Ifanaerialplatformisincontactwithanenergizedconductortheplatformoperatormustwarnground

personnelinthevicinitytostayaway.Theirbodiescanconductelectricitycreatinganelectricalshock

hazard resulting in death or serious injury.

Do not approach or leave the aerial platform until the electricity has been turned off.

Do not attempt to operate the lower controls when the platform, scissors structure, or any part of

the aerial platform is in contact with a high-voltage electrical conductor or if there is an immediate

danger of such contact.

Personnel on or near an aerial platform must be continuously aware of electrical hazards, recogniz-

ing that death or serious injury can result from contact with an energized conductor.

California

Proposition 65 Warning

Battery posts, terminals and related accessories contain lead

andleadcomponents,chemicalsknownto theStateof California

to cause cancer and birth defects or other reproductive harm.

Wash hands after handling.

TM12E – 10016030 i

General Information

About This Manual

ThismanualcoversTM12E aerialplatforms.Information

is included for machines that have been manufactured

toconformtoallapplicablerequirementsofthe following

organizations:

yAmerican National Standards Institute (ANSI)

yCanadian Standards Association (CSA)

yEuropean Committee for Standardization (CE)

yAustralian Standards (AS) certication

Part pages include a drawing and a bill of material.

The bill of material lists the item number that is on the

drawing, the Snorkel part number, quantity used and a

description of the item.

Some callouts in the drawings may have a balloon with

two numbers. The top number is the item number and

the bottom number is the quantity of the item at that

location.

While Snorkel has attempted in every way to conrm that

all information in this manual is correct, improvements

are being constantly made to the machine that may not

be reected in this manual.

If you nd information in this manual that is not correct

or is confusing, you are urged to report your ndings to

Snorkel for our evaluation. Your input is important to us

and will be used in future printings of this manual.

This machine is covered by a limited warranty that

specically identies items warrantied by Snorkel and

thoseitemscoveredby original manufacturer's warranty.

Repairs and Maintenance

Every person who maintains, inspects, tests or repairs

the machine must be qualied and authorized to do so.

Caution

Do not modify this aerial platform without prior

written consent of Snorkel Engineering Department.

Modication may void the warranty, adversely affect

stability or affect the operational characteristics of

the aerial platform.

Abbreviations

The following abbreviations may be used in this manual.

AC alternating current

ANSI American National Standards Institute

AR as required

CCA cold cranking amps

cm centimeter

DC direct current

ft feet

GFCI ground fault circuit interrupter

in inch

lbs pounds

mm millimeter

no number

NPT national pipe thread

psi pounds per square inch

qty quantity

rpm revolutions per minute

UL Underwriters Laboratories Inc.

Additional Information

All correspondence relative to this machine, such as eld

reports, discrepancy reports, requests for information,

etc.,shouldbedirectedtooneofthe following locations:

Snorkel

8350 Eastgate Road

Henderson, NV 89015 USA

Phone: 1-702-628-9400

Snorkel

P.O. Box 1160

St. Joseph, MO 64502-1160 USA

Phone: 1-800-255-0317

Snorkel

Vigo Centre

Birtley Road

Washington

Tyne & Wear

NE38 9DA

Phone: +44 (0) 845 1550 058

http://www.snorkellifts.com

TM12E – 10016030

Component Identication

Chassis

Lower

Controls

Upper Controls

Left Side

Platform

Operator’s

Manual

Front

Rear

Tie-Down/Lift Lugs

Mast

Right Side

Battery

Tray

Hydraulic Reservoir

Accessible Through Either

Battery Tray

Charger

Outlet Plug

Front

Rear

Emergency

Lowering Knob

Saloon Entry

Doors

Battery Disconnect

Power to Platform

Outlet Plug

Battery Tray

Platform Extension

TM12E – 10016030 iii

Service and Parts Information

Ordering Parts

Whenplacinganorderforserviceorrepairparts,please

havethefollowingmachine information readilyavailable.

yModel number

ySerial number

ySnorkel part number

yDescription of part

yQuantity of parts required

yYour purchase order number

yAddress for order to ship to

yThe desired shipment method

If ordering parts off-line, the parts order form on the fol-

lowing page may be mailed or faxed to the attention of

the Parts Department at one of the following locations:

Snorkel

8350 Eastgate Road

Henderson, NV 89015 USA

Phone: 1-702-628-9400

Parts Fax: 1-702-636-4943

Snorkel

P.O. Box 1160

St. Joseph, MO 64502-1160 USA

Phone: 1-800-255-0317

Parts Fax: 1-785-989-3077

Snorkel

Vigo Centre

Birtley Road

Washington

Tyne & Wear

NE38 9DA

Phone: +44 (0) 845 1550 058

Parts Fax: +44 (0) 1952 607 678

Attention: Parts Department

For your convenience, our electronic on-line ordering

system is available at the following Internet location:

http://www.snorkellifts.com

ANSI and OSHA Compliance

All owners and users of the aerial platform must read,

understand and comply with all applicable regulations.

UltimatecompliancetoOSHAregulationsistherespon-

sibility of the user and their employer.

ANSI publications clearly identify the responsibilities

of all personnel who may be involved with the aerial

platform.Areprint of the “Manual of Responsibilities for

Dealers, Owners, Users, Operators, Lessors and Les-

sees of ANSI/SIAA92.6-2006 Self-Propelled Elevating

Work Platforms” is available from Snorkel dealers or

from the factory upon request.

Copies are also available from:

Scaffold IndustryAssociation, Inc.

P.O. Box 20574

Phoenix, AZ 85036-0574 USA

Manuals

Manuals are available from Snorkel to support any of

the machines that we produce.

The specic manuals for TM12E aerial platforms are

as follows:

TM12E Operator’s Manual ANSI

Snorkel part number – 10001135

TM12E Repair Parts Manual

Snorkel part number – 10016030

ANSI Manual of Responsibilities

ANSI/SIAA92.6-2006

Snorkel part number – 0361367

Machine Information

Model Number:

Serial Number:

Date of Purchase:

Purchased From:

Snorkel Dealer or Distributor:

TM12E – 10016030

Parts Order Form

Date:

Company:

Address:

Contact Name:

Phone Number:

Fax Number:

Account Number:

Purchase Order Number:

Model Number:

Serial Number:

Ship To:

Shipping Method:

Part Number Description Quantity

Note: Backordered parts will be shipped as soon as available using the same shipping method as the original

order unless otherwise indicated below.

Ship complete order only. Do not backorder parts.

Ship all available parts and disposition of backordered parts.

Other instructions as specied:

Fill out completely and fax attention Parts Department to:

Snorkel Henderson 1-702-636-4946

Snorkel Kansas 1-785-989-3077

Snorkel Europe +44 (0) 1952 607 678

REPAIRPARTS

TM12E PARTS MANUAL TM12E ASSEMBLY

TM12E ASSEMBLY Mon Feb 15 04:08:52 UTC 2021 2-1

アイテム部品番号名前数量 UOM

- 10001135E TM12EASSEMBLY EA

1 10000001 ASSY,CHASSISTM12 1 EA

2 10000002 ASSY,MASTTM12 1 EA

3 10001108 ASSY,EXTPLATFORMTM12E 1 EA

4 10000072 CYLINDER,LIFT 1 EA

5 6019281 SOLENOIDVALVE 1 EA

6 11700-009 FTNGSTR-06MB-06MFSF5OLO 1 EA

7 6091348 CHECKVALVEPOPPETFLOW

WITH0 1 EA

8 6019289 COIL20VDCHYDRAFORCE

4303620 1 EA

9 10001184 HANDLE,ALUM"T"10-32

THREAD 1 EA

10 11001-008 WASHER1/2SAEFLATASTM 8 EA

11 10908-008 NUT1/2-13UNCHEXLOCKREG 4 EA

12 10004-012 SCREW1/2-13UNCHHCX1-1/2 4 EA

13 10303-004 SCREW1/2SHSHLDRX1/2 2 EA

14 11001-004 WASHER1/4SAEFLATASTM* 10 EA

15 10908-004 NUT1/4-20UNCHEXLOCKREG 5 EA

16 10000-014 SCREW1/4-20UNCHHCX1-3/4 2 EA

17 10000-018 SCREW1/4-20UNCHHCX2-1/4 1 EA

18 10000-007 SCREW1/4-20UNCx7/8HHCG8 2 EA

Not

Shown 10001081 SCREWNAILNO4X1/4L 4 EA

Not

Shown 10001701 KIT,US110VACPLUG 1 EA

TM12E PARTS MANUAL TM12E ASSEMBLY

TM12E ASSEMBLY Mon Feb 15 04:08:52 UTC 2021 2-1

Indice

Altri manuali Snorkel Sistema di sollevamento

Snorkel

Snorkel AB60J Manuale utente

Snorkel

Snorkel S3215L Manuale utente

Snorkel

Snorkel S2646E Manuale utente

Snorkel

Snorkel MB26J Manuale utente

Snorkel

Snorkel A62JRT Manuale utente

Snorkel

Snorkel SR2770 Manuale per l'uso e la cura

Snorkel

Snorkel MHP15/44 Manuale utente

Snorkel

Snorkel ML15I Manuale utente

Snorkel

Snorkel MHP 13/35 Mark II Manuale per l'uso e la cura

Snorkel

Snorkel SL30SL Manuale utente

Snorkel

Snorkel AB85J Manuale del proprietario

Snorkel

Snorkel A38E Manuale utente

Snorkel

Snorkel ML12C Manuale utente

Snorkel

Snorkel MHP13AT Manuale utente

Snorkel

Snorkel PRO 126 Manuale per l'uso e la cura

Snorkel

Snorkel SR2770 Manuale utente

Snorkel

Snorkel TL49J Manuale utente

Snorkel

Snorkel SL26 Series Guida rapida

Snorkel

Snorkel UL40 Guida rapida

Snorkel

Snorkel S3006P Manuale utente

Snorkel

Snorkel AB60J Manuale del proprietario

Snorkel

Snorkel SL20 Manuale utente

Snorkel

Snorkel SL26-01 Series Manuale utente

Snorkel

Snorkel S3010E Guida rapida

Manuali Sistema di sollevamento popolari di altre marche

morse

morse 82H-124 Manuale utente

Braun

Braun NL955 Series Manuale utente

haacon

haacon 1889.10 Manuale utente

Protekt

Protekt AT 252 Manuale utente

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Manuale utente

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Manuale utente

Genie

Genie Z-60/34 Manuale utente

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Manuale utente

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Manuale utente

Custom Equipment

Custom Equipment Hy-Brid 3 Series Manuale di programmazione

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Manuale di programmazione

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Manuale di programmazione

BERG

BERG BeNomic EasyLeaf Manuale utente

Powermate

Powermate LiftGate LG-3 Manuale utente

Terberg

Terberg OMNIDEKA Manuale utente

Harmar Mobility

Harmar Mobility AL625 Istruzioni operative

Rotary

Rotary SPO16 Manuale utente

Ricon

Ricon Mirage F9T Manuale utente