Sundance Spas Solo Istruzioni operative

Portofino Series

Installation & Owner’s Manual

Revised Sections 9.7

9.7 Programming the Filter Cycle

Tango, Caprio, and Caprio ST Models Only

Proper filtration is an important key to maintaining the clarity of your hot tub’s water. The hot tubs filtration

system is designed for unsurpassed effectiveness at removing debris and suspended particles from the water

anytime the water is circulated by the pump.

To select a pre-programmed filter cycle or lockout mode, press and hold both control panel WARMER and

COOLER arrow keys at the same time, then release. Then press either WARMER or COOLER arrow

keys to select filter mode F1 through L2 below:

F1 No filter cycle - power-up default (recommended for Solo models only)

F2 1 hour of filtration a day two minutes after initial power-up

F3 2 hours of filtration a day (1 hour cycle every 12 hours)

F4 3 hours of filtration a day (1 hour cycle every 8 hours)

F5 4 hours of filtration a day (1 hour cycle every 6 hours)

F6 6 hours of filtration a day (1 hour cycle every 4 hours)

L1 Lock Out (disables all hot tub functions to permit filter cleaning)

L2 Lock Mode (disables the jets and light buttons to prevent unauthorized use of the

hot tub) - filter cycles and heater will continue to operate as programmed in this

mode. The temperature display flashes when this function is enabled. Example: the

“F3” filter cycle was enabled prior to choosing lock mode. The hot tub continues to

perform filter cycle “F3” until lock mode is canceled, allowing another filter cycle to

be selected.

To set a time for the first filter cycle, simply turn power on to the spa two minutes prior to the desired filter

time. EXAMPLE: If you desire your first filter cycle to begin at 10:00 AM turn off power to the spa and turn it

back on again at 9:58 AM. Note: start time is approximate and may vary slightly from day to day.

Section 9.0 Changes (Underlined)

9.0 Operating Instructions

The spa control system has automatic functions that operate upon start-up and normal opera-

tion to protect the system. Upon power up, the readout displays the following information:

1. Control panel displays current software release (e.g. 3.50 or 6.17), then;

Important Note: If your system displays 3.50 upon strartup, disregard

this addendum sheet and refer solely to the owner’s manual. If your

system displays 6.17 upon startup, refer to revised section 9.7 below

for proper filter cycle programming instructions.

ADDENDUM - IMPORTANT OPERATING INSTRUCTION CORRECTION!

Sundance Portofino Series Owner’s Manual

#6530-374, Revision-A & B

Several sections in the owner’s manual contains revisions for models manufactured between January and

April 2002. Please refer to the changes outlined below when operating your new spa.

Startup

Sequence

Table of Contents

1.0 Important Spa Owner’s Information...................................1

2.0 FCC Notice............................................................................1

3.0 Important Safety Instructions.............................................2

3.1 General Electrical Safety Instructions....................................4

4.0 Choosing a Location ...........................................................5

4.1 Outdoor Location ...................................................................5

4.2 Indoor Location ......................................................................6

5.0 Power Supply Requirements ..............................................7

6.0 Electrical Wiring Instructions .............................................8

7.0 Start-Up Instructions ...........................................................9

7.1 Filling the Spa ........................................................................9

7.2 Safety Check........................................................................10

7.3 Initiating Water Circulation...................................................10

7.4 Adding Start-Up Chemicals ................................................. 10

8.0 Control Panel Functions ................................................... 11

9.0 Operating Instructions ......................................................12

9.1 Setting Water Temperature ..................................................12

9.2 Pump Button ........................................................................12

9.3 Light Button..........................................................................12

9.4 Solo Diverter Valve / Air Control Operation ..........................13

9.5 Tango Diverter Valve / Air Control Operation .......................13

9.6 Caprio / Caprio ST Diverter /Air Control Valve Operation ...14

9.7 Filtration Options..................................................................15

9.8 Select the Filtration Mode ....................................................15

10.0 Care And Maintenance ......................................................16

10.1 Cleaning The Filter...............................................................16

10.2 Draining And Refilling...........................................................18

10.3 Cleaning The Spa Interior ....................................................19

10.4 Cleaning The Pillows............................................................19

10.5 Maintaining The Cover .........................................................20

10.6 Maintaining The Wood Cabinet............................................20

10.7 Winterizing The Spa............................................................ 21

10.8 Maintaining Water Quality ................................................... 21

10.9 Controlling pH ..................................................................... 21

10.10 Sanitizing / Using Additives ................................................. 22

11.0 Error Conditions / Error Messages ................................. 22

11.1 Summer Logic..................................................................... 22

11.2 Overheat Condition

OH.......................................................

11.3 Panel displays

SN1.............................................................

11.4 Panel displays

SN2.............................................................

11.5 Panel displays

FL1 or FL2 ..................................................

11.6 Panel displays

COL ............................................................

11.7 Panel displays

ICE..............................................................

11.8 Panel displays

- - - -

........................................................... 25

12.0 Troubleshooting Procedures ........................................... 25

12.1 No Components Operate (e.g. Pump, Light) ...................... 25

12.2 Pump Does Not Operate But Light Does ............................ 25

12.3 Poor Jet Action.................................................................... 26

12.4 Water is Too Hot.................................................................. 26

12.5 No Heat............................................................................... 26

13.0 Spa Equipment Packs ...................................................... 27

13.1 Solo Equipment Pack ......................................................... 27

13.2 Tango Equipment Pack....................................................... 27

13.3 Caprio / Caprio ST Equipment Pack................................... 28

14.0 Spa Overhead Views......................................................... 28

14.1 Solo Overhead View ........................................................... 28

14.2 Tango Overhead View......................................................... 29

14.3 Caprio / Caprio ST Overhead View .................................... 29

15.0 120/240 VAC Convertible Circuit Diagram...................... 30

16.0 230-240 VAC Dedicated Circuit Diagram ........................ 31

17.0 Specifications.................................................................... 32

17.1 Solo Specifications ............................................................. 32

17.2 Tango Specifications........................................................... 34

17.3 Caprio / Caprio ST Specifications....................................... 36

1.0 Important Spa Owner’s Information

Your Portofino spa is constructed of the highest standards and is

capable of providing many years of trouble-free use. However,

because heat retentive materials are utilized to insulate the spa for

efficient operation, an uncovered spa surface directly exposed to

sunlight and high temperatures for an extended period of time is

subject to permanent damage. Damage caused by exposing the

spa to this abuse is not covered by warranty. We recommend that

you always keep the spa full of water when it is exposed to direct

sunlight and that you keep the Sundance insulating cover in place at

all times when the spa is not in use. Read and carefully follow the

requirements for your spa’s support base.

Refer to section 4.0-4.2

(page 5-6).

Sundance Spas Inc. constantly strives to offer the finest spas avail-

able, therefore modifications and enhancements may be made

which affect the specifications, illustrations and/or instructions

contained herein.

2.0 FCC Notice

This equipment has been tested and found to comply with

the limits for a Class B Digital Device, pursuant to Part 15 of

the FCC Rules. These limits are designed to provide

reasonable protection against harmful interference in a residential

installation. This equipment generates, uses and can radiate radio

frequency energy and, if not installed and used in accordance with

the instructions, may cause harmful interference to radio communi-

cations. However, there is no guarantee that interference will not

occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be

determined by turning the equipment off and on, the user is encour-

aged to try to correct the interference by one or more of the follow-

ing measures:

1. Rearrange or relocate the receiving antenna;

2. Increase the separation between the equipment and receiver;

3. Connect the equipment into an outlet on a circuit different from

the circuit connected;

4. Consult the dealer or an experienced radio/TV technician for

help. 1

Changes or modifications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.

3.0 Important Safety Instructions

When installing and using this equipment, basic safety

precautions should always be followed, including the

following:

1. READ AND FOLLOW ALL INSTRUCTIONS BEFORE OPERAT-

ING THE SPA!

2. DANGER - RISK OF ELECTRICAL SHOCK. Install spa at least

5 feet (1.5 m) from all metal surfaces. (A spa may be installed

within 5 feet (1.5 m) of metal surfaces, if in accordance with the

country electrical code).

3. DANGER - RISK OF ELECTRICAL SHOCK. Do not permit any

electric appliance such as a light, telephone, radio, or television

within 5 feet (1.5 m) of the spa.

4. INSTALLATION - The spa must be installed in such a manner

as to provide drainage of the compartment for electrical compo-

nents.

5. CAUTION, 240 VAC POWERED SPAS - These spas must be

hard wired to your household electrical service box only. Do not

use an extension cord or any other disconnectable power cord.

The use of an extension cord or a disconnectable power cord is

highly dangerous and will void all warranties!

6. A wire connector marked ground “GRN” is provided within the

power box.

Refer to section 6.0 (page 8).

To reduce the risk of

electric shock, connect this terminal or connector to the ground-

ing terminal of your electrical service or supply panel with a

continuous green insulating copper wire equivalent in size to the

circuit conductors supplying this equipment, but no smaller than

#8 AWG (8.4 mm2). In addition, a second wire connector is

provided for bonding to local ground points. To reduce the risk

of electrical shock, this connector should be bonded with a #8

AWG (8.4 mm2) copper wire to any metal ladders, water pipes,

or other metal within 5 feet (1.5 m) of the spa.

7. The electrical supply for this product must include a suitably

rated switch or circuit breaker to open all ungrounded supply

conductors to comply with the country electrical code.

8. Before entering a spa or hot tub the user should measure the

water temperature with an accurate thermometer since the

tolerance of the water temperature regulating device may vary

as much as ±5 °F (±3 °C).

9. Always enter and exit the spa slowly and cautiously. Wet

surfaces are slippery.

10. Do not use the spa alone.

11.WARNING - RISK OF CHILD DROWNING. Extreme caution

must be exercised to prevent unauthorized access by children.

To avoid accidents, ensure that children cannot use a spa or hot

tub unless they are supervised at all times.

12. DANGER - To reduce the risk of injury, do not remove any drain

suction gate or cover.

13. Never use the weir gate for sitting or resting your feet. It is

designed to float freely.

14. The water in the spa or hot tub should never exceed 104 °F (40

°C). Water temperatures between 100 °F (38 °C) and 104 °F

(40 °C) are considered safe for a healthy adult. Lower water

temperatures are recommended for extended use (exceeding

10-15 minutes) and for young children.

15. Since excessive water temperatures have potential for causing

fetal damage during the early months of pregnancy, pregnant or

potentially pregnant women should limit spa or hot tub water

temperatures to 100 °F (38 °C).

16. The use of alcohol, drugs, or medication before or during spa or

hot tub use may lead to unconsciousness with the possibility of

drowning.

17. Persons suffering from obesity or with a medical history of heart

disease, low or high blood pressure, circulatory system prob-

lems, or diabetes should consult a physician before using a spa

or hot tub.

18. Persons using medication should consult a physician before

using a spa or hot tub since some medications may induce

drowsiness while other medications may affect heart rate, blood

pressure, and circulation.

19. Long exposures in the spa may result in nausea, dizziness, or

fainting. Observe a reasonable time limit, leave the spa, then

shower, cool down, and if you wish, return for another brief stay.

20. Excessive temperatures may cause hyperthermia. Symptoms

and first aid information are as follows:

•HEAT STROKE: The most susceptible people are the very

young and elderly, alcoholics, and most people under the influ-

ence of drugs, medication and alcohol.

•SYMPTOMS: Hyperthermia causes loss of salt, sweating,

dizziness, headache, dryness of mouth and nausea, faintness

and/or unconsciousness, convulsions, flushed appearance of

skin, and rapid pulse and/or weak, shallow breathing.

•TREATMENT: Place the victim on his back, head slightly el-

evated. Apply wet cloths or ice packs to the head, wrap the body

in a sheet, pouring on a small amount of water. Follow with a

cool shower or bath. Get medical attention as soon as possible.

21. It is recommended that the following emergency telephone

numbers be listed at the nearest telephone: physician, hospital,

ambulance and police.

22. Save these instructions!

3.1 General Electrical Safety Instructions

Your new Portofino spa is equipped with the “state-of-the-art” LX-10

equipment system. It contains the most advanced safety and

self-protective equipment in the industry. Nonetheless, this spa

must be installed properly to insure dependable usage. Please

contact your dealer if you have any questions regarding your instal-

lation. In the event they are unable to answer your questions, direct

your inquiries to Sundance Spas Inc. Please refer to the back of this

manual for our address.

Proper grounding is extremely important. Portofino spas are

equipped with a current collector system. Apressure-type wire

connector is provided outside the control box, located behind the

equipment door to permit connection of a bonding wire between this

point and any ground metal equipment, metal water pipe or conduit

within 5 feet (1.5 m) of the spa, or copper clad grounding rod buried

within 5 feet (1.5 m) of the spa. The bonding wire must be at least

#8 AWG (8.4 mm2) solid copper wire. This is a very important safety

assurance feature. Before installing this spa, check with the local

electrical authority to insure the installation conforms to local coun-

try/area state codes.

4.0 Choosing a Location

IMPORTANT: Because of the combined weight of the spa,

water, and users, it is extremely important that the base

upon which the spa rests be smooth, flat, level and capable

of uniformly supporting this weight without shifting or settling for the

entire time the spa is in place. If the spa is placed on a surface

which does not meet these requirements, damage to the skirt and/or

the spa shell may result. Damage caused by improper support is

not covered under the manufacturer’s warranty. It is the responsibil-

ity of the spa owner to assure the integrity of the support at all times.

We recommend a poured, reinforced concrete slab with a minimum

thickness of 4 inches (10 cm). Wood decking is also acceptable,

provided it is constructed so that it meets the requirements outlined

above. The spa must be installed in such a manner as to provide

drainage away from the spa. Placing the spa in a depression

without provisions for proper drainage could allow rain, overflow and

other casual water to flood the equipment and create a wet condition

in which it would sit.

For spas which will be recessed into a floor or deck, install so as to

permit access to the equipment, either from above or below, for

servicing. Make certain that there are no obstructions that would

prevent removal of the cabinet side panels, especially on the side

with the equipment pack. Make sure provisions are made for drain-

ing the spa.

4.1 Outdoor Location

In selecting the ideal outdoor location for your spa, we suggest that

you take into consideration:

1. The proximity to changing area and shelter around spa (espe-

cially in colder weather).

2. The pathway to and from your spa (this should be free of debris

so that dirt and leaves are not easily tracked into the spa).

3. Closeness to trees and shrubbery (remember that leaves and

birds could create extra work in keeping the spa clean).

4. A sheltered environment (less wind and weather exposure can

result in lowered operation and maintenance costs).

5. The overall enhancement of your environment.

6. It is preferable not to place the spa under a gutter-less roof

overhang since runoff water will shorten the life expectancy of

the spa cover.

4.2 Indoor Location

For indoor installations, be certain to make provisions for proper

ventilation. When the spa is in use, considerable amounts of mois-

ture will escape. This can damage various surfaces over time. A

dehumidifier can help control the moisture in the room. If you have

any questions regarding the placement or installation of your spa,

consult your authorized Portofino dealer.

120/240 Volt Convertible Models

A spa connected to a 120 VAC electrical service must be located

close enough to a grounded, grounding-type electrical outlet so that

the included power cord can be plugged directly into it. DO NOT

USE AN EXTENSION CORD as this could cause damage to the hot

tub’s equipment due to insufficient voltage. The power supplied to

this hot tub must be a dedicated circuit with no other appliances or

lights sharing the power provided by the circuit.

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Sundance Spas Vasca idromassaggio

Sundance Spas

Sundance Spas ALTAMAR Manuale utente

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Hawthorne Manuale utente

Sundance Spas

Sundance Spas Altamar 880 series Manuale utente

Sundance Spas

Sundance Spas Camden Manuale utente

Sundance Spas

Sundance Spas Edison Manuale utente

Sundance Spas

Sundance Spas Spas Manuale utente

Sundance Spas

Sundance Spas 680 Series Manuale utente

Sundance Spas

Sundance Spas Marin 880 Manuale utente

Sundance Spas

Sundance Spas 780 series Manuale utente

Sundance Spas

Sundance Spas Burlington Manuale utente

Sundance Spas

Sundance Spas Denali 680 Series Manuale utente

Sundance Spas

Sundance Spas Spas 680 Series Manuale utente

Sundance Spas

Sundance Spas 880 Series Manuale utente

Sundance Spas

Sundance Spas Portofino Series Istruzioni per l'installazione

Sundance Spas

Sundance Spas 850Export Series Istruzioni operative

Sundance Spas

Sundance Spas 850 Series Manuale utente

Sundance Spas

Sundance Spas 850 Series Istruzioni operative

Sundance Spas

Sundance Spas Altmar Manuale utente

Sundance Spas

Sundance Spas maxxus 880 Series Manuale utente

Sundance Spas

Sundance Spas ALTAMAR 880 Manuale utente

Sundance Spas

Sundance Spas Export 680 Series Manuale utente

Sundance Spas

Sundance Spas ALTAMAR 880 Manuale d'uso e manutenzione

Sundance Spas

Sundance Spas Hamilton Manuale utente

Manuali Vasca idromassaggio popolari di altre marche

Bestway

Bestway Lay-Z-Spa 54189 Manuale utente

Jacuzzi

Jacuzzi ARGA ARG101C0110 Manuale elenco delle parti

Morphy Richards

Morphy Richards Essentials PC4006 Manuale utente

Softub

Softub PRESTIGE Manuale utente

JNJ SPAS

JNJ SPAS SPA-318 Manuale di installazione

KIRAMI

KIRAMI Comfort Family Manuale utente

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Manuale utente

HoMedics

HoMedics FB-655HJ-GB Manuale utente

Everyday Hot Tubs

Everyday Hot Tubs 530 Manuale utente

anko

anko SS-601A Manuale utente

Jacuzzi

Jacuzzi Duetta 6042 Manuale utente

Pooli

Pooli OS030979B Manuale utente

Jacuzzi

Jacuzzi alimia Manuale utente

ab Solares Smart Spa Manuale utente

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Manuale utente

Outsunny

Outsunny 848-047V70 Manuale utente

Aquatic

Aquatic INFINITY 1 Manuale utente

Master Spas

Master Spas MP Force Manuale utente