Whispbar K871W Manuale utente
K871W
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 4 x 4 x 4 x 4
x 2 x 2 x 2 x 2
Revision No: 1A 1
Fitting Kit K871W
MAX kgs (lbs)
W/P WHD
Peugeot
5008 , 5dr MPV 09-+ AU 65 kgs (143 lbs) 65 kgs (143 lbs)
5008 , 5dr MPV 09-+ EU 65 kgs (143 lbs) 65 kgs (143 lbs)
2
Fitting Kit EN
K871W
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
●Use keys to remove covers.
3
Fitting Kit EN
K871W
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
●Set bars to length (revert to rear of these
instructions).
●Please check the rear of this manual for
information relating specifically to your
vehicle.
4
Fitting Kit EN
K871W
●Tighten adjusting screw to 3 Nm (2.2 ft lb)
hand tight.
●Remove plastic clamp block by gripping bar
leg with fingers and push firmly with
thumbs until clamp block drops out behind
leg.
●Select plastic internal block (from fitting kit)
and insert into foot.
●Repeat for all legs.
5
Fitting Kit EN
K871W
Fitment
●Open or remove fixed-point covers.
●Select grubscrews and screw into the
vehicle's fixed points.
●Do not over tighten.
●Repeat for all four positions.
●70mm front, 80mm rear
●Insert brass bushing, short one at the front,
long at the rear. Hand-tighten.
6
Fitting Kit EN
K871W
●Insert load-support as shown on the
picture.
●Place the pad over load support.
●Place crossbar foot over grubscrews.
●Make sure the pad fits into the holes
underneath the foot.
7
Fitting Kit EN
K871W
●Tighten the plastic knob. The side with the
nut showing should be facing up.
●Ensure the plastic knob is in the position
shown when fully tightened.
●Repeat for all four positions.
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
8
Fitting Kit EN
K871W
CAUTION: Recheck all fasteners immediately after
a load is applied to the crossbars.
Regularly check screws are tight.
9
Fitting Kit EN
K871W
Maintenance
●Clean the car roof and surfaces of the
product that will be in contact with the car
roof.
●Follow the fitting instructions for fitting the
product to your vehicle. Make sure all steps
are carried out in order.
●Set crossbars a minimum distance of
700mm (27 1/2") apart where no other
distance is specified in the fitting
instructions. This is especially important
when carrying long loads.
●Check unit is securely attached whenever
you refit it to the vehicle. If the unit feels
loose, refer to the fitting instructions and
readjust.
●Some glass/panoramic roofs and radio
antennae may not be able to be used when
the product is fitted.
●Do not modify this product.
●Refer to the maximum permitted load
capacity specified in the fitting instructions.
Do not exceed the vehicle manufacturers
roof load rating if it is lower than the
maximum load capacity specified in the
fitting instructions.
●Loads should not overhang the sides of the
product and be evenly distributed with the
lowest possible centre of gravity.
●Long loads should be secured with non-
elastic straps to the front and rear of the
vehicle.
●Objects with pointed ends (e.g. ski poles)
should be carried with the pointed ends to
the rear of the vehicle.
●Remove all loose or removable objects
from the load prior to loading.
●Make sure all loads are securely fastened
with non-elastic straps. Check regularly
during longer journeys.
●A loaded roof rack system can alter the
performance of your vehicle. Be especially
aware of the effects of side winds,
changing of direction, and braking
performance. Avoid rapid acceleration and
deceleration. Drive carefully.
●Note that the total height of the vehicle
increases when upright loads are carried.
●Products should be locked during transport
if they have locks fitted.
10
Indice
Altri manuali Whispbar Accessori per automobili
Whispbar
Whispbar K425W Manuale utente
Whispbar
Whispbar K880W Manuale utente
Whispbar
Whispbar S47W Guida all'installazione
Whispbar
Whispbar K540W Manuale utente
Whispbar
Whispbar K649W Manuale utente
Whispbar
Whispbar K447W Manuale operativo e di installazione
Whispbar
Whispbar K864W Manuale utente
Whispbar
Whispbar K489W Manuale utente
Whispbar
Whispbar K471W Manuale utente
Whispbar
Whispbar K1002W Manuale operativo e di installazione
Whispbar
Whispbar K390W Manuale utente
Whispbar
Whispbar K668 Manuale utente
Whispbar
Whispbar K401W Manuale utente
Whispbar
Whispbar K456 Manuale utente
Whispbar
Whispbar K629W Manuale utente
Whispbar
Whispbar K532W Manuale utente
Whispbar
Whispbar K383W Manuale utente
Whispbar
Whispbar K115W Manuale utente
Whispbar
Whispbar K193W Manuale utente
Whispbar
Whispbar K899W Manuale utente
