Extech Instruments IR260 Manuale utente

USERGUIDE

MiniInfraRedThermometer

WithLaserPointerandHigh‐LowAlarms

ModelIR260

99 Washington Street

Melrose, MA 02176

Phone 781-665-1400

Toll Free 1-800-517-8431

Visit us at www.TestEquipmentDepot.com

EXTECHINSTRUMENTS

2 IR260‐en‐GB_V1.21/16

Introduction

CongratulationsonyourpurchaseoftheIR260IRThermometer.Thisthermometermakesnon‐

contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐inlaserpointer

increasestargetaccuracywhilethebacklitLCDandhandypushbuttonscombineforconvenient,

ergonomicoperation.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,will

provideyearsofreliableservice.

Features

Measuresnon‐contactsurfacetemperatureupto400°C(752°F)

12:1DistancetoSpotRatio(FieldofView)

Single‐pointlasertargeting

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Maximum‐Minimumtemperaturefunction

Selectabletemperatureunits(°F/°C)

Dynamicbatterystatusindication

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolorterminal,indicatestheusermustrefertothemanualfor

furtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyesofapersonorananimal

oInspectfordamageorforanyshortageofpartsoraccessoriesbeforeuse

oReplacethebatteriesimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethe

measuredtemperaturevaluetoreadmuchlowerthantheactual

temperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments

<1mW Output at 650nm

EXTECHINSTRUMENTS

3IR260‐en‐GB_V1.21/16

Description



MeterDescription

1. LCDDisplay

2. MAX‐MIN/DownButton

3. Backlight‐LaserPointer/UpButton

4. Laserpointerlens

5. IRThermometerlens

6. SETButton

7. MeasurementScanTrigger

8. BatteryCompartment

DisplayDescription

Emissivityvalueindication

Laserpointeractiveicon



Scanmode(activewhilethetriggerispulled;displayed

temperaturetracksthetemperatureofthescannedsurfaces)

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimumtemperatureicons

Batterycapacityindicator(flasheswhenbatteryvoltageiscritical)

DisplayBacklighticon

Temperatureunits(°F/°C)

TemperatureAlarmiconsandaudiblealarmdisableicon

EXTECHINSTRUMENTS

4IR260‐en‐GB_V1.21/16

Operation

MeterPower

Themeterispoweredbytwo1.5VAAbatteries.Withfreshbatteriesinstalled,themeter

switchesONwhenthetriggerispulled.Thebatteriesarelocatedinthemeterhandle;pullthe

batterycompartmentlidawayfromthebodyofthemetertoopen.RefertotheMaintenance

sectionformoreBatteryInstallationinstructions.Thebatteryiconprovidesbatterystatus

indication.Replacethebatteriesassoonasthebatterystatusiconflashes.

SurfaceTemperatureMeasurements

1. HoldthemeterbyitsHandleGripandpointittowardthesurfacetobemeasured.Readthe

FieldofViewsectionbelowfordistancetotarget(spot)ratioinformation.

2. PullandholdtheTriggertoturnthemeteronandbegintestinginScanmode.Thedisplay

willlightifthetwo1.5Vbatteriesaregood.Replacethebatteriesifthedisplaydoesnotlight.

3. ReleasetheTrigger;thereadingwillholdforapproximately9seconds,afterwhichthemeter

willautomaticallyshutoff.

4. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.Forexample,ifthelaserissettoONandthetemperatureunitsaresettooFatthetime

theunitisswitchedOFF,theunitwillswitchONandusethesamesettings.

Laser–ON/OFF

Pull the trigger and release.

PushandHOLDthe buttonforabout3secondstoswitchthelaserpointerONorOFF.

TheLasericonwillflashwhenthestatehaschanged.WhenthelaserisON,thelasericon will

appearontheLCD.Aimtheredlaserbeamapproximatelyahalfinchbelowthepointoftest

(pressingtheLaserbuttonagainturnsthelaseroff).

MAX‐MINMode

Pressthetriggerandrelease.

PresstheMAX‐MINbuttontoviewthemaximumtemperaturereading(MAX),pressagainto

viewthelowestreading(MIN).PressandholdtheMAX‐MINbuttontoswitchtheMAX‐MIN

modeoff.

DisplayBacklight

Pressthetriggerandrelease.

Pressthebacklightbutton momentarilytoswitchthebacklightONorOFF.

Over‐rangeIndicators(OLand‐OL)

Ifthetemperaturemeasurementexceeds779°F(415°C),thethermometerwilldisplayOLin

placeofatemperaturereading.Ifthetemperaturemeasurementisbelow‐25°C(‐13°F),the

thermometerwilldisplay‐OLinplaceofatemperaturereading.



EXTECHINSTRUMENTS

5IR260‐en‐GB_V1.21/16

SettingMode

ReleasethetriggerandpresstheSETbuttontoaccesstheSettingMode.UsetheSETbuttonto

navigatethroughtheSettingModefieldsanduse(UP)andtheMAX‐MIN(DOWN)

buttonstomakechanges.Theavailableparametersarelistedbelow:

Emissivitysetting

°C/°Ftemperatureunitsselection

TemperatureAlarmAudibleBeeperEnable/Disable

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Thecorrespondingparametericonwillflashwhenselected.ToexittheSettingMode,press

andholdtheSETbuttonfortwoseconds.

EmissivitySetting

The iconwillflashwhenselected.UsetheupandMAX‐MINdownbuttonsto

increaseordecreasetheemissivity(in0.01steps).Theemissivityrangeis0.10to1.00.Hold

theupordownbuttontorapidlyincreaseordecreasetheemissivityvalue.PresstheSET

buttontoconfirmandtosteptothenextoption.

SelectingtheTemperatureUnitofMeasure(°C/°F)

Usethe upandMAX‐MINdownbuttonstoselect°Cor°F.PresstheSETbuttonto

confirmandtosteptothenextoption.

Enable/DisableAudibleTemperatureAlarm

Thisparameterisusedtoenable/disabletheaudibletemperaturealarm.Theiconwillflash

inthismode.

UsetheupandMAX‐MINdownbuttonstotogglethesetting.Whentheaudible

alarmisdisabled,thedisplaywillshow‘HIGHLOW’.Whentheaudiblealarmisenabled,the

displaywillshow.Whentheaudiblealarmisenabled,thebeeperisallowedto

soundwheneverthemeasuredtemperaturegoesbeyondthehighorlowtemperaturelimit

values.PresstheSETbuttontoconfirmandtosteptothenextoption.

HIGHTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheHighAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingtheupordownbuttonwill

rapidlyincreaseordecreasetheHIGHlimitvalue.AbeepwillsoundiftheHIGHtemperature

valuereachestheLOWtemperaturevaluewhileprogramming.PresstheSETbuttonto

confirmandtosteptothenextoption.

LOWTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheLowAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingdowntheupordown

buttonwillrapidlyincreaseordecreasetheLOWlimitvalue.AbeepwillsoundiftheLOW

temperaturevaluereachestheHIGHtemperaturevaluewhileprogramming.PresstheSET

buttontoconfirmandtosteptothenextoption.

EXTECHINSTRUMENTS

6IR260‐en‐GB_V1.21/16

LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyondthetargetandthenscan

theentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris24inches

fromthetarget(spot),thediameterofthetargetmustbeatleast2inches.Otherdistancesare

shownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadecloserthan2feetfromthetarget.Themeter

canmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedbyexternalsources

oflight.Inaddition,thespotsizemaybesolargethatitencompassessurfaceareasnotintended

tobemeasured.



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.Seetheaccompanyingdiagram.



Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

EXTECHINSTRUMENTS

7IR260‐en‐GB_V1.21/16

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

Maintenance

Cleaning

Tocleanthelensesusecompressedairtocleardustandotherparticles,thencarefullyclean

withawetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR260inwaterorotherliquid.

Troubleshooting

SymptomProblemAction

OLdisplayTargettemperatureexceedsrangeSelectatargetwithinrange

‐OLdisplayTargettemperatureunder‐rangeSelectatargetwithinrange

BatteryiconflashesLowBatterypowerReplaceBatteries

BlankdisplayscreenLowbatterypowerCheckand/orreplacebatteries

NoLaserpointerLowbatteryorenvironmental

temperaturehigherthan40°C(104°F)

Replacethebatteries ormovethe

IR260toanareawithalower

ambienttemperature

EXTECHINSTRUMENTS

8IR260‐en‐GB_V1.21/16

ReplacingBatteries

Whenthebatteryiconflashes,orwhenthemeterdoesn’tswitchON,replacethebatteries.

Thebatterycompartmentislocatedinthehandlegrip.Thebatterycompartmentlidislocated

justbelowthetrigger.Prythecompartmentlidofftoreachthecompartment.

Replacethe1.5VAAbatteriesfollowingcorrectpolarityandthenclosethebatterycompartment

lid.

BatterySafetyNotes:Pleasedisposeofbatteriesresponsibly;neverdisposeofbatteriesinafire,

batteriesmayexplodeorleak.Ifthemeterisnottobeusedfor60daysormore,removethe

batteryandstoreseparately.Donotmixbatterytypesorfreshnesslevels;pleaseusebatteries

ofthesametypeandofthesamefreshnesslevel.



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriatecollection

sites,theretailstorewherethebatterieswerepurchased,orwhereverbatteriesaresold.



Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotake

end‐of‐lifedevicestoadesignatedcollectionpointforthedisposalofelectricalandelectronic

equipment.



EXTECHINSTRUMENTS

9 IR260‐en‐GB_V1.21/16

Specifications

InfraredThermometerSpecifications

Range/Resolution‐20.0to400.0oC(‐4.0to752.0oF)

Accuracy‐20~0oC(‐4~32oF):±5°C(9°F)

0~400oC(32~752oF)±2°C(3.6°F)or2%ofreading(whicheverisgreater)

Note:Accuracyisspecifiedforthefollowingambienttemperaturerange:

21to25°C(70to77°F)

EmissivityAdjustablefrom0.10to1.00

FieldofView12:1DistancetoSpotratio

LaserpowerLessthan1mW

Spectralresponse630to670nm(wavelength)

GeneralSpecifications

Display BacklitLCDdisplaywithfunctionindicators

Displayrate500msapprox.

OperatingTemperature 0°Cto40°C(32°Fto104°F)

OperatingHumidityMax.75%RH

PowerSupplyTwo1.5VAAAlkalinebatteries

AutomaticPowerOffMetershutsoffautomaticallyafter9seconds

Weight 226g(8.0oz.)

Dimensions172x97x46mm(6.8x3.8x1.8”)

Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176

TestEquipmentDepot.com

Indice

Altri manuali Extech Instruments Termometro

Extech Instruments

Extech Instruments 42545-NIST Manuale utente

Extech Instruments

Extech Instruments HD200 Manuale utente

Extech Instruments

Extech Instruments RHM15 Manuale utente

Extech Instruments

Extech Instruments TM20 Manuale utente

Extech Instruments

Extech Instruments 407907 Manuale utente

Extech Instruments

Extech Instruments TM300 Manuale utente

Extech Instruments

Extech Instruments RH350 Manuale utente

Extech Instruments

Extech Instruments VIR50-NISTL Manuale utente

Extech Instruments

Extech Instruments 42512 Manuale utente

Extech Instruments

Extech Instruments RHT510 Manuale utente

Extech Instruments

Extech Instruments 42545 Manuale utente

Extech Instruments

Extech Instruments TM200 Manuale utente

Extech Instruments

Extech Instruments K.J.E.T. 422324 Manuale utente

Extech Instruments

Extech Instruments 433201 Manuale utente

Extech Instruments

Extech Instruments RH250W Manuale utente

Extech Instruments

Extech Instruments MD13628 Manuale utente

Extech Instruments

Extech Instruments 42510A Manuale utente

Extech Instruments

Extech Instruments AN500 Manuale utente

Extech Instruments

Extech Instruments 42530 Manuale utente

Extech Instruments

Extech Instruments Extech 470 Manuale utente

Extech Instruments

Extech Instruments EasyView EA20 Manuale utente

Extech Instruments

Extech Instruments RHM15 Manuale utente

Extech Instruments

Extech Instruments IRT25 Manuale utente

Extech Instruments

Extech Instruments EA11 Manuale utente

Manuali Termometro popolari di altre marche

Delton

Delton 981A Manuale utente

Baker

Baker MM2P Manuale utente

Tarmo

Tarmo 320281 Manuale utente

Citizen

Citizen CTD 504 Manuale utente

TFA

TFA 14.1500 Manuale utente

Vive

Vive DMD1010 Manuale utente

Gotemp

Gotemp THB4002 Manuale utente

GREISINGER

GREISINGER G 1202 Manuale utente

Amprobe

Amprobe TMD-53W Manuale utente

Trotec

Trotec BP10 Manuale utente

Radiance instruments

Radiance instruments RT616 Series Manuale utente

Eurolec

Eurolec IR151 Manuale utente

Scaneo

Scaneo TS42B Manuale utente

Sper scientific

Sper scientific 800043 Manuale utente

Microlife

Microlife NC 200 Manuale di istruzioni

Motorola

Motorola MBP69SN Guida alla configurazione

The MeatStick

The MeatStick The MeatStick Manuale utente

Hama

Hama TH35-A Manuale utente