METRON PS-416M Guida alla risoluzione dei problemi

1-1

PS-416M

User & Service Manual

PATIENT SIMULATOR

1-2

METRON:

USA FRANCE NORWAY

1345 Monroe NW, Suite 255A 30, rue Paul Claudel Travbaneveien 1

Grand Rapids, MI 49505 91000 Evry, France N-7044 Trondheim, Norway

Phone: (+1) 888 863-8766 Phone: (+33) 1 6078 8899 Phone: (+47) 7382 8500

Fax: (+1) 616 454-3350 Fax: (+33) 1 6078 6839 Fax: (+47) 7391 7009

E-mail: [email protected] E-mail: met[email protected] E-mail: support@metron.no

Disclaimer

METRON provides this publication as is without warranty of any kind, either express or implied, including but not

limited to the implied warranties of merchantability or fitness for any particular purpose. Further, METRON reserves the

right to revise this publication and to make changes from time to time to the content hereof, without obligation to MET-

RON or its local representatives to notify any person of such revision or changes. Some jurisdictions do not allow disclaim-

ers of expressed or implied warranties in certain transactions; therefore, this statement may not apply to you.

Limited Warranty

METRON warrants that the PS-416M Patient Simulator will substantially conform to published specifications and to the

documentation, provided that it is used for the purpose for which it was designed. METRON will, for a period of twelve (12)

months from date of purchase, replace or repair any defective analyzer, if the fault is due to a manufacturing defect. In no

event will METRON or its local representatives be liable for direct, indirect, special, incidental, or consequential damages

arising out of the use of or inability to use the PS-416M Patient Simulator, even if advised of the possibility of such dam-

ages. METRON or its local representatives are not responsible for any costs, loss of profits, loss of data, or claims by third

parties due to use of, or inability to use the PS-416M Patient Simulator. Neither METRON nor its local representatives will

accept, nor be bound by any other form of guarantee concerning the PS-416M Patient Simulator other than this guarantee.

Some jurisdictions do not allow disclaimers of expressed or implied warranties in certain transactions; therefore, this

statement may not apply to you.

Trademarks

Duracell is a registered trademark of Duracell, Inc.

1-3

Table of Contents

MANUAL REVISION RECORD ...................................................................................................... 1-5

1. INTRODUCTION........................................................................................................................ 1-7

1.1 PS-416M Features ................................................................................................................. 1-7

1.2 Specifications......................................................................................................................... 1-7

1.3 General Information .............................................................................................................. 1-9

2. INSTALLATION ....................................................................................................................... 2-11

2.1 Receipt, Inspection and Return............................................................................................ 2-11

3. OPERATING PS-416M............................................................................................................. 3-13

3.1 Control Switches and Terminals.......................................................................................... 3-13

3.2 Use....................................................................................................................................... 3-14

4. CONTROL AND CALIBRATION........................................................................................... 4-17

4.1 Required Equipment............................................................................................................ 4-17

4.2 Preparation........................................................................................................................... 4-17

4.3 Function Testing.................................................................................................................. 4-17

5. COMPONENT FUNCTIONS AND PARTS ........................................................................... 5-21

5.1 Theory of Operation ............................................................................................................ 5-21

5.2 Functions Description.......................................................................................................... 5-21

5.3 Component Parts.................................................................................................................. 5-23

APPENDIX A: DIAGRAMS........................................................................................................... 5-27

Component Location .................................................................................................................... 5-29

Schematic Diagram Part 1 ........................................................................................................... 5-30

Schematic Diagram Part 2 ........................................................................................................... 5-31

APPENDIX B: ERROR REPORT FORM, PS-416M .................................................................. 5-33

APPENDIX C: SUGGESTION FORM, PS-416M........................................................................ 5-35

1-4

This page intentionally left blank.

1-5

Manual Revision Record

This record page is for recording revisions to your PS-416M User and Service Manual that have been pub-

lished by METRON or its authorized representavtives. We recommend that only the management or facil-

ity representative authorized to process changes and revisions to publications:

•make the pen changes or insert the revised pages;

•ensure that obsolete pages are withdrawn and either disposed of immediately, or marked as superseded

and placed in a superseded document file, and;

•enter the information below reflecting that the revisions have been entered.

Rev No Date Entered Reason Signature of Person Entering Change

0 - Initial Release

1-6

This page intentionally left blank.

1-7

1. Introduction

This chapter describes the METRON PS-416M Patient Simulator’s features

and specifications.

1.1 PS-416M Features

METRON’s PS-416M is a high performance simulator designed to simplify

patient monitor testing, and is designed to be used by trained service techni-

cians. It simulates electrocardiogram, respiration, dynamic blood pressure

and static temperature.

It offers three preprogrammed automatic test modes (ECG rate, ECG per-

formance rate, and BP level), plus a built-in ECG lead continuity test. Ar-

rhythmia selection includes two supraventricular, two-conduction; eight ven-

tricular, one paced; and one fetal/maternal ECG simulation.

1.2 Specifications

1. ECG General

Lead Configuration: 12-lead simulation derived from one resistively

divided analog signal.

RL, RA, LA, LL, V1-6

Output Impedance

Limb leads: 500 or 1000 ohms to RL

V Leads: 1000 ohms to RL

High Level Output: 0.5 V/mV of low level (Lead II)

2. Normal Sinus

Rates: 30, 60, 80, 120, 180, and 300 BPM

Rate Accuracy: ± 1% of selection

Amplitudes: 0.5mV, 1.0mV, 1.5mV and 2.0mV (Lead II)

Amplitude Accuracy: ± 5%. (Lead II 1.0mV)

Automatic ECG Rate Test

3. Manual ECG Performance Test

Square Wave: 2.0Hz 1.0 V p-p biphasic

DC pulse: 4.0 sec. 1.0 mV

Sine Waves: 0.1, 0.5, 10, 40, 50, 60 and 100 Hz

Triangle Wave: 2.0 Hz

Amplitude: 0.5mV, 1.0mV, 1.5mV and 2.0mV (Lead II)

Amplitude Accuracy: ± 5%. (Lead II 1.0mV)

4. Automatic ECG Performance Test

1-8

Gain/Damping: 2 Hz square wave

Frequency Response

Low Frequency: 4 second DC pulse

Band Pass: 10 Hz sine

Monitor: -3dB point: 40 Hz sine

Power Line Notch Filter: 50 Hz sine

Linearity: 2 Hz triangle wave

5. ECG Lead Test

Display flashes if lead resistance is <3 kOhms (DC lead wire only)

6. Blood Pressure General

Input/Output Impedance: 300 Ohms

Exciter Voltage Range: 2 to 16 volts

Exciter Frequency Range: DC to 4000 Hz

Output Sensitivity: 5 or 40 µV/V/mmHg

Accuracy: ± 1% full scale 1 mmHg

Calibrated Rate: 80 BPM

7. Dynamic Blood Pressure Selections

Atmosphere: 0 mmHg

Arterial: 120/80 mmHg

Left Ventricle: 20/0 mmHg

Right Ventricle: 25/0 mmHg

Pulmonary Artery: 25/10 mmHg

Pulmonary Wedge: 10/2 mmHg

Static Levels: 0, 20, 40, 80, 100, 200, 250, 300 mmHg

8. Arrhythmia Selections

Atrial Fibrillation 1 & 2

Premature Atrial Contraction

Premature Ventricular Contraction (PVC)

Early PVC

R on T PVC

Multifocal PVCs

Bigeminy

Bigeminy Run of 5 PVCs

Ventricular Tachycardia

Ventricular Fibrillation

Second Degree Type 2

Right Bundle Branch Block

Asynchronous Pacemaker

Fetal/Maternal ECG

1-9

9. Respiration

Normal Physiological Simulation

Baseline Impedances: 500 to 1000 Ohms

Impedance Variations: 0.1, 0.2, 0.5, 1.0, and 3.0 Ohms

Rates: 0 (Apnea), 15, 20, 30, 40, 60, 120 BPM

Output Configuration: Lead 1, 11, RL-LL

10. Temperature

30°C / 86°F, 37°C / 98.6°F, 40°C / 104°F

Compatible with YSI 400/700 series.

Accuracy: ± 0.25°C

1.3 General Information

Display/Control: 2-digit numeric display keys

5 switches for BP, respiration, temperature and

Power On/Off

ECG Output Connectors

High Level: Standard phone jack

Low level: 10 AHA color-coded standard safety banana con-

nectors with detachable banana to snap adapter.

Power: 9 V alkaline battery or battery eliminator

Case: High impact plastic

Weight: 0.5 kg / 1.1 lbs.

Dimensions: Height: 47 mm / 1.8 in.

Width: 138 mm / 5.4 in.

Length: 190 mm / 7.5 in.

Standard Accessories: PS-416M Patient Simulator (P.N. 17020)

110 V or 220 V AC Adapter (P.N. 17021)

Carrying Case (P.N. 17022)

Snap-to-Banana Adapters (10pk) (P.N. 17023)

User and Service Manual PS-416M (P.N. 17025)

Optional Accessories: Unterminated or prewired BP Cable (P.N. 17440)

Unterminated or prewired 400/700

YSI-series Temperature Cable (P.N. 17443)

1-10

This page intentionally left blank.

Indice

Altri manuali METRON Strumento di misura

METRON

METRON QA-90 Guida alla risoluzione dei problemi

METRON

METRON QA-45 Guida alla risoluzione dei problemi

METRON

METRON QA-1290 Guida alla risoluzione dei problemi

METRON

METRON QA-ES Guida alla risoluzione dei problemi

METRON

METRON daeg SPO2 Manuale utente

Manuali Strumento di misura popolari di altre marche

Suaoki

Suaoki D40 Manuale utente

Elster

Elster BK-G1.6 Manuale utente

Endress+Hauser

Endress+Hauser Deltabar FMD71 Manuale

Duratool

Duratool D03128 Manuale utente

Vega

Vega VEGAPULS 65 Manuale utente

Tonghui

Tonghui TH2618B Manuale utente

Tenmars

Tenmars TM-801 Manuale utente

MSR

MSR 145 Manuale utente

TPS

TPS WP-82 Manuale utente

ELMETRON

ELMETRON CP-511 Manuale utente

PCB Piezotronics

PCB Piezotronics 003C30 Manuale utente

Tenma

Tenma 72-10465 Manuale utente

Endress+Hauser

Endress+Hauser Proline Promag 50 Specifiche tecniche

Siemens

Siemens SITRANS F Coriolis FCT030 Manuale elenco delle parti

KLINGER

KLINGER CMF V Series Manuale utente

EXFO

EXFO FTB-2 Manuale operativo e di manutenzione

Keysight

Keysight M8290A Manuale utente

ADTEK

ADTEK MW-5 Manuale utente