Philips GC2810 Manuale utente
ServiceManual
Philips Consumer Lifestyle
Published by Philips Domestic Appliances and Personal Care Printed in the Netherlands © Copyright reserved Subject to modification
Steam Iron Power Life Successor
GC2810
10/08
PRODUCT INFORMATION
Features
- Colour: Blue
- Powerglide soleplate coating
- Pointed tip soleplate
- Steam output: 30 g/min
- Steam boost: 90 g/min
- Steam level control: 3 settings
- Drip stop system
- Spray feature
- Tank capacity: 270 ml
- Cord length: 2 m
- 360 degrees ball swivel
- Filling door
- Calc clean feature
Safety Information
- This product meets the requirements regarding
interference suppression on radio and TV.
- After the product has been repaired, it should function
properly and has to meet the safety requirements and
legal regulations as officially laid down at this moment.
TECHNICAL INFORMATION
Voltage : 220 - 240 V
Frequency : 50 - 60 Hz
Power : 2000 W
Dimension (F-box) : 328 mm x 129 mm x 163 mm
(Width x Depth x Height)
Product net weight : 1.175 kg
Water Advice
In case you live in an area with hard water (e.g. water hardness
more than 8 dGH), it is recommended to use a mixture of
50 % tap water and 50 % demineralized water.
Powerglide Soleplate
Silver solgel coating for more robust scratch resistance,
smooth gliding & easy to clean.
Pointed Tip
This feature allows soleplate to reach tricky area.
Steam Boost
The steam boost helps to remove stubborn wrinkles.
Drip Stop
The water tank bottom has a valve that is controlled by
a bimetal disc on the soleplate. Water is only released
into steam chamber via the tank valve when the soleplate
temperature is high enough. When the soleplate temperature
is too low, the tank valve is closed. This prevents water from
dripping onto the garment.
Calc Clean Function
This function flush scale particles out of the iron, hence iron
enjoy longer life.
GC2810
2-5
DISASSEMBLY ADVICE
BACKPLATE 19
CORDSET 22
BALL SWIVEL 20
Remove screw A
Disassemble BACKPLATE 19
Disconnect 3x quick-connectors of CORDSET 22
Disassemble CORDSET 22
FILLING DOOR ASSY 18
INLAY PRINTED 17
SOS KNOB 15
SPRAY KNOB 16
SPRAY PUMP 9
SOS PUMP 10
LAMP ASSY 5
Disassemble FILLING DOOR ASSY 18
Remove screw B
Release rear catch of INLAY PRINTED 17
Disassemble INLAY PRINTED 17
Disconnect 2x quick-connectors of LAMP ASSY 5
Disassemble LAMP ASSY 5
THERMOSTAT DIAL PRINTED 21
WATER TANK ASSY 7
COVER 3
INSULATION SHEET 23
DOSING SEAL 13
SOS SEAL 14
SOLEPLATE MOUNTED ASSY 1
Disassemble THERMOSTAT DIAL PRINTED 21
Remove screws C (3x)
Disassemble WATER TANK ASSY 7
Remove screws D (3x)
Disassemble COVER 3
Note for re-assembly:
Please ensure that INSULATION SHEET 23 is put in place
during re-assembly.
This metal part acts as a heat sink to prevent softening of COVER
3 plastics at the screw location D1.
GC2810
3-5
REPAIR INSTRUCTIONS
- Due to the high wattage of the iron, only the specified cord set must be used.
- Should damage be observed on the CORDSET 22, it must be replaced.
Continued usage is not allowed.
- After the product has been repaired, it should function properly and has to meet the safety requirements & legal regulations as
laid down & officially established at this moment.
- The following tests are common checks that are conducted on a repaired product before it is returned to the consumer.
1. Soleplate temperature
Check that soleplate temperature is within IEC requirement.
Measure the temperature of the soleplate after the iron has reached steady state i.e connected to the mains for at least 15 minutes.
The table below shows the temperature requirement.
Marking
Soleplate temperature (Deg C)
Material, for example
Test-
point
==
Minimum Maximum Nominal + Tolerance
•(1 dot) 70 120 95 ± 25 Acetate, elastane, polyamide, polyproylene
•• (2 dots) 100 160 130 ± 30 Cupro, polyester, silk, triacetate, viscose, wool
••• (3 dots) 140 210 175 ± 35 Cotton, linen
2. Leakage current
Check that leakage current is within IEC requirement.
Measure leakage current between LIVE/NEUTRAL & EARTH.
IEC requirement is that at 230 V supply, the EARTH leakage current must be less than 0.75 mA.
3. Water leakage / Functionality
Check that there is no water leakage from any part of the product during operation.
Check that the functionality of the product (product dependent) eg. steaming, variable steam, SOS, ASO etc is working properly.
4. Loose part
Check that there are no loose parts eg. extra screw in the product that can cause short-circuit or product malfunction.
GC2810
4-5
PARTS LIST
RESISTOR
LAMP
FUSE
N
L
E
HEATING
UNIT
INPUT
THERMOSTAT
Pos Service code Description
1
2
3
4
5
6
7
13
14
15
16
17
18
19
20
21
22
23
24
4239 021 52820
4239 015 70150
4239 026 34230
4239 026 13220
4239 021 50160
4239 015 55800
4239 021 53760
4239 015 58300
4239 015 58310
4239 026 34450
4239 026 34460
4239 021 50280
4239 021 51910
4239 026 34480
4239 026 34650
4239 021 53730
4239 021 53540
4239 000 08850
4239 000 08670
4239 010 10290
4239 026 34490
Soleplate mounted assy 230 V / 2000 W
Ryton ring
Cover molded
Thermostat bush
Lamp assy
Tank top seal
Water tank assy - GC2810 Korea / Australia
Dosing seal
SOS seal
SOS knob
Spray knob
Inlay printed
Filling door assy
Backplate molded
Ball swivel - Snow white
Thermostat dial printed - Eng / Kor
Thermostat dial printed - Eng
Cord set Korea
Cord set Australia
Insulation sheet
Steam slider
GC2810
5-5
EXPLODED VIEW
B
A
D1 D2
D3
C1
C2
C3
22
19
5
2
1
4
7
20
16
24
15
18
23
3
13
14
6
21
17
Indice
Altri manuali Philips Ferro
Philips
Philips GC3310/02 Manuale utente
Philips
Philips Azur GC4532 Manuale utente
Philips
Philips GC7300 Series Manuale utente
Philips
Philips GC4820 Manuale utente
Philips
Philips GC9500 Series Manuale utente
Philips
Philips HI5915 Manuale utente
Philips
Philips GC7000 Series Manuale utente
Philips
Philips GC7630 Manuale utente
Philips
Philips HI558/02 Manuale utente
Philips
Philips Azur Cordless HI575 Manuale utente
Philips
Philips GC4900 Manuale utente
Philips
Philips HI995/03 Manuale utente
Philips
Philips GC1738 Manuale utente
Philips
Philips HD2581 Manuale utente
Philips
Philips HI5919/30 Manuale utente
Philips
Philips GC6510 Manuale utente
Philips
Philips GC4880 series Manuale utente
Philips
Philips Dry Iron Diva GC135 Manuale utente
Philips
Philips HI5914 Manuale utente
Philips
Philips Diva GC149 Manuale utente
