FDS FD220CV-C-1 Manuale utente

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 1 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Installation and Operation Manual

FD220CV-C-1

22” Panel Mount LCD Display

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 2 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Table of Contents

General Information......................................................................................................................3

Front View......................................................................................................................................3

Additional Information................................................................................................................3

Specifications................................................................................................................................4

Installation Instructions .............................................................................................................4

Power ..............................................................................................................................................4

Wiring Instructions......................................................................................................................5

S-Video and Audio Wiring..........................................................................................................5

VGA Wiring...................................................................................................................................6

Power and Ground Wiring..........................................................................................................7

Rear View with Connectors.........................................................................................................8

Power/Video..................................................................................................................................9

Pinouts ................................................................................................................................... 10-11

Operation Instructions..............................................................................................................12

Button Control.............................................................................................................................12

Technical Drawing.....................................................................................................................13

Technical Support......................................................................................................................14

Instructions for Continued Airworthiness ...........................................................................14

Warranty ......................................................................................................................................15

Log of Revisions.........................................................................................................................16

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 3 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

General Information

The FD220CV-C-1 is a panel mounted 22” monitor. Built with retrofit aircraft integration in

mind, this display can switch between five video input sources using an infrared remote

control or the buttons located on the top of the unit.

Front View

Additional Information

The FD220CV-C-1 features five available video sources: HD-SDI In-Out, DVI-D, Industry

Standard VGA (computer graphics i.e. moving maps), S-Video (via BNC connectors for Y

and C components), and Composite Video (via BNC connector).

The LCD is protected with a .060” thick anti-glare, anti-abrasion Lexan lens to prevent

scratching of the LCD, and to meet stringent FAA abrasive load criteria.

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 4 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Specifications

Display Type

21.5” TFT Color LCD

Display Color

16.7 Million Colors

Screen Resolution

1920 x 1080

Brightness

300 cd/m2

Dimensions

19.5”(W) x 11.5” (H) x 1.675”(D)

Display Size

18.75”(W) x 10.55”(H)

Weight

9.75 Lb.

Power @ Amp

28V DC @ 1.94A Max. Cont. steady-

state

Video Type Supported

NTSC/PAL

Video Sources

HD-SDI (In-Out), DVI-D, Industry

Standard VGA, S-Video, Composite

Screen Control

On Screen Display Menu

Viewing Angle

178° on Both Axis

Materials

Aluminum

Remote Control

IR, included

Pixel Pitch

248.25 x 248.25 mm

Operating Temperature

0-50° C (32-122° F)

Additional Test Certifications

FD220CV: DO-160, Sec 21, Cat M

DO-160 Sec 21, Cat B

CSA –C22.2 No. 228-92/UL1418 -

DO-160, Sec 7, Cat B

Installation Instructions

All cabin equipment, such as the FD220CV-C-1, should be installed on a non-essential bus

and have a dedicated circuit breaker. It is a requirement that a switch be installed in the

cockpit so that the pilot can de-energize the system should it become necessary.

There are (10) 8-32 UNC mounting holes located on the sides and back of the display. Six

mounting points are located on the rear and two on each side of the bezel. See installation

drawing at end of manual for dimensional details.

Power

This is a 28VDC monitor that requires 1.94 Amps of maximum continuous steady-state

power to operate. The unit turns on automatically upon power application.

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 5 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Wiring Suggestions

For balanced signals on twisted pair cables, all shields should be grounded to the

connector at the source, and floating at the display.

Avoid routing video wiring parallel to:

AC wiring

Strobe wiring

DC motor supply cables

Inverter cabling

Or any other potential noise source.

Composite, S-Video, and Audio Wiring

Recommended cable for s-video and audio purposes is PIC 75 Ohm Coax, P/N V76261.

This is a lightweight, flexible, and low signal loss cable which meets FAA flammability

requirements of FAR 23.1359(d), FAR 25.853(a) and FAR 25.869(a)(4).

Similar aviation coaxial cable can be used from other vendors, as well.

Some aircraft are prone to AC noise - we recommend adding to the composite source a 75

Ohm video isolation transformer such as Deerfield Laboratory, Inc. Part No. 162-1

(www.deerfieldlab.com, (650) 632-4090). In most cases this should be added to the video

output of the source.

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 6 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

VGA Wiring

Recommended cable for VGA purpose is ECS P/N 453005. This is a single shielded cable

containing 5 separate coaxial cables, color-coded to match the functions of the wires.

We recommend coax cables be terminated using solder sleeve coaxial cable

terminators such as Raychem Part Number CWT-4174-W122-5/9.

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 7 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Power and Ground Wiring

20 AWG wire is recommended for Power and Ground applications.

This is a 28VDC monitor that requires 3 amps of power to operate. To operate properly this

monitor requires an input voltage of 24-29VDC.

The rated current of the equipment and associated voltage drop should be taken into

consideration when selecting wire gauge. The following example is based on an install with

a 28VDC power system and a total of 50 feet of wire between the circuit breaker, monitor

and ground.

Example: 22 AWG wire has 16.2 Ohms per 1000 feet, this equates to .81 Ohms for 50 feet.

3 Amps of current on .81 Ohms will drop 2.43 Volts.

Resistance of Wire Type M22759/16-**

(** = Gauge)

Gauge (AWG)

OHMS/1000’

26.20

16.20

9.88

4.81

2.02

1.26

.70

Also, use short heavy gauge wire and a clean tight connection for ground.

It is the installer's responsibility to understand the product's requirements to install the

product in compliance with industry standards and safety.

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 8 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Rear View with Connectors

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 9 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Power/Video

Pin out for DB-15 Female Connector (Industry Standard VGA)

Connector P/N: 748364-1 or Equivalent

Crimp Contacts P/N: M39029/58-360 or Equivalent

Number

Description

Red Signal

Green Signal

Blue Signal

N/C

Ground –Horizontal Sync

Red Return

Green Return

Blue Return

N/C

Ground –Vertical Sync

N/C

Horizontal Sync

Vertical Sync

N/C

Document Number:

MAN –FD220CV-C-1

Rev:

Revision Date:

01/10/2017

Page 10 of 16

TECHNICAL SUPPORT

470-239-7421 or FDSAvionics.com

Pin out for 28V PWR –D38999 connector (supplied)

Connector P/N: D38999/26FB5SA or Equivalent

Crimp Contacts P/N: M39029/56-351 or Equivalent

MATING FACE

Description

28VDC Power

28VDC Ground

N/C

Pin out for HD-SDI Input (In-Out Pass Thru)

(Standard BNC –75 OHM) –31-242 (Supplied)

Description

Center

Video Signal

Shell

Video Return

Pin out for S-Video (Luminance - Y Component)

(Standard BNC –75 OHM) –31-242 (Supplied)

Description

Center

Y Signal

Shell

Y Return

Indice

Manuali Monitor popolari di altre marche

Linear Acoustic

Linear Acoustic LQ-1000 Manuale utente

AOC

AOC I2579V Manuale utente

Gateway

Gateway FPD1520 Manuale utente

Furuno

Furuno Mu 120c Manuale utente

Asus

Asus VB171D - 17" LCD Monitor Manuale utente

Dell

Dell S2230MX Istruzioni utente

Philips

Philips 107C64 Manuale utente

Dell

Dell S2409WFP Manuale utente

EverFocus

EverFocus EN-7517E Manuale utente

Panasonic

Panasonic TH152UX1 - 152" PLASMA TV Manuale utente

Dell

Dell Precision 7680 Manuale di istruzioni

LG 50PM1M - - 50" Plasma Panel Manuale utente

Bosch

Bosch DDU 9 Manuale utente

Acer

Acer A231HL Manuale utente

Philips

Philips 86BDL4152T Manuale utente

NEC

NEC AccuSync LCD5V Manuale utente

Emay

Emay SleepO2 Manuale utente

IBM

IBM 6360 Istruzioni per l'installazione