Harmar Mobility AL350 Istruzioni operative

Read and understand this manual thoroughly before

attempting to install or operate the lift. If you have any

questions, please contact your Authorized Harmar Dealer or

Harmar’s Technical Service Department.

P 800-833-0478 | F 866-234-5680 | TECH@HARMAR.COM

Dealer Name & Contact Information:

Serial # of Your Lift:

AL350

Installation & Owner’s Manual www.harmar.com | 800-833-0478

AL350 Hitch-Mounted

Scooter and Powerchair Lift

Capacity: 350 lbs

P/N: 610-00065 Rev A

Contents

NOTE: The following symbols indicate areas where you should take

special care to avoid danger to individuals or property.

Section 1: Owner

OPERATING YOUR LIFT

General Operation.................................3

Using a Swing-Away..............................6

Manual Override.................................... 8

SAFETY & MAINTENANCE

Section 2: Installer

PREPARATION

Tools Required............................................11

Unpacking theLift.....................................12

Installation Overview ...............................13

INSTALLATION

Wiring the Vehicle .....................................15

Vehicle Hitch................................................18

Hitch Adapters........................................... 19

Lift Installation

Hitch Post Mount ................................ 21

Swing-Away ................................................ 23

CHAIR PREPARATION 25

Anchor Plate ......................................... 25

U-Bolt Kit................................................ 26

TROUBLESHOOTING

WIRING DIAGRAM

EXPLODED VIEWS

WARRANTY 35

WARNING

Hazardous situation. If not avoided,

could result in serious injury to

installer or user.

CAUTION!

Hazardous situation. If not

avoided, could result in serious

damage to property.

| www.harmar.com | 800-833-0478

SECTION 1 : OWNER Operating Your Lift

GENERAL OPERATION

1. LOWERING THE LIFT

Insert key and switch to ‘ON’ position.Press

‘DOWN’ on toggle switch. The platform will

unfold. Continue to lower until platform reaches

the ground and becomes level. [Figure 3-1]

DO NOT over-lower to the point where the

vehicle begins to rise. This will damage the lift.

IMPORTANT

Positioning the chair properly on the platform is

critical to ensure it is properly locked onto the lift.

Always verify wheels are captured by cradles

or bars. Please consult your dealer on the specics

of your application.

Figure 3-1

Figure 3-2

2. DRIVE ONTO PLATFORM.

Drive slowly, stopping when the drive wheels fall

between the platform bars if applicable.[Figure

3-2]

AL350 Hitch-Mounted Scooter and Power Chair Lift P/N: 610-00065 Rev A

SECTION 1 : OWNER

Operating Your Lift

3. SECURING THE CHAIR

Ensure Chair or Scooter is Powered Off. You may wish to raise the platform halfway,

using the ‘UP’ toggle switch, in order to avoid having to bend over while you attach

straps.[Figure4-1]

Figure 4-2

4. RAISING THE LIFT

When the chair is secure, use the ‘UP’ toggle

switch to continue raising the lift. Stop when

it reaches the top of travel when you hear the

clutch sound. Twist the key to remove.

[Figure 4-2]

Figure 4-1

| www.harmar.com | 800-833-0478

SECTION 1 : OWNER Operating Your Lift

CAUTION

These are general

instructions. Specics may

vary based on your chair

model and lift combination.

Please follow the specic

instruction suggested by

your dealer.

CAUTION

Always verify the chair or

scooter is held rmly in place

prior to transport.

•Always run the lift fully to the top

for transport. The lift will make a

ratcheting sound which indicates

that all mechanisms are locked and

prepared for travel.

•Never attempt to move the vehicle

without the lift being in the full up or

stowed position. This may damage the lift.

•Drive slowly over rough terrain such as

pot holes, unpaved roads, railroad tracks.

Excessive loads from rough driving will

damage your lift and is not covered by

the warranty.

•If you notice any damage, stop using

the lift immediately. Do not attempt

to transport a chair or scooter with a

compromised lift. Damage to your chair,

lift, vehicle may occur. Take the lift to

your nearest dealer and have it evaluated

prior to further use.

5. UNLOADING THE CHAIR

Insert the key and switch to ‘ON’ position.

Press ‘DOWN’ to lower the lift. Do NOT

continue travel to the point where the

vehicle rises; that will damage the lift.

[Figure 5-1]

Drive the chair o the platform carefully.

When the chair is unloaded, press ‘UP’ and

the platform will automatically fold.

Figure 5-1

AL350 Hitch-Mounted Scooter and Power Chair Lift P/N: 610-00065 Rev A

Remove

Safety

Pull

T-Handle

AL105 AL105L

Remove

Safety

Pull

T-Handle

AL105 AL105L

SECTION 1 : OWNER

Operating Your Lift

SWING-AWAY

The Swing-Away allows you to easily swing the

installed auto lift away from the back of the

vehicle for convenient access to the trunk or lift

gate. The Swing-Away option can be purchased

from an authorized dealer and added at any time.

NOTE: Two Swing-Away models areavailable,

a standard AL105and the lightweight

AL105L. They work basically the same way

but the parts differ slightly as noted in

[Figure 6-3].

Figure 6-2

WARNING

NEVER open the Swing-Away

with the chair on the lift.

You will damage the Swing-

Away and the lift. It will

potentially damage the vehicle

and the chair. Any of these

actions will VOID your warranty.

Figure 8-4

Remove

Safety

Pull

T-Handle

AL105 AL105L

Remove

Safety

Pull

T-Handle

AL105 AL105L

Figure 6-3

Figure 6-5

OPENING THE SWING-AWAY

1. Remove Safety Pin [Figure 6-3]

2. Pull T-Handle [Figure 6-4]

•Grasp the lift rmly and swing it out, away

from the vehicle. The Swing-Away can be

opened up to 180 degrees from the closed

position to allow full access to the

vehicle’s cargo area. [Figure 6-5]

WARNING

Figure 6-1

Open ONLYon Level Ground

Failure to open on level

ground may result in losing

control of the lift, resulting in

personal injury or damage to

property.

| www.harmar.com | 800-833-0478

SECTION 1 : OWNER Operating Your Lift

CLOSING THE SWING AWAY

Close the Swing-Away unit as you would a

car door.

WARNING

Stay clear of the latching

mechanism

Figure 7-1

SAFELY CLOSED WRONG

Figure 7-2

Figure 7-3

WARNING

Always install the safety pin.

CAUTION

Verify that the T handle has

fully retracted.

AL350 Hitch-Mounted Scooter and Power Chair Lift

Figure 7-4

P/N: 610-00065 Rev A

VEHICLE HARNESS

LIFT HARNESS

VEHICLE HARNESS

LIFT HARNESS

REMOVE

3/8”

Turn COUNTER -

CLOCKWISE

to LOWER platform.

Turn CLOCKWISE

to RAISE platform.

SECTION 1 : OWNER

Operating Your Lift

Figure 8-1

Figure 10-2

Figure 8-2

MANUAL OVERRIDE

IMPORTANT!

You MUST unplug the two-connector plug BEFORE

any attempt to use the Manual Override. Failure to

do so result in serious injury.

WARNING

Disconnect power from lift

BEFORE attempting manual

override.

1. Unplug Power to the Lift. [Figure8-1]

2. Remove the cap on top of the motor.

[Figure 8-2]

3. Insert a 3/8” socket wrench into the

actuator and rotate the Hex Shaft. [Figure 8-3]

Figure 8-3

In the event of a power failure, for example

if your car battery dies, your lift can still

operate using the Manual Override system.

4. Turn COUNTER-CLOCKWISE to LOWER

the platform. [Figure 8-4]

5. Turn CLOCKWISE to RAISE the platform.

[Figure 8-4]

Figure 8-4

| www.harmar.com | 800-833-0478

CAUTION

SECTION 1 : OWNER Safety & Maintenance

SPECIAL CAUTIONS

• Beware of pinch points. These

are areas ofmechanical objects

with moving parts than can catch

extremities or clothing. Donotplace

fingers, extremities or allow clothing

near such points.

• Keep hands, feet and objects away

from Platform as it Lowers.

• Keep chair tires properly inated.

Improper inflation will change how the

chair fits and secures on the platform,

and changes the clamping pressure.

• Secure chair rmly before driving.

Double-check that is it secured

properly tothe platform before you

transport it.

•Inspect the lift condition often. If

ANY parts are worn or damaged, DO

NOT USE THE LIFT. Immediately contact

the dealer you purchased the lift from

for repairs.

•Do Not Enter Steep Driveways

Straight On. Enter and leave at an

angle to the street so that the lift does

not drag on the ground.

• Do Not Move the Vehicle with

Platform Down. If you move with the

platform in the down position, you will

damage the lift mechanism.

• Hand Wash or Use Touchless

Automatic Car Wash only. To

prevent lift damage do NOT use

automatic wash systems.

SAFETY & MAINTENANCE

WARNING!

This lift is NOT meant for human transport. The chair or

scooter MUST be unoccupied before operating the lift. Each

lift is designed to transport a specic chair only. DO NOT

attempt to move any mobility devices, objects, people, or

materials other than those for which the lift was designed.

CAUTION!

Drive with EXTREME CARE while transporting your chair or

scooter on the lift. DRIVE SLOWLY over rough terrain such as

pot holes, unpaved roads, railroad tracks. Excessive bumping

creates stress on the lift and vehicle and can badly damage

your lift, vehicle, and mobility device.

AL350 Hitch-Mounted Scooter and Power Chair Lift

Figure 9-1

P/N: 610-00065 Rev A

ESAERG ESAERG

ESAERG

SECTION 2 : INSTALLER

Safety & Maintenance

CAUTION!

Drive the scooter o

in REVERSE. When the

scooter is clear of the

platform, raise the

platform by pushing up

on the UP/DOWN switch.

MAINTENANCE

This Outside Lift is designed to be as trouble free as possible;

however, some basic maintenance will ensure that it continues

to oer reliable use for years to come.

Oil pivot points on all moving parts every 30 days.

Re-grease the inside vertical square tube every 30 days in

winter or in dirty or dusty conditions. Just lower the platform

to the ground and clean the tube with mineral spirits, WD-40,

or a good solvent. When clean, grease the square vertical tube

shaft with high grade water-resistant grease such as boat

trailer wheel bearing grease. [Figure 10-1]

Check for paint chips and touch up bare metal. Use a good

gloss black enamel or lacquer to inhibit rust. You may need to

do this more frequently if your lift is subject to salt air or road

salt in the winter.

Figure 10-1

| www.harmar.com | 800-833-0478

Indice

Altri manuali Harmar Mobility Sistema di sollevamento

Harmar Mobility

Harmar Mobility VPL400-X Manuale utente

Harmar Mobility

Harmar Mobility Pinnacle SL600 Manuale utente

Harmar Mobility

Harmar Mobility AL6000 Manuale utente

Harmar Mobility

Harmar Mobility AL625 Istruzioni operative

Harmar Mobility

Harmar Mobility CPLP400 Istruzioni per l'installazione

Harmar Mobility

Harmar Mobility AL100-DE Manuale utente

Harmar Mobility

Harmar Mobility IL500 Sierra Inclined Platform Lift Supplemento

Harmar Mobility

Harmar Mobility AL030 Istruzioni operative

Harmar Mobility

Harmar Mobility AL625HD Istruzioni operative

Harmar Mobility

Harmar Mobility AL010 Supplemento

Harmar Mobility

Harmar Mobility Pinnacle SL600 Supplemento

Harmar Mobility

Harmar Mobility AL215 Axis I Istruzioni operative

Harmar Mobility

Harmar Mobility HIGHLANDER EPL400 Istruzioni per l'installazione

Harmar Mobility

Harmar Mobility AL600 Pioneer Istruzioni per l'installazione

Harmar Mobility

Harmar Mobility Highlander RPL400 Manuale utente

Harmar Mobility

Harmar Mobility VPL400-X Supplemento

Harmar Mobility

Harmar Mobility Single-Fold Ramp Istruzioni per l'installazione

Harmar Mobility

Harmar Mobility AL055 Istruzioni operative

Harmar Mobility

Harmar Mobility Highlander CPL400 Istruzioni per l'installazione

Harmar Mobility

Harmar Mobility Pride Outlander Series Manuale utente

Harmar Mobility

Harmar Mobility HIGHLANDER II Supplemento

Harmar Mobility

Harmar Mobility AL030 Istruzioni operative

Harmar Mobility

Harmar Mobility AL815CC Istruzioni operative

Harmar Mobility

Harmar Mobility HELIX Manuale utente

Manuali Sistema di sollevamento popolari di altre marche

morse

morse 82H-124 Manuale utente

Braun

Braun NL955 Series Manuale utente

haacon

haacon 1889.10 Manuale utente

Protekt

Protekt AT 252 Manuale utente

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Manuale utente

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Manuale utente

Genie

Genie Z-60/34 Manuale utente

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Manuale utente

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Manuale utente

Custom Equipment

Custom Equipment Hy-Brid 3 Series Manuale di programmazione

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Manuale di programmazione

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Manuale di programmazione

BERG

BERG BeNomic EasyLeaf Manuale utente

Powermate

Powermate LiftGate LG-3 Manuale utente

Snorkel

Snorkel TM12 Series Manuale utente

Terberg

Terberg OMNIDEKA Manuale utente

Rotary

Rotary SPO16 Manuale utente

Ricon

Ricon Mirage F9T Manuale utente