Multiplex FreshBlender Manuale utente

Instruction Sheet Subject: FreshBlender Caster Brake Retrofit

SCOPE: ALL MULTIPLEX FRESHBLENDER UNITS

1 of 3

 DocumentNumber:020008727 April14,2021

MULTIPLEX

645 PARK EAST BLVD SUITE 5, NEW ALBANY, IN 47150

844-724-CARE

WWW.MULTIPLEXBEVERAGE.COM

Refreshing the Experience

TwopeoplearerequiredtocompletethisCasterBrake

Retrofit.

TOOLS REQUIRED

• Clean5-gallonbucket

• FreshBlenderDoorKey

• Six(6)Boards,2”x4”boardscutto2’lengths(5cmx

10cmcutto61cmlengths)

• 14mmWrench

• 14mmSocketandDriverorCordlessImpactDrill

PARTS REQUIRED

• BlueLocTite

• 020008731CasterBrakeRetrofitKit(kitpartslisted

below)

PART NO. DESCRIPTION QTY

020008728 BrakeHardwareSet 2

020008727 Instructions 1

BrakeHardwareshownbelow(doesnotincludewheelfork):

NUT

BRAKE BRACKET

BRAKE PEDAL

WAVE WASHER

BOLT

nWarning

NeverleaveunitunattendedduringCasterBrakeRetrofit.

nWarning

Unitisheavy.DoNOTattempttoliftbyhand.

,Caution

Do NOT use a pry bar, crowbar or other sharp ended

objecttoleverageunitup.Sharpobjectswilldamageunit

refrigerationsystem.

REMOVE OLD HARDWARE

1. Pullunit12”(31cm)awayfromwall.

2. Place5-gallon(20liter)bucketunderdrain.

3. Unlockdoor.

4. Openlowerrefrigerationdoor.

5. Stackthree(3)2x4’s(5cmx10cm)flatonthefloor

perpendiculartotherightsideofunit.Positionthese

boards1”(2.5cm)behindtherearofcaster.Thesethree

(3)boardswillbeusedtosupporttheunit.

6. Stacktwo(2)boards6”(15cm)awayandparallelto

frontofunit.Theseboardswillbeusedasafulcrumto

liftfrontofunit.

7. Slideone(1)board3”(8cm)underfrontofunitandlay

perpendicularontopoftwo(2)boardslayinginfront

ofunit.Thisboardwillbeusedasalevertoliftfrontof

unit.

8. Makesurelowerrefrigerationdoorisopen.Doormust

beopentopreventdamagetodoorandunit.

9. Onepersonshouldcarefullysteponendofleverwhile

secondpersonslidesthethree(3)boardstackunder

unit.

10.Verifythethree(3)boardstackisstableandexcessive

lengthofboardscanbeseenonbothsidesofunit.

2 of 3

DocumentNumber:020008727 April14,2021

Subject:FreshBlenderCasterBrakeRetrofit

11.Gentlyreleasepressurefromleveruntilunitrestson

three(3)boardstack.Removeandsetasideleverand

fulcrumboards.Closelowerrefrigerationdoor.

12.Testunitforstability.

13.Removeoldhardware.

A. Placewrenchoncasterboltandplacesocketon

casternut.

B. Turnsockettoremovenutwhileusingwrenchto

holdbolt.Removebolt,nutandwheel.

INSTALL NEW BRAKE

14.PlaceWaveWasherontoBolt.

PlaceBrakeBracketoverwheelfork.VerifytabonBrake

Bracketisinsertedintoslotonwheelfork.

15.PlaceBrakePedalontoBrakeBracket.

16.Insertoldcasterwheelbetweenforksandpressboltinto

assemblyasshownbelow.

3 of 3

DocumentNumber:020008727 April14,2021

Subject:FreshBlenderCasterBrakeRetrofit

17.Place1-2dropsofBlueLocTiteontonutthenthreadnut

ontobolt.

18.Placewrenchoncasterboltandplacesocketoncaster

nut.Turnsockettoinstallnutwhileusingwrenchto

holdbolt.EndofBoltshouldbeflushwithendofnut.

DoNOTovertighten.WithBrakePedalinOFFposition,

wheelshouldturn.

19.Repeatsteps13-18forinstallingbrakehardwarefor

otherfrontwheel.

20.Stacktwo(2)boards6”(2.4cm)awayandparallelto

frontofunit.Theseboardswillbeusedasafulcrumto

liftfrontofunit.

21.Slideone(1)board3”(1.2cm)underfrontofunitand

layperpendicularontopoftwo(2)boardslayinginfront

ofunit.Thisboardwillbeusedasalevertoliftfrontof

unit.

22.Openlowerrefrigerationdoor.Doormustbeopento

preventdamagetodoorandunit.

23.Onepersonshouldcarefullysteponendofleverwhile

secondpersonslidesthethree(3)boardstackoutfrom

underunit.

24.Gentlylowerunitandremoveboards.

25.Testeachnewcasterbrakeassembly.Adjustif

necessary.

26.Closelowerrefrigerationdoorandlockunit.

27.Removedrainbucket.

28.Pushunitintoplace.

29.Connectdrain.

Altri manuali per FreshBlender

Altri manuali Multiplex Utensili

Multiplex

Multiplex Merlin Tuning Manuale utente

Manuali Utensili popolari di altre marche

Martor

Martor SECUNORM 175 Manuale utente

ERKCO

ERKCO 1000 Manuale utente

jbc

jbc N4473 Manuale utente

FEINMETALL

FEINMETALL FZWZ-SET-001 Manuale utente

Worx Professional

Worx Professional Sonicrafter WU676 Manuale utente

Gage Bilt

Gage Bilt GB713SH Manuale utente

Hilti

Hilti DX 9-ENP Manuale utente

norbar

norbar NORTRONIC 34399 Manuale utente

BGS technic

BGS technic 8578 Manuale utente

Makita

Makita DHR241 Manuale utente

Motor Guard

Motor Guard JMB-1250 Manuale utente

Power Adhesives

Power Adhesives 805-12 Manuale utente

Clemco

Clemco 24189 Manuale utente

VVG

VVG VNG 903 Series Manuale utente

Hilti

Hilti FX 3-A Manuale utente

Grizzly

Grizzly H6472 Manuale utente

axing

axing BWZ 5-02 Manuale utente

Dh-Robotics

Dh-Robotics RGI-100 Come usare